Samsung DV5006 User manual

Clothes Dryers

Owner’s Instructions

DV5008J

DV5006

DV5004J

DV5002

Safety Instructions 3,4

Installation Instructions

Ducting Installation instructions 5

Duct length calculations 6

Exhaust directions 6

Special accessory 6

Special installation requirements 7

Electrical power supply 7

Operating Instructions, Tips

Control panel(DV5008J) 8

Control panel(DV5006) 9

Control panel(DV5004J) 10

Control panel(DV5002) 11

Loading clothes 12

Polyester Knits & Permanent Press Drying Tips 12

Program selecting guide 13

Program chart 14

Drying times 14

Care and Cleaning

Cleaning the filter 15

Dryer Exterior 15

Dryer Vent 16

Inside the dryer cabinet 16

Problem Solver 17

Questions? Use this problem solver 17

Specification 17

Table of Contents

2SAMSUNG Clothes Dryers Owner’s Instructions

Safety Instructions

SAMSUNG Clothes Dryers Owner’s Instructions

Read all instructions before using this appliance

Warning - It is extremely important that you read and adhere to the following

instructions. Failure to do so could result in bodily injuries and/or

property damage due to fire.

•Use this appliance only for its intended purpose as described in this

Owner’s Manual. This dryer must be:

- Properly installed and located in accordance with the Installation Instructions

before it is used.

- Properly grounded to conform with Local Codes. Follow details in Installation

Instructions.

- Located where the temperature is above 50°F(10°C) for satisfactory

operation of the dryer control system. Do not install or store the dryer

where it will be exposed to the weather.

- Connected to a properly rated, protected and sized power supply circuit

to avoid electrical overload.

- Vented to the outside to prevent large amounts of moisture and lint from

being blown into the room.

Carefully follow the venting details in the Installation Instructions.

Do not repair or replace any part of the appliance or attempt any servicing

unless specifically recommended in this Owner’s Manual.

When disconnecting this appliance pull by the plug rather than the cord to

avoid damage to the cord or junction of cord and plug. Make sure that the

cord is located so that it will not be stepped on, tripped over or otherwise

subjected to damage or stress.

To Minimize the Possibility of a Fire Hazard

• Do not use heat to dry articles containing rubber, plastic, or similar materials (such as

padded bras, tennis shoes, galoshes, bath mats, rugs, bibs, pillows, baby pants, plastic

bags, etc.) as these materials may melt or burn. Also, some rubber materials, when

heated, can under certain circumstances produce fire by spontaneous combustion.

• Do not store items that may burn or melt (such as clothing, paper material, plastics or

plastic containers, etc.) on top of the dryer during operation.

• Garments labeled “Dry Away from Heat” must not be put in your dryer.

• Do not wash or dry articles that have been cleaned in, washed in, soaked in, or spotted

with combustible or explosive substances (such as wax, paint, gasoline degreasers,

dry-cleaning solvents, kerosene, etc.) which may ignite or explode.

Do not add these substances to the wash water. Do not use these substances around your

washer and/or dryer during operation.

• Any article on which you have used a cleaning solvent, or which contains

flammable materials (such as cleaning cloths, mops, towels used in beauty salons,

restaurants or barber shops, etc.) must not be placed in or near the dryer until all

traces of these flammable liquids or solids and their fumes have been removed.

There are many highly flammable items used in homes such as: acetone,

de-natured alcohol, gasoline, kerosene, some household cleaners, some spot removers,

turpentines, waxes, wax removers and products containing petroleum distillates.

• Clean the lint filter before each load to prevent lint accumulation inside the dryer or in

the room. DO NOT OPERATE THE DRYER WITHOUT LINTFILTER IN PLACE.

• Keep the area around the exhaust opening, and around and underneath your appliances

free from the accumulation of combustible materials, such as lint, paper, rags,

chemicals, etc.

• Regularly inspect the vent duct to ensure it has not been crushed or otherwise restricted.

• The interior of the dryer cabinet and the exhaust duct connection inside the dryer should

be cleaned every 2 to 3 years, or more often if needed, by a qualified service person.

To Minimize the Possibility of Injury

• Never reach into the dryer while the drum is moving. Before loading, unloaing or

adding clothes, wait until the drum has completely stopped.

