PEERLESS PANA-85WM Guide

1 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Model: PANA-85WM

Installation and Assembly:

Wall Mount for Panasonic TH-85PF12U and TH-85VX200U

Landscape

Portrait

Maximum Load Capacity:

270 lb (122 kg)

2 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Table of Contents

Parts List.................................................................................................................................................................................3

Installation to Triple Wood Stud Wall......................................................................................................................................4

Installation to Solid Concrete or Cinder Block ........................................................................................................................5

Installing Tilt Brackets.............................................................................................................................................................7

Mounting and Removing Flat Panel Screen...........................................................................................................................8

IMPORTANT! Read instruction sheet before you start installation and assembly.

• DonotbegintoinstallyourPeerlessproductuntilyouhavereadandunderstoodtheinstructionsandwarnings

containedinthisInstallationSheet.Ifyouhaveanyquestionsregardinganyoftheinstructionsorwarnings,forUS

customerspleasecallPeerlesscustomercareat1-800-865-2112,forallinternationalcustomers,pleasecontact

yourlocaldistributor.

• Thisproductshouldonlybeinstalledbysomeoneofgoodmechanicalaptitude,hasexperiencewithbasicbuilding

construction,andfullyunderstandstheseinstructions.

• Makesurethatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandallattached

hardwareandcomponents.

• NeverexceedtheMaximumLoadCapacity.Seepageone.

• Ifmountingtowoodwallstuds,makesurethatmountingscrewsareanchoredintothecenterofthestuds.Useof

an"edgetoedge"studnderishighlyrecommended.

• Alwaysuseanassistantormechanicalliftingequipmenttosafelyliftandpositionequipment.

• Tightenscrewsrmly,butdonotovertighten.Overtighteningcandamagetheitems,greatlyreducingtheirholding

power.

• Thisproductisintendedforindooruseonly.Useofthisproductoutdoorscouldleadtoproductfailureandpersonal

injury.

• Thisproductwasdesignedtobeinstalledonthefollowingwallconstructiononly;

WALL CONSTRUCTION HARDWARE REQUIRED

 •Wood Stud Included

•Wood Beam Included

•Solid Concrete Included

•Cinder Block Included

•MetalStud   ContactQualiedProfessional

•Brick    ContactQualiedProfessional

•Otherorunsure?   ContactQualiedProfessional

WARNING

3 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

AB C

E JH KG I L

Description Qty. Part #

wallplate 1 201-1697

Btilt plate 1 201-1695

Csupport tube 2 201-1693

Dadapter bracket 2 201-1692

Erectangle cap 4 590-1334

FM8x15mmphillipsscrew 18 520-9257

GM5x8mmphillipsscrew 2 570-0005

H8mmanchor 9 590-0320

I#14x2.5woodscrew 9 5S1-015-CO3

J5/16splitwasher 18 540-9405

K5/16washer 18 540-9406

Llock bracket 2 201-1698

Parts List

4 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Installation to Triple Wood Stud Wall

Useastudndertolocatetheedgesofthestuds.Useofanedge-to-edgestudnderishighlyrecommended.

Basedontheiredges,drawaverticallinedowneachstud’scenter.Placewallplate(A)onwallasatemplate.

Levelplate,andmarkthecenteroftheninemountingholes.Makesurethatthemountingholesareonthestud

centerlines.Drillnine5/32"(4mm)dia.holes2.5"(64mm)deep.Makesurethatthewallplateislevel,secureit

usingnine#14x2.5"woodscrews(I)asshown.

Skip to step 2.

• Installermustverifythatthesupportingsurfacewillsafelysupportthecombinedloadoftheequipmentandall

attachedhardwareandcomponents.

• Tightenwoodscrewssothatwallplateisrmlyattached,butdonotovertighten.Overtighteningcandamagethe

screws,greatlyreducingtheirholdingpower.

• Nevertighteninexcessof80in.•lb(9N.M.).

• Makesurethatmountingscrewsareanchoredintothecenterofthestud.Theuseofan"edgetoedge"studnder

ishighlyrecommended.

• Hardwareprovidedisforattachmentofmountthroughstandardthicknessdrywallorplasterintowoodstuds.Install-

ersareresponsibletoprovidehardwareforothertypesofmountingsituations.

WARNING

5 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

solid concrete

cinder block

Installation to Solid Concrete or Cinder Block

• WheninstallingPeerlesswallmountsoncinderblock,verifythatyouhaveaminimumof1-3/8"(35mm)ofactual

concretethicknessintheholetobeusedfortheconcreteanchors.Donotdrillintomortarjoints!Besuretomount

inasolidpartoftheblock,generally1"(25mm)minimumfromthesideoftheblock.CinderblockmustmeetASTM

C-90specications.Itissuggestedthatastandardelectricdrillonslowsettingisusedtodrilltheholeinsteadofa

hammerdrilltoavoidbreakingoutthebackoftheholewhenenteringavoidorcavity.

• Concretemustbe2000psidensityminimum.Lighterdensityconcretemaynotholdconcreteanchor.

• Makesurethatthewallwillsafelysupportfourtimesthecombinedloadoftheequipmentandallattachedhardware

and components.

WARNING

CUTAWAY VIEW

INCORRECT CORRECT

wall

plate

wall

plate

plaster/

drywall

plaster/

drywall

concrete concrete

Drillholesandinsertanchors(H).

Place plate (A)overanchors(H)andsecurewithscrews(I).

Tightenallfasteners.

concrete

surface

• Tightenscrewssothatwallplateisrmlyattached,

but do not overtighten.Overtighteningcandamage

screws,greatlyreducingtheirholdingpower.

• Nevertighteninexcessof80in.•lb(9N.M.).

