Alliance Laundry Systems 25 Series User manual

Programming

Tumble Dryer

Dual Digital Control

Refer to Page 8 for Model Numbers

Original Instructions

Keep These Instructions for Future Reference.

CAUTION: Read the instructions before using the machine.

(If this machine changes ownership, this manual must accompany machine.)

www.alliancelaundry.com Part No. 70579901EN

January 2018

Installation must conform with local codes or, in the absence of

local codes, with:

In the U.S.A., installation must conform to the latest edition of

the American National Standard Z223.1/ NFPA 54 “National

Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric

Code.”

In Canada, installation must comply with Standards CAN/CSA-

B149.1 or Natural Gas and Propane Installation Code and CSA

C22.1, latest edition, Canadian Electric Code, Part I.

In Australia and New Zealand, installation must comply with the

Gas Installations Standard AS/NZS 5601 Part 1: General Installa-

tions.

WARNING

FOR YOUR SAFETY, the information in this manual

must be followed to minimize the risk of fire or ex-

plosion or to prevent property damage, personal in-

jury or death.

W033

WARNING

• Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

•WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Clear the room, building or area of all occu-

pants.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s in-

structions.

• If you cannot reach your gas supplier, call the

fire department.

• Installation and service must be performed by a

qualified installer, service agency or the gas sup-

plier.

W052

IMPORTANT: Information must be obtained from a lo-

cal gas supplier on instructions to be followed if the

user smells gas. These instructions must be posted in

a prominent location. Step-by-step instructions of the

above safety information must be posted in a promi-

nent location near the tumble dryer for customer use.

IMPORTANT: The installer must fully test the tumble

dryer after installation and demonstrate to the owner

how to operate the machine.

WARNING

To reduce the risk of electric shock, fire, explosion,

serious injury or death:

• Disconnect electric power to the tumble dryer be-

fore servicing.

• Close gas shut-off valve to gas tumble dryer be-

fore servicing.

• Close steam valve to steam tumble dryer before

servicing.

• Never start the tumble dryer with any guards/

panels removed.

• Whenever ground wires are removed during serv-

icing, these ground wires must be reconnected to

ensure that the tumble dryer is properly ground-

ed.

W002R1

WARNING

• Installation of unit must be performed by a quali-

fied installer.

• Install tumble dryer according to manufacturer’s

instructions and local codes.

• DO NOT install a tumble dryer with flexible plastic

venting materials. If flexible metal (foil type) duct

is installed, it must be of a specific type identified

by the appliance manufacturer as suitable for use

with tumble dryer. Refer to section on connecting

exhaust system. Flexible venting materials are

known to collapse, be easily crushed, and trap

lint. These conditions will obstruct tumble dryer

airflow and increase the risk of fire.

W752R1

The following information applies to the state of Massachusetts,

USA.

DO NOT COPY or TRANSMIT

3 Part No. 70579901EN

• This appliance can only be installed by a Massachusetts li-

censed plumber or gas fitter.

• This appliance must be installed with a 36 inch [91 cm] long

flexible gas connector.

• A “T-Handle” type gas shut-off valve must be installed in the

gas supply line to this appliance.

• This appliance must not be installed in a bedroom or bath-

room.

DO NOT COPY or TRANSMIT

4 Part No. 70579901EN

Table of Contents

Introduction........................................................................................... 7

Model Identification........................................................................................7

Preliminary Information.......................................................................20

About the Control......................................................................................... 20

Glossary of Terms.........................................................................................20

Power Fail Recovery..................................................................................... 20

Control Identification........................................................................... 21

Select Cycle Keypads....................................................................................21

Display Identification............................................................................24

Light Emitting Diodes (LEDs)....................................................................... 24

CYCLE LED............................................................................................ 24

REVERSING LED (reversing models only).................................................24

Four 7-Segment Digits.................................................................................. 24

Special Features....................................................................................25

Collecting Audit Information......................................................................... 25

Testing the Machine Using Diagnostic Functions............................................. 25

Rapid Advance Feature................................................................................. 25

Machine Operation...............................................................................26

Power Up.....................................................................................................26

System Check Mode..................................................................................... 26

Start Mode................................................................................................... 26

Run Mode.................................................................................................... 26

End of Cycle Mode....................................................................................... 26

Changing Cycles...........................................................................................26

OPL Power Save...........................................................................................26

Power Failure Display Mode..........................................................................26

Error Display Mode...................................................................................... 26

Extended Tumble Mode.................................................................................26

Opening the Service Door .................................................................... 27

Stacked Tumble Dryer...................................................................................27

Stand Alone Tumble Dryer............................................................................ 27

written consent of the publisher.

