SPI D141 User manual
Manual
SPI Handheld meter D141
SanEcoTec Ltd.
5636 Manotick Main Street
Avive House
Ottawa, Ontario K4M 1B3
Canada
T (Toll Free): 1.877.610.0787
T (Ottawa) : 613.491.0525
F: 613.491.0524
www.sanecotec.com
www.avivewater.com
Contents
SPI HANDHELD METER D141 ................................................................................................................ 1
GENERAL INFORMATION .............................................................................................................. 1
1. INTRODUCTION ........................................................................................................................ 2
2. FUNCTION AND OPERATION ..................................................................................................... 3
3. USE OF HANDHELD METER........................................................................................................ 4
4. SPARE PARTS............................................................................................................................ 5
5. TO START ................................................................................................................................. 6
6. PREPARATION CHEMICALS........................................................................................................ 7
7. USE .......................................................................................................................................... 8
8. SAFETY REGARDS.................................................................................................................... 11
9. MAINTENANCE ....................................................................................................................... 12
10. STORAGE AND TRANSPORT................................................................................................... 12
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 1
General information
The SPI handheld meter is specifically designed to carry out measurements in the field.
With the design there is aimed at a good price/quality ratio for this unit
This handheld meter can be used to measure the following parameters:
Free available chlorine (VBC)
Total chlorine (Tot. Cl)
pH
Hydrogen peroxide (PerO)
Limited warranty
This manual is made with care, although SanEcoTec is not taking any responsibility according the
consequential for any failures made in this manual.
Copyright notice
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or
transmitted, in any form, by any means, electronic, mechanical, photocopying, recording or
otherwise without permission in writing from your supplier.
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 2
1. Introduction
Thank you for buying this handheld meter. This manual is made to help you by installation and use of
your handheld meter. We advise to read this manual with care.
You bought our new handheld meter this handheld meter can be used to measure the following
parameters:
Free available chlorine (VBC)
Total chlorine (Tot. Cl)
pH
Hydrogen peroxide (PerO)
Specifications for these parameters:
Measurments
Liquid
Range
Accuracy
VBC
DPD
0-2 mg/l
+/- 0.03 mg/l
Tot. cl
DPD
0-2 mg/l
+/- 0.03 mg/l
pH
Phenol Red
6.8- 8.0 pH
+/- 0.1 pH
PerO
Peroxide color
0-15 ppm
+/- 0.1 ppm
PerO
Peroxide color
15-100 ppm
+/- 1 ppm
These accuracies are based when you take care of all procedures described in this manual.
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 3
2. Function and operation
2.1 Warnings:
•This handheld meter is not waterproof, so by usage take care of water in the handheld
meter. Let the handheld meter not left in water. Water can cause damage onto the
electronic circuits.
•After using the cuvettes take care the cuvettes are cleaned properly and rinsed with water,
after rinsing they have to be dried.
•Replace the cuvettes back into the hand case so these cuvettes cannot damage. (Damage of
cuvettes cause problems with measurements).
2.2 Technical specifications :
The power for this instrument is made by 3 batteries type AA 1,5V 2500 mAh.
2.3 Performance:
The handheld meter guarantees a high quality, so take care of this meter with highest
responsibility.
With those batteries can be measured for approximately 300 hours continuously.
2.4 Surrounding influence :
During measurements the results can have influence of light so by every measurement you
have to use the 2 caps to close the cuvettes.
During the measurement of pH you have to take care of temperature disturbing. With the pH
measurement made by phenol red the temperature correction is standard at 25ºC.
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 4
3. Use of handheld meter
3.1 Handheld meter description:
Parts of the handheld meter :
1 Display.
2 On/Off. This button is used to activate the handheld meter.
3 Calib. This button is used to zero the blanc measurement.
4 Enter. This button is used to confirm your choice.
5 Menu. This button is used to switch to the different parameters of your
handheld meter.
6 Channel 1. Supplied with a blue led . This channel can be used for measurement of
peroxide and is used as reference (blanc) for chlorine and pH.
7 Channel 2. Supplied with a green led. This channel can be used for measurement of
chlorine and pH and is used as reference (blanc) for peroxide.
1 DISPLAY
2 ON/OFF
3 CALIB.
4 ENTER
5 MENU
6 CHANNEL 1
7 CHANNEL 2
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 5
4. Spare parts
This handheld meter is delivered include:
•1 x hand case
•2 x Caps
•4 x Cuvettes
•100 ml Phenol red with pipette
•1 x graduated cylinder
•50 ml Peroxide reagent (just PerO measurement)
•50 ml DPD 1 (just Cl measurement)
•50 ml Start (just Cl measurement)
•50 ml Totaal 2 (just Cl measurement)
•1 x manual
All these spare parts has to be delivered. All these items can be purchased afterwards.
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 6
5. To start
5.1 Demand of surrounding:
During measurement the results can have bad influence of light so you use 2 caps to cover the
cuvettes during measurement.
5.2 Installation:
Take the handheld meter out of case and check the cuvettes.
5.3 Cleaning cuvettes:
Before every measurement the cuvettes has to be cleaned. The cuvettes you use has to be clean not
polluted and clear. If not, clean cuvettes properly in- and outside has to be dried.
Pollution in cuvettes can cause disturbance of measurements.
SPI –D141 HANDHELD METER
SPI HSPI
V6 20161007 7
6. Preparation chemicals
6.1 DPD 1:
DPD 1 is ready to use solution.
6.2 Start:
Start is a ready to use solution.
6.3 Totaal 2:
Totaal 2 is a ready to use solution
Take care of the tenability of Totaal 2
6.4 Peroxidecolor:
Peroxide color is a ready to use solution
Take care, All above described solutions has to be stored in the refrigerator.
6.4 Phenol red:
Phenol red is a ready to use solution.
It is not necessary to keep it in the fridge.
Table of contents
Other SPI Measuring Instrument manuals
SPI
SPI 11-983-4 Instruction Manual
SPI
SPI SPI-P170 User manual
SPI
SPI 10-702-9 User manual
SPI
SPI 18-010-9 User manual
SPI
SPI ABSOLUTE DIGITAL CALIPER User manual
SPI
SPI 20-186-3 User manual
SPI
SPI DIAL CALIPER User manual
SPI
SPI 10G12 User manual
SPI
SPI 94200 Instruction Manual
SPI
SPI C170 CHLORINE User manual