• Alwaysattachconcreteexpansionanchorsdirectly

to load-bearing concrete.

• Neverattachconcreteexpansionanchorsto

concretecoveredwithplaster,drywall,orother

nishingmaterial.Ifmountingtoconcretesurfaces

coveredwithanishingsurfaceisunavoidable,

thenishingsurfacemustbecounterboredas

shownbelow.Besureconcreteanchorsdonot

pullawayfromconcretewhentighteningscrews.If

plaster/drywallisthickerthan5/8"(16mm),custom

fastenersmustbesuppliedbyinstaller.

WARNING

Makesurethatwallplate(A)islevel,useitasa

templatetomarkninemountingholes.Drillnine5/16"

(8mm)dia.holestoaminimumdepthof2.5"(64mm).

Insertanchors(H)inholesushwithwallasshownin

gure1.1.Placewallplateoveranchorsandsecure

withnine#14x2.5"screws(I).Level,thentightenall

fastenersasshowning.1.2.

Fig. 1.1

Fig. 1.2

6 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Securetwosupporttubes(C) to tilt plate (B)usingfourM8x15mmphillipsscrews(F),four5/16splitwashers(J),

andfour5/16washers(K).

Securefourrectanglecaps(E) to support tubes (C)asshown.

Landscape Portrait

FJK

Securetwoadapterbrackets(D) to support tubes (C)usingeightM8x15mmphillipsscrews(F),eight5/16split

washers(J),andeight5/16washers(K)tocreatebracketassembly.

NOTE:Besurekeyholespointdown.

FJK

Keyhole

7 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Tomakesurebracketassemblykeyholeareproperlyalignedwithstandoffs,positionbracketassembly

ontodisplaystandoffs.

Removebracketassemblyfrombackofdisplay.

Secure tilt plate (B)ofbracketassemblytowallplate(A)atdesiredtiltangleusingsixM8x15mmphillipsscrews

(F),six5/16splitwashers(J),andsix5/16washers(K).SecureoneM8x15mmphillipsscrews(F),5/16split

washer(J),and5/16washer(K)intoslotoftiltplate(B)asshowninDetail1.

Landscape Portrait

F,J, and K

0°

5°

10°

Slot

Display

MountingSurface

NotShownforClarity

Detail 1

8 of 8 ISSUED: 12-18-09 SHEET #: 125-9090-4 03-24-11

Hookdisplaystandoffsintokeyholeslotsonadapterbrackets(D)ofbracketassembly.

NOTE:Makesurethatstandoffsrestatthebottomofkeyholeslotsasshownindetail2.

Securedisplaystandoffsinkeyholeusingtwolockbrackets(L)andM5x8mmphillipsscrews(G)

asshownindetail3.

Detail 2

Keyhole

DisplayStandoff

Detail 3

Display

MountingSurface

NotShownforClarity

Landscape

Portrait

Detail 2

Detail 3

MountingSurface

NotShownforClarity

Display

Keyhole

DisplayStandoff

Table of contents

Other PEERLESS Rack & Stand manuals

PEERLESS

PEERLESS SGLS01 User manual

PEERLESS

PEERLESS SR1G Guide

PEERLESS

PEERLESS A100IWBMOUNT Guide

PEERLESS

PEERLESS PARAMOUNT PA730 Guide

PEERLESS

PEERLESS Perfect Mount PMF2X2 User manual

PEERLESS

PEERLESS Solid-Point PLB 1 Guide

PEERLESS

PEERLESS LWB375 Guide

PEERLESS

PEERLESS WSP820 Guide

PEERLESS

PEERLESS SOLID POINT PLCM 1 Instruction Manual

PEERLESS

PEERLESS MSA-301 Guide

PEERLESS

PEERLESS JMWS 30 Guide

PEERLESS

PEERLESS Paramount PSP2 Guide

PEERLESS

PEERLESS DMU50SM Guide

PEERLESS

PEERLESS AEC0609 Guide

PEERLESS

PEERLESS HCW101 User manual

PEERLESS

PEERLESS PARAMOUNT PA730 Instruction Manual

PEERLESS

PEERLESS PLT BLK Guide

PEERLESS

PEERLESS LDS 1920U Guide

PEERLESS

PEERLESS Smartmount SWS310/BK Guide

PEERLESS

PEERLESS SmartMount ST 630P Guide

PEERLESS

PEERLESS Smartmount SA752PU Guide

PEERLESS

PEERLESS LCT Series Guide

PEERLESS

PEERLESS WMJ 018 Guide

PEERLESS

PEERLESS PJF2-UNV Guide

Popular Rack & Stand manuals by other brands

Salamander

Salamander Acadia AC/W/L400/WH Assembly instructions

Fohhn

Fohhn VAT-09 Mounting instruction

ricoo

ricoo FS0522 quick start guide

AMSOIL

AMSOIL BMK-22 Installation and service instructions

Kargo Master

Kargo Master 48220 installation guide

Milestone AV Technologies

Milestone AV Technologies SIMPLICITY SLF2 installation instructions

ricoo

ricoo S1222 installation instructions

Ready-Set-Mount

Ready-Set-Mount RSMCM602 instruction manual

VidaBox

VidaBox VB MNT FFS2 installation guide

Welch Allyn

Welch Allyn 48960 Assembly instructions

Arkon

Arkon CM035-ST-2 installation instructions

PROEL

PROEL PLWIN60C user manual

Agilent Technologies

Agilent Technologies E2609B installation guide

Mustang

Mustang MV-ARM4 installation guide

Mounting Solutions

Mounting Solutions WRM-320 manual

Pyle

Pyle PMKSPAD1 manual

ShelterIt

ShelterIt 21208 installation instructions

SPL

SPL RackPack?4 1040 manual 