Whispbar K621W User manual
K621W
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 4 x 4 x 2 x 2
x 4 x 4 x 4 x 4
x 1 x 1
Revision No: 6C 1
Fitting Kit K621W
MAX kgs (lbs)
W/P WHD
Mercedes
CLS Class W219, 4dr Sedan 04-10 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 US 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Subaru
WRX , 4dr Sedan 11-14 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 US 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit EN
K621W
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
3
Fitting Kit EN
K621W
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Attaches to factory-fitted mounting points
●Please check the rear of this manual for
information relating specifically to your
vehicle.
●Adjust crossbar in or out to suit vehicle.
Refer to the crossbar instructions for
crossbar adjustment.
4
Fitting Kit EN
K621W
●Tighten adjusting screw to 3 Nm (2.2 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Select plastic internal block (from fitting kit)
and insert into foot.
5
Fitting Kit EN
K621W
●Repeat for all four positions.
●Open or remove fixed-point covers.
●Select four grubscrews and assemble them
into the adaptor using 3 mm (1/8") Hex
Key.
●NOTE: Mercedes only
●Select grubscrews and screw into the
vehicle's fixed points.
●Do not over tighten.
●Repeat for all four positions.
6
Fitting Kit EN
K621W
●Sort M6 grubscrews into lengths.
●A = Mercedes CLS Class
B = Mercedes S Class / Subaru WRX
C = Not applicable unless advised
●Using the supplied Hex Key, tighten
grubscrew into position.
●Repeat for all four positions.
Fitment
●Refer to the underside of the pad for the
part number.
7
Fitting Kit EN
K621W
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 224A
B = 225A
●Close all fixed-point covers so they rest on
the grubscrew and place pads over
grubscrews.
●It is important to put the pads in the correct
position on the vehicle.
8
Fitting Kit EN
K621W
●Place crossbars on pads ensuring the pads
fit into the holes underneath the foot and
the grubscrew passes through the hole in
the foot.
All Configurations:
●Tighten the plastic knob. The side with the
nut showing should be facing up.
●Ensure the plastic knob is in the position
shown when fully tightened.
●Repeat for all four positions.
9
Fitting Kit EN
K621W
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
CAUTION: Recheck all fasteners immediately after
a load is applied to the crossbars.
Regularly check screws are tight.
10
Table of contents
Other Whispbar Automobile Accessories manuals
Whispbar
Whispbar K343W User manual
Whispbar
Whispbar K720W User manual
Whispbar
Whispbar K619 Operation and installation manual
Whispbar
Whispbar K097W User manual
Whispbar
Whispbar K382W User manual
Whispbar
Whispbar K758W User manual
Whispbar
Whispbar K827W User manual
Whispbar
Whispbar K850W Operation and installation manual
Whispbar
Whispbar K432W User manual
Whispbar
Whispbar K909W Operation and installation manual
Whispbar
Whispbar K589W User manual
Whispbar
Whispbar K501W User manual
Whispbar
Whispbar K753W Fitting Kit User manual
Whispbar
Whispbar K390W User manual
Whispbar
Whispbar K462W User manual
Whispbar
Whispbar K398W User manual
Whispbar
Whispbar K678W User manual
Whispbar
Whispbar K334W Operation and installation manual
Whispbar
Whispbar K112W User manual
Whispbar
Whispbar K401W User manual
