Blaupunkt TPMS 3.0 User manual
Enjoy it.
Operating and Installation Instructions
TIRE PRESSURE
MONITORING SYSTEM
TPMS 3.0
Safety Notes
This TPMS (Tire Pressure Monitoring System) has
been manufactured according to established safety
guidelines. However, dangers may still occur if the
safety notes in this manual is not observed. This manual
is intended to familiarize the user with the TPMS’s
important functions. Read this carefully, prior to using
the appliance. Keep this manual in an easily accessible
location. In addition, do observe the instructions of the
devices used in conjunction with this appliance.
Road Safety
Always observe the following notes for road safety:
•
General Safety
•
•
•
•
•
•
•
CAUTIONS
•
This manual may be updated from time to time without
any notice.
Disclaimer
In no event shall Blaupunkt be liable for any direct,
indirect, punitive, incidental, special consequential
damages to property or life and whatsoever arising out
of or connected with the use or misuse of our products.
USA & CANADA: This product is not intended for sale in
the United States and Canada. If purchased in the U.S. or
Canada, this product is purchased on as-is basis. No
warranty, whether expressed or implied is provided in
the U.S. or Canada.
1
Device must be used in a way that compliments
the safety of the user when driving the vehicle. It
is recommended for the user to park at an appro-
priate location when examining the tires in case of
abnormal alert.
Device is intended for installation and operation in
a vehicle with 12V vehicle system outage, hence the
device must be installed 300mm away from the head
unit to prevent signal disruption.
Do not dismantle or modify the device. Installation or
repair should be performed by a specialist. Blaupunkt
is not liable for any loss or damage resulting from
unauthorized disassembly or modication to the
device.
Device is compatible with car radios with rear
camera input.
Device is designed to monitor tire pressure and
temperature only. Driver is responsible for the
upkeep of the tires.
Blaupunkt is not liable in case of loss of sensors. Con-
tact your Blaupunkt dealer to purchase new sensors.
Package comes with pre-set sensor for designated
tires. In case of sensor replacement or change of
sensor location, ensure the sensor are reprogrammed
before operating.
Please do not operate the device under such
conditions (extremely high temperature or extremely
low temperature); ensure that the temperature within
the car ranges from -20°C to 80°C before you begin
installation process and during operation.
For abnormalities, please refer to the “Trouble-
shooting”section. Consult with Blaupunkt dealer
for further examining, in case if the problem cannot
be resolved.
3
SPECIFICATIONS
Sensor
Operating frequency
Battery voltage
Battery lifetime
Operating temperature
Pressure range
Receiver
Operating current
Operating frequency
Operating voltage
Operating temperature
Default Value
High pressure value
Low pressure value
High temperature value
Precision
Temperature
Pressure
Air pressure unit
Accessories
433.92 ± 0.05MHz
2.2V ~ 3.3V
1-year
-20°C ~ 70°C
0~3.5 Bar / 0~50 PSI
<200mA
433.92± 0.05MHz
+12V
-20°C ~ 70°C
3.0 Bar / 43 PSI
1.8 Bar / 26 PSI
68°C
+/-2°C
0.1 Bar / 1.5 PSI
1 Bar = 14.5 PSI = 100 Kpa = 1.02Kgf/cm
4x external sensor
1x sensor tool 1x battery 1x rubber seal
5x anti-theft nuts 1x spanner
(keep in car)
Receiver
Remote Button (Battery Included)
Sensor Cover
Battery
Sensor (Battery Included)
Rubber Seal
Washer
Hex Nut
STRUCTURE & FUNCTIONS
Functions
1.
2.
3.
4.
5.
6.
7.
8.
2
1
2
3
4
5
6
7
8
Remove the valve cap.
Screw in the nut.
Screw on the sensor.
Tighten up the nut to the sensor by using
the spanner.
Spray soap water on the nozzle to check
for leakage problem.
Clean the area before using it.
1.
2.
3.
4.
5.
6.
SENSOR INSTALLATION
5
Problems
Air leakage after sensor installation
No tire data are displayed after
completing installation
Missing or lost sensor
Sensor battery low
Change of tire location
Solutions
The tire valves may not be universal standard, please check with the local
workshop.
Ensure ACC is turned on.
Please purchase new sensor.
Please replace with battery CR1632.
Please reprogram the corresponding sensors.
If any of the following problem occur, please resort to Troubleshooting for the possible solutions. Consult Blaupunkt
authorized dealer if problem persist.
TROUBLESHOOTING
RECEIVER INSTALLATION WIRING DIAGRAM
Car Reverse Video
Output Head Unit
Reverse Camera Signal
Input
Reverse Camera
Connect with the yellow (third wire)
Black
Yellow
Blue
Red
Connect to Ground Wire
Connect to Red Wire (Beside the Reverse Camera RCA Jack)
Connect to Headunit’s Reverse TriggerWire DC 12V
Connect to ACC 12V Power Supply
4
Fix the wires hardness
by using cable tie
Connect wire harness and
the receiver, then cover it
with the cover board
After installation
1.6
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
3.2
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
Tear o the 3M tap on the back of
remote button and paste it near to the
driver’s seat.
Tire pressure data will be displayed, if the
button is pressing.
Normal
• Displays real time tire pressure of 4 tires.
High Pressure
•
Air Leakage
•
•
1.
2.
1.
2.
3.
OPERATION INSTRUCTION DIFFERENT SCENARIO
7
3M
3M
3M
2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
Bi- Bi- Bi-
Slow : Bi-- Bi-- Bi--
Fast : Bi- Bi- Bi- Bi-
Unscrew the nut.
Unscrew the sensor.
Remove the washer.
Unscrew the sensor cover by using
sensor tool.
Replace new battery.
Refer to “Sensor Installation”steps.
1.
2.
3.
4.
5.
6.
SENSOR BATTERY REPLACEMENT
6
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
LO
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
2.5
70˚C
Bar
Psi
2.5
45˚C
Bar
Psi 2.5
45˚C
Bar
Psi
2.5
45˚C
Bar
Psi
TPMS
High Temperature
•
Low Battery
Sensor Failure
4.
5.
6.
DIFFERENT SCENARIO
8
Bi- Bi- Bi-
Designed and engineered by Blaupunkt Competence Centre 1 311 19 003 23 01
Table of contents
Other Blaupunkt Measuring Instrument manuals