• Do not dry fiberglass articles in your dryer. Skin irritation could result from the remain-

ing glass particles that may be picked up by clothing during subsequent dryer uses.

• The laundry process can reduce the flame retardance of some fabrics. To avoid such a

result, the garment manufacturer’s care instructions should be followed very carefully.

• Close supervision is necessary if this appliance is used in reach of or near children. Do

not allow children to play inside, on, or with this appliance or any discarded appliance.

Dispose of discarded appliances and shipping or packing materials properly. Before

discarding a dryer, or removing from service, remove the door of the dryer

compartment.

• Keep all laundry aids (such as detergents, bleaches, fabric softeners, etc.) out of the

reach of children, preferably in a locked cabinet. Observe all warnings on container

labels to avoid personal injury.

• Keep the floor around your appliances clean and dry to reduce the possibility of

slipping.

• To minimize the possibility of electric shock, unplug this appliance from the power

supply before attempting any maintenance or cleaning (except the removal and

cleaning of the lint filter).

• Do not tamper with the controls.

• Do not operate this appliance if it is damaged, malfunctioning, partially disassembled,

or has missing or broken parts, including a damaged cord or plug.

• Never climb on or stand on the dryer.

• DO NOTplace items exposed to cooking oils in your dryer. Items contaminaed with

cooking oils may contribute to a chemical reaction that could cause a clothes load to

catch fire.

SAVE THESE INSTRUCTIONS

Safety Instructions

4SAMSUNG Clothes Dryers Owner’s Instructions

DUCTING INSTALLATION INSTRUCTIONS

Installation and service must be performed by a qualified installer or service agency.

IMPORTANT: Have your dryer installed properly.

NOTE: The WARNING and IMPORTANT instructions appearing in this manual are

not meant to cover all possible conditions and situations that may occur. It must

be understood that common sense, caution, and carefulness are factors that CAN-

NOT be built into the dryer. These factors MUST BE supplied by the person(s)

installing, maintaining, or operating the dryer.

Failure to install, maintain, and/or operate this machine according to the manufacturer’s

instructions may result in conditions which can result in bodily injury and/or damage

to property.

Installation Instructions

SAMSUNG Clothes Dryers Owner’s Instructions

This dryer comes ready for rear

venting.

WARNINGS

• Never use flexible duct inside the dryer.

• Do not terminate ducting in a chimney,

range hood, gas vent, floor or attic

space. The combination of lint and

grease could create a fire hazard or

cause damage.

• Provide an access for inspection and

cleaning the exhaust system at least

once a year.

EXHAUST LENGTH

The MAXIMUM ALLOWABLE length

of the ducting depends upon the type

of duct, number of turns, the type of

external venting point, and all conditions

noted below. The maximum allowable

length for both rigid and flexible metal

ducting is shown in table 1 (next page).

More than four 90°turns is not

recommended.

VENTING CHECK LIST - HOOD

or WALL CAP

• Terminate ducting in a manner to

prevent back drafts, entry of birds or

other wildlife.

• Termination should present minimal

resistance to the exhaust air flow and

should require little or no maintenance

to prevent clogging.

• Wall caps must be installed at least 300

mm (12”) above ground level or any

other obstruction with the opening

pointed down.

• If roof vents or louvered plenums are

used, they must be equivalent to a 100

mm (4”) wall cap with damper, in

regard to resistance to air flow,

prevention of back drafts and

maintenance required to prevent

clogging.

SEPARATION OF TURNS

Separate all turns by at least 1m(3ft.) of

straight duct, including distance between

last turn and dampered wall cap. If two

turns must be closer than 1 m (3 ft.)

deduct 3 m (10 ft.) from the maximum

lengths shown in the table for each occur-

rence.

TURNS OTHER THAN 90°

• One turn of 45° or less may be ignored.

• Two 45° turns should be treated as one

90°.

• Each turn over 45° should be treated as

one 90°.

SEALING OF JOINTS

• All joints should be tight to avoid leaks.

The male end of each section of duct

must point away from the dryer.

• Do not assemble the duct work with

fasteners that extend into the duct. They

will serve as a collection point for lint.

• Duct joints can be made air and

moisture-tight by wrapping the

overlapped joints with duct tape.

