Extech Instruments SP505 User manual

USER MANUAL

Solar Power Meter

Model SP505

Additional User Manual Translations available at www.extech.com

SP505-en-GB_V1.1 10/18

Introduction

Thank you for selecting the Extech Model SP505 Solar Power Meter. This device measures the

power of solar radiation. Use the SP505 to measure the effectiveness of solar film, measure solar

radiation, check solar insulated windows, check headlight intensity, and find the optimal

incidence angle for solar panels and solar water heaters. This device is shipped fully tested and

calibrated and, with proper use, will provide years of reliable service. Please visit our website

(www.extech.com) to check for the latest version and translations of this User Manual, and for

Customer Support.

Safety

Please read the entire User Manual before operating this device. Use the meter only as specified

and do not attempt to service or open the meter housing. Do not allow children to handle the

meter. Please dispose of batteries and meter responsibly and in accordance with all applicable

laws and regulations. Do not look directly into the sun, damage to your eyes can result.

Meter Description

1. Solar Light Sensor

2. LCD

3. Unit button

4. Zero button

5. Power ON-OFF button

6. Range button

7. Hold button

Note: Battery compartment and tripod mount are located on the

back of the meter

LCD Description

1. Data Hold icon

2. Zero calibration mode

3. Battery status

4. Unit of measure (W/m2or BTU (ft2*h))

5. Measurement display

SP505-en-GB_V1.1 10/18

Operation

Power the Meter

Press the button to turn the meter ON/OFF. If the meter display does not switch ON, please

check the batteries (2 x 1.5V ‘AAA’) in the rear compartment. The meter has an APO feature

where the meter automatically switches off after 10 minutes of inactivity.

Zero the Sensor

Cover the sensor, and press the button to zero the display before use.

Range Selection

Short press the button to toggle the range of the meter. The meter display range toggles

between 0.1 and 1 unit resolution.

Unit Selection

Short press the button to toggle the units between W/cm2 and BTU (ft2*h); the lower

display area will show the selected units.

Data Hold

Short press the button to freeze or unfreeze a reading on the display.

Testing Solar Power

With the meter ON, zero the display and then point the sensor (top of meter) toward the sun

and read the displayed power measurement. A display of ‘OL’ indicates that the measured

power is beyond the range of the meter.

Other Application Examples

Automobile Headlight Measurements

1. Turn on the headlights and short press the power button to power the meter.

2. Face the sensor (top of meter) toward one headlight and then the other, recording each

reading.

3. Turn the high beams on and measure both headlights again, recording the readings.

4. Retain the recorded readings with the vehicle for reference.

5. Short press the power button to power OFF the meter.

Measuring the Solar Insulation of Windows

Use the meter to test the solar film of car windows or the heat efficiency of windows in

residential or commercial properties.

1. Turn on the meter and zero the display before taking a measurement.

2. With the window closed, aim the sensor toward the sun and record the reading.

3. Open the window and aim the device toward the sun, recording the reading.

4. Compare the two values to determine the heat efficiency of the window. Test the windows

at least once a year to monitor efficiency.

SP505-en-GB_V1.1 10/18

Maintenance

Battery Replacement

1. Power OFF the meter.

2. Slide the battery compartment cover off in a downward motion.

3. Replace the two (2) ‘AAA’ 1.5V batteries observing correct polarity. Secure the

compartment cover before using the meter.

Safety: Please dispose of batteries responsibly, never dispose of batteries in a fire, batteries may explode or

leak. If the meter is to be stored for 60 days or more, remove the batteries and store them separately.

Never dispose of used batteries or rechargeable batteries in household waste.

As consumers, users are legally required to take used batteries to appropriate collection sites, the

retail store where the batteries were purchased, or wherever batteries are sold.

Disposal: Do not dispose of this instrument in household waste. The user is obligated to take end-

of-life devices to a designated collection point for the disposal of electrical and electronic

equipment.

Cleaning and Storage

Clean the sensor (top of meter) occasionally with a soft, dry cloth.

Periodically wipe the case with a damp cloth and mild detergent; do not use abrasives or

solvents.

