Waring WJX80 User manual

WJX80

PULP-EJECT JUICE EXTRACTOR

EXTRACTOR DE JUGO

CON SEPARADOR DE PULPA

CENTRIFUGEUSE

AVEC SÉPARATEUR DE PULPE

For your safety and continued enjoyment of this product,

always read the instruction book carefully before using.

Para su seguridad y para disfrutar plenamente de este producto,

siempre lea cuidadosamente las instrucciones antes de usarlo.

An que ce produit vous procure en toute sécurité beaucoup de satisfaction,

lire attentivement le mode d’emploi avant de l’utiliser.

For your safety and continued enjoyment of this product, always read

the instruction book carefully before using.

IMPORTANT SAFEGUARDS

When using electrical appliances, basic safety precautions should

always be taken, including the following:

1. READ ALL INSTRUCTIONS.

2. Always use the appliance on a dry, level surface.

3. Do not push produce into the feed chute with your ngers.

Always use the food pusher provided.

4. Do not touch the small cutting blades in the base of the

stainless steel lter basket.

5. Do not leave the juice extractor unattended when in use.

6. This appliance should not be used by or near children or

individuals with certain disabilities.

7. Always make sure the juice extractor is properly and completely

assembled before operating. The unit will not turn on unless

properly assembled.

8. Always disconnect the juice extractor from the power outlet

when not in use or before moving the appliance, putting on or

removing parts and cleaning.

9. Always make sure juice extractor cover is securely in place

before motor is turned on. Do not turn lid while juicer is in

operation.

10. Be sure to turn switch to OFF position after each use. Make

sure the motor stops completely before disassembling.

11. Do not put your ngers or any other object into the juicer

opening while it is in operation. If food becomes lodged in the

opening, use food pusher or another piece of fruit or vegetable

to push it down. When this method is not possible, turn the

motor off and disassemble juicer to remove the remaining food.

12. Do not operate any electrical appliance with a damaged cord or

plug or after the appliance has malfunctioned or been damaged

in any manner.

If damaged, immediately stop use and call Waring®Customer

Service at (800) 269-6640, in the United States, for examination,

adjustment or repair.

13. Do not let the cord hang over the edge of the table or counter,

or touch hot surfaces or become knotted.

14. Do not place this appliance on or near a hot gas or electric

burner, or where it could touch a heated oven.

15. For any maintenance in the United States, other than cleaning,

call (800) 269-6640.

16. This appliance has a 3-prong grounded plug. To reduce the

risk of electric shock, this plug is intended to t into a grounded

outlet only one way. If the plug does not t, contact a qualied

electrician. Do not attempt to modify the plug in any way.

17. To protect against risk of electric shock, do not put motor, unit

housing or power cord in water or other liquids.

18. Avoid contact with moving parts.

19. The use of attachments not recommended or sold by the

manufacturer may cause re, electric shock or injury.

20. Do not use outdoors.

21. Do not use the appliance if the lter basket is damaged.

22. This appliance is not intended for use by persons (including

children) with reduced physical, sensory, or mental capabilities,

or lack of experience and knowledge, unless they have

been given supervision or instructions concerning use of the

appliance by a person responsible for their safety.

23. Children should be supervised to ensure that they do not play

with the appliance.

24. To avoid risk of injury, do not carry the unit by the locking arm.

The locking arm is not a handle.

25. A copy of this manual can be downloaded at

waringcommercialproducts.com.

SAVE THESE INSTRUCTIONS

APPROVED FOR

COMMERCIAL USE

CONTENTS

Important Safeguards ........................................................................2

Grounding Instructions.......................................................................4

Extension Cords.................................................................................5

Introduction ........................................................................................5

Features and Benets ........................................................................5

Parts and Accessories .......................................................................6

Assembling.........................................................................................7

Operating Instructions........................................................................7

Manual Thermal Protection ................................................................8

Disassembling....................................................................................9

Cleaning & Maintenance ....................................................................9

Troubleshooting................................................................................10

Vegetables and Their Vitamin and Mineral Content......................... 11

Fruits and Their Vitamin and Mineral Content..................................12

Warranty ...........................................................................................13

GROUNDING INSTRUCTIONS

This appliance must be grounded while in use to protect the operator

from electric shock. The appliance is equipped with a 3-conductor

cord and 3-prong grounding-type plug to t the proper grounding-

type receptacle. The appliance has a plug that looks like the plug

in drawing (1 ). An adapter, as in drawing (2), should be used for

connecting the appliance plug to two-prong receptacles. The

grounding lug, which extends from the adapter, must be connected

to a permanent ground such as a properly grounded outlet box, as

shown in drawing (3), using a metal screw.