INSULATION

• Duct work which runs through an

unheated area or is near an air condi-

tioning duct, should be insulated to

reduce condensation and lint build up

and be sloped down toward outdoors.

NOTE: Never install screen inside exhaust duct.

WARNING: THE DRYER MUST

VENT TO THE OUTDOORS.

TO PREVENT LARGE AMOUNTS

OF LINTAND MOISTURE FROM

ACCUMULATING AND TO

MAINTAIN DRYING EFFICIENCY,

THIS MACHINE MUST BE

VENTED OUTDOORS.

DUCT LENGTH CALCULATION

Table 1: RECOMMENDED MAXIMUM LENGTH

* Do not use non metallic flexible duct.

SPECIAL ACCESSORY

Stacking kit(Model no:SK-2)

You can obtain the stacking kit from your retailer.

With this kit you can combine your dryer with a Samsung

automatic washing machine to create a washing/drying column.

The appliances are stacked in a space-economizing manner in

this arrangement, the washing machine at the button and the

dryer at the top!

Installation Instructions

6SAMSUNG Clothes Dryers Owner’s Instructions

ELECTRIC DRYERS

Weather Hood Type

Recommended Use only for short run installations

Rigid Metallic Flexible* Rigid Metallic Flexible*

14m(46ft.) 9m(30ft.) 11m(37ft.) 7m(24ft.)

11m(38ft.) 7.5m(25ft.) 9m(30ft.) 6m(20ft.)

9m(31ft.) 6m(20ft.) 6.5m(22ft.) 4m(14ft.)

7m(24ft.) 5m(16ft.) 4.5m(15ft.) 3m(10ft.)

No. of 90°

elbows

↔4”(10.16cm) ↔2 1/2”(6.35cm)

SPECIAL INSTALLATION REQUIREMENTS

ALCOVE OR CLOSET INSTALLATION

•WARNING: To reduce the risk of fire, this dryer MUST BE VENTED TO THE

OUTDOORS. See the VENTING INFORMATION section.

• The minimum clearances between dryer cabinet and adjacent walls or other surfaces are :

0” either side 1” front and rear

• The minimum vertical space from floor to overhead cabinets, ceilings, etc. is 52”(132cm).

• The closet door must be louvered or otherwise ventilated and must contain a minimum of

60 sq. in. of open area equally distributed. If this closet contains both a washer and a

dryer, doors must contain a minimum of 120 sq. in. of open area equally distributed.

MINIMUM CLEARANCES OTHER THAN ALCOVE OR CLOSET INSTALLA-

TIONS.

• Minimum clearances to combustible surfaces: 0 clearance both sides and 25 mm (1”) rear.

NOTE: CONSIDERATION MUST BE GIVEN TO INSTALLING AND SERVICING THE

APPLIANCE.

ELECTRICAL POWER SUPPLY

CAUTION: NEVER USE AN EXTENSION CORD WITH THIS APPLIANCE.

• This dryer must be connected to an individual circuit identical to the one specified on the

rating plate of the loading port, protected by fuses or circuit breaker conforming to local

codes. THIS APPLIANCE MUST BE PROPERLY GROUNDED.

GROUNDING INSTRUCTIONS

• This appliance must be grounded. In the event of malfunction or breakdown, grounding will

reduce the risk of electric shock by providing a path of least resistance for electric current.

The plug must be plugged into an appropriate outlet that is properly installed and grounded

in accordance with all local codes and ordinances.

WARNING:

• Improper connection of the equipment grounding conductor can result in a risk of electric

shock. Check with a qualified electrician or serviceman if you are in doubt as to whether the

appliance is properly grounded.

• Do not modify the plug provided with the appliance - if it will not fit the outlet, have a

proper outlet installed by a qualified electrician.

Installation Instructions

SAMSUNG Clothes Dryers Owner’s Instructions

Control panel (DV5008J)

1. The SIGNALbutton

Set to OFF at the factory. When switched on, a buzzer sounds when the current program has finished.

Push the SIGNALbutton once to turn on and again to turn off. The indicator labelled with a bell

symbol will light when this feature is switched on.

2. The TEMPERATURE button

Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the button once

to set to low and again to set back to high. The LOW lamp will illuminate when switched on.