Store the meter in the supplied pouch.

Remove the batteries if the meter is to be stored for more than 60 days.

SP505-en-GB_V1.1 10/18

Specifications

Display

3 ¾ digit LCD display (3999 counts)

Measurements

Solar Radiation Power

Sampling Rate

Approximately 0.25 seconds

Over-range Display

“OL“

Tripod mount

On rear panel

Power

2 x 1.5V ‘AAA’batteries

Battery life

Approx. 50 hours

Automatic power off (APO)

After approx. 10 minutes of inactivity

Operating Temperature/Humidity

5 to 40oC (41 to 104oF) / 80% RH max

Operating Altitude

2000 meters (7000 ft.) maximum

Storage Temperature/Humidity

-10 to 60oC (14 to 140oF) / 70% RH max

Dimensions/Weight

108 x 48 x 23mm (4.3 x 1.9 x 0.9”) /80g (2.8oz)

Safety

For indoor use only. EMC: EN61326 (1997), A1 (1998), A2 (2001);

Pollution degree 2

Electrical Specifications (25±5°C)

Solar Power

Unit

Range

Resolution

Accuracy*

W/m2

0 to 3999

0.1

±10 W/m2or ±5%rdg; whichever is greater

BTU (ft2*h)

0 to 634

0.1

±3 BTU (ft2*h) or ±5%rdg; whichever is greater

*Additional temperature error: ±0.38 W/m2 or ±0.12 BTU ft2*h per °C from 25°C

ISO-9001 Certified

www.extech.com

Table of contents

Other Extech Instruments Measuring Instrument manuals

Extech Instruments

Extech Instruments TKG100 User manual

Extech Instruments

Extech Instruments PH220-C User manual

Extech Instruments

Extech Instruments MO265 User manual

Extech Instruments

Extech Instruments CO10 User manual

Extech Instruments

Extech Instruments LT505 User manual

Extech Instruments

Extech Instruments HT30 User manual

Extech Instruments

Extech Instruments 380360 User manual

Extech Instruments

Extech Instruments HD755-NIST User manual

Extech Instruments

Extech Instruments HD450 User manual

Extech Instruments

Extech Instruments AN100 User manual

Extech Instruments

Extech Instruments 341350A User manual

Extech Instruments

Extech Instruments 480823 User manual

Extech Instruments

Extech Instruments ExStik EC510 User manual

Extech Instruments

Extech Instruments MA160 User manual

Extech Instruments

Extech Instruments SDL730 User manual

Extech Instruments

Extech Instruments 401027 User manual

Extech Instruments

Extech Instruments EMF450 User manual

Extech Instruments

Extech Instruments 461891 User manual

Extech Instruments

Extech Instruments MA150 User manual

Extech Instruments

Extech Instruments CO52 User manual

Extech Instruments

Extech Instruments RH305 User manual

Extech Instruments

Extech Instruments PH100 User manual

Extech Instruments

Extech Instruments SL510 User manual

Extech Instruments

Extech Instruments 461893 User manual

Popular Measuring Instrument manuals by other brands

Suaoki

Suaoki D40 user manual

Elster

Elster BK-G1.6 operating instructions

Endress+Hauser

Endress+Hauser Deltabar FMD71 technical information

Duratool

Duratool D03128 manual

Vega

Vega VEGAPULS 65 Quick setup guide

Tonghui

Tonghui TH2618B Operation manual

Tenmars

Tenmars TM-801 user manual

MSR

MSR 145 user manual

TPS

TPS WP-82 manual

ELMETRON

ELMETRON CP-511 user manual

PCB Piezotronics

PCB Piezotronics 003C30 Installation and operating manual

Tenma

Tenma 72-10465 manual

Endress+Hauser

Endress+Hauser Proline Promag 50 Brief operating instructions

Siemens

Siemens SITRANS F Coriolis FCT030 Function manual

KLINGER

KLINGER CMF V Series instruction manual

EXFO

EXFO FTB-2 Notice

Keysight

Keysight M8290A Getting started guide

ADTEK

ADTEK MW-5 operating manual