GROUNDING METHOD

EXTENSION CORDS

Use only 3-wire extension cords which have 3-prong grounding-type

plugs and 3-pole cord connectors that accept the plug from the

appliance. Use only extension cords that are intended for indoor use.

Use only extension cords having an electrical rating not less than

the rating of the appliance. Do not use damaged extension cords.

Examine extension cord before using and replace if damaged. Do not

abuse extension cord and do not yank on any cord to disconnect.

Keep cord away from heat and sharp edges.

INTRODUCTION

Thank you for purchasing the Waring®Commercial Pulp Eject Juice

Extractor for your business.

Raw juices derived from fresh fruits and vegetables are invaluable as

an aid in maintaining a balanced diet. Raw juice contains, in its most

natural and complete form, precious vitamins, minerals, bioavonoids

and enzymes. Nutritional authorities claim that raw juice is food in

one of its most easily digestible forms. The Waring®Commercial

Juice Extractor is the result of intensive research and engineering

efforts, and we are sure you will be delighted with its performance.

FEATURES & BENEFITS

• Centrifugal-style juice extractor

• Built for use in smoothie shops, cafes, bars, restaurants, hotels,

healthcare establishments and more

• Safety interlocks ensure machine will only operate when properly

assembled

• Manual thermal protection automatically prevents machine from

overheating under heavy use

• 3-inch juice opening accommodates large fruits and vegetables,

so there is less prep work

• Powerful 1.25 HP motor

• Motor type: brushless induction

• Power: 120 volt, 1000 watts, 5-15 plug type

• Limited Two-Year Motor Warranty, Limited One Year Parts & Labor

PARTS AND ACCESSORIES

Food pusher

Extra-wide feed chute

with 3-inch opening

Top cover

Juice bowl

Stainless steel

lter basket and

shredder disc

Juice spout

Motor housing

Pulp container

(12-quart capacity)

On/Off (I /O) switch

Cleaning brush

Locking arm

ASSEMBLING YOUR WARING®COMMERCIAL

JUICE EXTRACTOR

For your safety, the juice extractor will not operate until the machine

is properly assembled. To assemble this unit, the following steps

must be followed in the order given.

Step 1

Place juice bowl on top of the motor housing.

Step 2

Place the stainless steel lter basket inside the center of the

juice bowl. Make sure it slides into place by pressing rmly and

spinning until it locks into place. To avoid injury, do not press on

shredder disc.

Step 3

Place the top cover onto the housing by aligning the tabs on both

sides. If cover does not t, this means that the lter basket is not

properly seated onto the juice bowl.

Step 4

Lock the top cover into place with the locking arm by lifting arm up

so that it snaps the lid down onto the juicing assembly.

Step 5

Place the pulp container into place to the right of the housing by

sliding it under the top cover. Tilt and push bottom of pulp container

into unit until it is seated properly. NOTE: Unit will not operate if top

cover and pulp container are not properly positioned.

OPERATING INSTRUCTIONS

NOTE: The juice extractor will not operate until the top cover and

pulp container are locked into position.

Step 1

Wash your fruit and vegetables for juicing. NOTE: Most fruit and

vegetables such as apples, carrots and cucumbers will not need to

be cut to size, as they will t into the feed chute whole.

Step 2

Ensure that the juice extractor is correctly assembled and that a juice

collector cup is placed under the spout while juicing.

Step 3

Plug the power cord into a power outlet and turn the machine ON.

Step 4

With the motor running, place food into the feed chute. Using the

food pusher, gently guide food down the chute. To extract maximum

juice, always push the food pusher down slowly. Make sure at area

of food pusher is aligned to at area of feed chute.

NEVER USE FINGERS TO PUSH FOOD DOWN THE FEED CHUTE

OR TO CLEAR THE FEED CHUTE. ALWAYS USE THE FOOD

PUSHER PROVIDED.

Step 5

Juice will ow into the juice cup and the separated pulp will

accumulate in the pulp container. Do not allow the pulp container to

overll, as this may prevent correct operation or damage the unit.

NOTE: The pulp container can be emptied during juicing by turning

the juice extractor to the OFF position, then carefully removing the

pulp container. You can reserve the pulp for soups, sauces or cakes.

Or, you can discard the pulp. Replace the pulp container by tilting it

slightly until it is properly seated under the cover.

Cleanup tip: For easy cleaning, immediately after each use, wash the

juicer’s removable parts with soap under running water to remove

wet, sticky pulp. Removable parts can be air-dried or can also be

cleaned on top shelf of dishwasher.

MANUAL THERMAL PROTECTION

Your juice extractor is equipped with manual thermal protection to

guard the motor from overheating. Should the motor stop running

under heavy use, turn the power switch off and unplug the power

cord. Empty the pulp container and the lter basket of all contents

and allow approximately 5 minutes for the motor to cool down.