3. The TIME button

When pressed, the timer displays 90(1:30) minutes. By pressing the button, you can reduce the setting

by 10 minutes with each press to a minimum of 20 minutes when the time returns to 90 mins.

(1:30 61:20 61:10 61:00 ..............30 620 61:30)

4. The DELAYSTARTbutton (and on/off indicator)

This allows you to delay the start of the selected dryer program in increments of 1 hour for each press.

(1 hour62 hours63hours624 hours6Cancel.)

5. The Wrinkle-Free button (and on/off indicator)

Pushing the Wrinkle-Free button, ends the drying program and switches the machine to the COOL

DOWN program. This reduces the drying temperature over 10 minutes and then runs for 10 mins at air

temperature.

6. Pre-programmed drying times selection

This allows the user to select from a number of pre-set commonly used drying programs. Rotate the

selector knob to illuminate the lamp next to the required program insuring that the Synthetic or Cotton

lamp is also lit, depending on the type of fabric to be dryer. Please refer to the Program Chart on page 14

of this details manual for more on Loads, temperature and drying times for each program.

7. The FILTER indicator

At switch on, the filter indicator will flash 3 times. When a drying cycle is finished , this indicator will

light to remind you that you should clean the filter after each use. Please refer to the Filter cleaning

instruction.

8. The CHILD LOCK indicator

With this feature switched on, all the function buttons on the front panel are disabled. To enable, you

have to press the WRINKLE-FREE and DELAY START buttons in order. To indicate the CHILD

LOCK is set, the indicator will light. To switch it off again, push the DELAY START button and WRIN-

KLE-FREE buttons in order, the indicator will be extinguished when disabled.

9. The START/PAUSE button

Pressing the blue button in the centre of the program selection knob starts and pauses the dryer.If you

open the door the machine is paused and you must press this button to continue the program.

10. The POWER button

This button is used to switch the unit on and off. If the dryer is left on for more than 10 minutes without

any key-presses or programs running, it will automatically power the unit down.

Operating Instructions, Tips

8SAMSUNG Clothes Dryers Owner’s Instructions

Control panel (DV5006)

1. The TIME button

When pressed, indicators light up to indicate the running time. Initially the 50 indicator is

lit up, then with each press time reduces by 10 mins and the indicators light

(eg: 50 minutes640 minutes 630 minutes 620 minutes 650 minutes.)

2. The TEMPERATURE button

Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the button

once to set to low and again to set back to high. The LOW lamp will illuminate when switched on.

3. The PROGRAM button

This allows the user to select from a number of pre-set commonly used drying programs. When first

pressed, the CUPBOARD setting is selected, pushing the PROGRAM button change the selection

as follows: Cupboard6Iron 6RotaryIron 6Extra6Cupboard

4. The COURSE button

When first switched on, the COTTON setting is selected. Pushing the button toggles the setting

as follows: Cotton6Synthetic6Cotton

5. The AIRING button

When pressed, not only is the airing feature enabled but the 50 minute time light is illuminated.

This is because the feature runs the dryer in cool mode (no heat) for 50 minutes. The running time can

be altered by pressing the time button. Each press changes the time setting as follows:

50 minutes640 minutes 630 minutes620 minutes 650 minutes

6. The SIGNALbutton

Set to OFF at the factory. When switched on, a buzzer sounds when the current program has finished.

Push the SIGNAL button once to turn on and again to turn off. The indicator labelled with a bell

symbol will light when this feature is switched on.

7. FILTER lamp

At switch on, the filter indicator will flash 3 times. When a drying cycle is finished , this indicator will

light to remind you that you should clean the filter after each use. Please refer to the Filter cleaning

instruction.

8. START/PAUSE button

Pressing the blue button in the centre of the program selection knob starts and pauses the dryer.

If you open the door the machine is paused and you must press this button to continue the program.

9. POWER button

This button is used to switch the unit on and off. If the dryer is left on for more than 10 minutes

without any key-presses or programs running, it will automatically power the unit down.

Operating Instructions, Tips

SAMSUNG Clothes Dryers Owner’s Instructions

Control panel (DV5004J)

1.The DELAY START button (and on/off indicator)

This allows you to delay the start of the selected dryer program in increments of 1 hour for each

press. (1 hour626hours 63 hours ... 624 hours 6Cancel.)

2.The TIME button

When pressed, the timer displays 50 minutes. By pressing the button, you can reduce the setting

to a minimum of 20 minutes when the time jumps to 100(1:40) mins and steps down to 50 mins.

3.The TEMPERATURE button

Set to OFF at the factory. Used to switch the drying temperature from high to low. Push the but-

ton once to set to low and again to set back to high. The LOW lamp will illuminate when

switched on.

4.The ANTI-CREASE button

Pushing the ANTI-CREASE button, ends the drying program and switches the machine to the

COOL DOWN program. This reduces the drying temperature over 15 minutes and then runs for

10 mins at air temperature.

5. Pre-programmed drying times selection

This allows the user to select from a number of pre-set commonly used drying programs.

Rotate the seletor knob to illuminate the lamp next to the required program insuring that the

Synthetic or Cotton lamp is also lit , depending on the type of fabric to be dryer. Please refer to

the Program Chart on page 14 of this manual for more details on Loads, temperature and drying

times for each program.

6. The START/PAUSE button

Pressing the blue button in the centre of the program selection knob starts and pauses the dryer.

If you open the door the machine is paused and you must press this button to continue the pro-

gram.

7.The SIGNAL button

Set to OFF at the factory. When switched on, a buzzer sounds when the current program

has finished. Push the SIGNAL button once to turn on and again to turn off. The indicator

labelled with a bell symbol will light when this feature is switched on.

8.The Power button

This button is used to switch the unit on and off. If the dryer is left on for more than 10 minutes

without any key-presses or programs running, it will automatically power the unit down.

9.The FILTER indicator

At switch on, the filter indicator will flash 3 times. When a drying cycle is finished , this indica-

tor will light to remind you that you should clean the filter after each use. Please refer to the

Filter cleaning instruction.

Operating Instructions, Tips

10 SAMSUNG Clothes Dryers Owner’s Instructions

This manual suits for next models

Table of contents

Other Samsung Dryer manuals

Samsung

Samsung DV10B9750 Series User manual

Samsung

Samsung DV331AEW User manual

Samsung

Samsung DVG45T3200 Series User manual

Samsung

Samsung DV393ETPARA/A1 User manual

Samsung

Samsung DV45K6200E Series User manual

Samsung

Samsung DVG45T6000V User manual

Samsung

Samsung DV337 SERIES User manual

Samsung

Samsung DV203 SERIES User manual

Samsung

Samsung DV52J8700E(G) series User manual

Samsung

Samsung DV231AGW/XAA User manual

Samsung

Samsung DV456ETHDSU/AA User manual

Samsung

Samsung DVE(G)45M5500 series User manual

Samsung

Samsung DV80F5E5HGW User manual

Samsung

Samsung DVG52M8650 Series User manual

Samsung

Samsung DVE52B7650V User manual

Samsung

Samsung DV9 BB9445 Series User manual

Samsung

Samsung DV220AEW/XAA User manual

Samsung

Samsung DV56H9100EG/AC User manual

Samsung

Samsung DV9 BBA Series User manual

Samsung

Samsung DVG50M7450W/A3 User manual

Samsung

Samsung DV8 T5 Series User manual

Samsung

Samsung DV45H6300EG Installation and operation manual

Samsung

Samsung DV50F9A6EVW/A2 User manual

Samsung

Samsung DV9 BBA Series User manual

Popular Dryer manuals by other brands

Bosch

Bosch WTA79200GB Installation and operating instructions

Amana

Amana W10233410A Use and care guide

Miele

Miele TWH 780 WP operating instructions

Asko

Asko T760 user guide

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Original instructions

Bosch

Bosch Logixx 10 WTB76556GB Instruction manual and installation instructions

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Operation and installation

Electrolux

Electrolux EW2H328R2 user manual

Beko

Beko DS8433RX1M user manual

Dawlance

Dawlance Spinner DS 6000 C owner's manual

Electrolux

Electrolux TP5080TW user manual

AEG

AEG TR838P4OB user manual

Indesit

Indesit IDV 75 instruction manual

Infiniton

Infiniton SD-DG85C manual

BOMANN

BOMANN WT 5019 instruction manual

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Installation

Asko

Asko T793C operating instructions

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer installation instructions