Press the reset button located underneath the machine, then plug

the power cord back into the outlet and continue juicing. If your

juice extractor does not function properly following this procedure,

discontinue use and contact Waring customer service.

DISASSEMBLING YOUR WARING®COMMERCIAL

JUICE EXTRACTOR

Step 1

Turn the Waring®Commercial Juice Extractor switch to the OFF

position. Remove the plug from the power outlet.

Step 2

Remove the pulp container by tilting it slightly to remove from base.

Step 3

Unlock the locking arm by pulling it out, away from the top cover,

so that it rests on the side housing.

Step 4

Remove the lid by pulling it up and off the juice bowl and basket.

Step 5

Remove stainless steel lter basket using the metal handles. THE

STAINLESS STEEL FILTER BASKET CONTAINS SMALL, SHARP

BLADES TO CUT AND PROCESS FRUITS AND VEGETABLES. DO

NOT TOUCH BLADES WHEN HANDLING THE FILTER BASKET.

Step 6

Remove juice bowl by lifting it up and off the housing.

CLEANING & MAINTENANCE

For easy cleaning: Rinse removable parts with hot, soapy water

immediately after each use to remove wet pulp. Rinse with clean

water. Allow parts to air-dry or, place removable parts on top shelf

only of dishwasher. The cover, juice bowl, pulp container and lter

basket are dishwasher safe (top shelf only).

Wipe the motor base with a damp cloth. DO NOT IMMERSE

THE MOTOR BASE IN WATER OR ANY OTHER LIQUIDS.

THE CENTER OF THE FILTER BASKET CONTAINS SMALL,

SHARP BLADES TO PROCESS FRUIT AND VEGETABLES

DURING THE JUICING FUNCTION. DO NOT TOUCH BLADES

WHEN HANDLING THE FILTER BASKET, AS BLADES HAVE

SHARP EDGES.

The included cleaning brush is the most effective way to clean the

lter basket. Using the brush, hold the lter basket under cold,

running water and brush from the outside of the basket. Then clean

the lter basket in warm, soapy water. Always treat the lter basket

with care, as it can be easily damaged. Use caution when handling,

as shredder disc is very sharp.

NOTE: To assist with cleaning, soak the stainless steel lter basket

in hot, soapy water for approximately 10 minutes immediately after

juicing is completed. If pulp is left to dry on the lter, it may clog the

ne pores of the lter mesh, thereby lessening the effectiveness of

the juicer.

Discoloration of the plastic may occur with strongly colored fruit and

vegetables. To help prevent this, wash parts immediately after use. If

discoloration does occur, the plastic parts can be soaked in bleach

and water. Using 1 tablespoon of bleach to 1 quart of water, soak

plastic parts for a maximum of 5 minutes, then rinse thoroughly. Do

not soak the lter basket in pure bleach.

TROUBLESHOOTING

ISSUE SOLUTION

Machine will not work

when switched on.

Make sure unit is plugged into proper power

supply source. Make sure all parts are assembled

correctly. Check your circuit breaker or fuse panel

to make sure it is live.

Motor appears to stall

when juicing.

Wet pulp can build up under the cover if the juicing

action is too vigorous. Try slower juicing action by

pushing the food pusher down more slowly.

Machine shuts off while

in use.

Unplug the power cord and allow approximately

5 minutes for the motor to cool down. Plug the

power cord back into the outlet and continue

juicing. If your juice extractor does not function

properly following this procedure, discontinue

use and contact Waring customer service.

Excess pulp builds up

in the lter basket.

Stop the juicing process and turn machine off.

Remove the juicer cover and scrape off pulp. Re-

assemble and begin juicing again. Try alternating

(soft and hard) vegetable and fruit varieties.

Table of contents

Languages:

Other Waring Kitchen Appliance manuals

Popular Kitchen Appliance manuals by other brands

Tayama

Tayama TYG-35AF instruction manual

AEG

AEG 43172V-MN user manual

REBER

REBER Professional 40 Use and maintenance

North American

North American BB12482G / TR-F-04-B-NCT-1 Assembly and operating instructions

Presto

Presto fountain popper instruction manual

Westmark

Westmark 1035 2260 operating instructions

Zanussi

Zanussi ZCG64396XA user manual

HOFFEN

HOFFEN SM-9302M instruction manual

Philips

Philips HD3133 user manual

Ronco

Ronco Beef Jerky User guide and recipes

Hendi

Hendi 470411 user manual

Livoo

Livoo MEN386 user manual

Vogue

Vogue D446 instruction manual

croydon

croydon WR-10313-700 instruction manual

ADE

ADE AUTOMATIC-L operating instructions

Chefman

Chefman RJ43-SQ Series user guide

Vacmaster

Vacmaster VP680 user guide

Jetmaster

Jetmaster 900HG operating instructions