DO NOT COPY or TRANSMIT

5 Part No. 70579901EN

Entering the Manual Mode................................................................... 28

How to Enter the Manual Mode......................................................................28

How to Exit Manual Mode.............................................................................28

Rapid Advance Feature.........................................................................29

Manual Rapid Advance Menu........................................................................ 29

Collecting Audit Information................................................................ 30

Manual Read Audit Mode Menu.................................................................... 30

Machine Diagnostic Functions.............................................................. 31

Manual Diagnostic Mode Menu..................................................................... 31

Diagnostic (Testing) Mode – Quick Reference.................................................31

Diagnostic Test Descriptions..........................................................................32

Front-End Control Software Version Number d 01 .......................................32

Input/Output Board Software Version Number d 02...................................... 32

Drive Board Software Version Number d 03................................................ 32

Fan Board Software Version Number d 04................................................... 32

Ignition Control Software Version Number d 05 (gas models only)................ 32

Service Door Switch Input Test d 08 ...........................................................32

Dryer on Temperature Test d 14.................................................................. 33

Door Switch Input Test d 15 ...................................................................... 33

Lint Door Switch Input Test d 16................................................................ 33

Temperature Sensor Display Test d 19 ........................................................ 33

12.5VDC Voltage Test d 20 ....................................................................... 33

24VDC Voltage Test d 21 ..........................................................................33

AC Mains Voltage Test d 28 ...................................................................... 33

Machine Configuration #1 Display Test d 29 ...............................................33

Machine Configuration #2 Display Test d 30 ...............................................34

Machine Configuration #3 Display Test d 31 ...............................................34

Machine Configuration #4 Display Test d 32 ...............................................34

Machine Configuration #5 Display Test d 33................................................44

ICM Alarm Status d 34 (gas models only)................................................... 44

ICM Reset Test d 35 (gas models only)....................................................... 44

Heat Interlock Test d 36............................................................................. 44

Air Flow Switch Test d 37..........................................................................45

Fan Motor Test d 38...................................................................................45

Damper Motor Test d 39 (steam models only).............................................. 45

Drive Motor Test d 40................................................................................45

Factory Test Cycle................................................................................ 46

Factory Test Quick Reference Chart................................................................46

Error Codes..........................................................................................48

DO NOT COPY or TRANSMIT

6 Part No. 70579901EN

Introduction

Model Identification

Information in this manual is applicable to these models. Refer

to the machine serial plate for the model number.

Introduction

DO NOT COPY or TRANSMIT

7 Part No. 70579901EN

25 Series (11 Kg)

BA025E BU025L HA025S HU025F NG025S PK025N SJ025F UG025R

BA025F BU025N HG025D HU025L NH025E PT025E SJ025L UG025S

BA025L BU025R HG025E HU025N NH025L PT025L SJ025N UH025E

BA025N BU025S HG025F HU025R NH025N PT025N SJ025R UH025F

BA025R GA025E HG025L HU025S NH025S PT025S SJ025S UH025L

BA025S GA025L HG025N KT025E NJ0205E PU025E SK025N UH025N

BG025D GA025N HG025R KT025L NJ025L PU025L SK025R UH025R

BG025E GA025S HG025S KT025N NJ025N PU025N ST025E UH025S

BG025F GG025E HH025E KT025S NJ025S PU025S ST025F UJ025D

BG025L GG025L HH025F MG025D NK025N SA025E ST025L UJ025E

BG025N GG025N HH025L MG025E NU025E SA025F ST025N UJ025F

BG025R GG025S HH025N MG025F NU025L SA025L ST025R UJ025L

BG025S GH025E HH025R MG025L NU025N SA025N ST025S UJ025N

BH025E GH025L HH025S MG025N NU025S SA025R SU025E UJ025R

BH025F GH025N HJ025D MG025R PA025E SA025S SU025F UJ025S

BH025L GH025S HJ025E MG025S PA025L SG025D SU025L UK025N

BH025N GJ025E HJ025F MJ025D PA025N SG025E SU025N UK025R

BH025R GJ025L HJ025L MJ025E PA025S SG025F SU025R UT025E

BH025S GJ025N HJ025N MJ025F PG025E SG025L SU025S UT025F

BJ025D GJ025S HJ025R MJ025L PG025L SG025N UA025E UT025L

BJ025E GK025N HJ025S MJ025N PG025N SG025R UA025F UT025N

BJ025F GU025E HK025N MJ025R PG025S SG025S UA025L UT025R

BJ025L GU025L HK025R MJ025S PH025E SH025E UA025N UT025S

BJ025N GU025N HT025E NA025E PH025L SH025F UA025R UU025E

BJ025R GU025S HT025F NA025L PH025N SH025L UA025S UU025F

BJ025S HA025E HT025L NA025N PH025S SH025N UG025D UU025L

BK025N HA025F HT025N NA025S PJ025E SH025R UG025E UU025N

BK025R HA025L HT025R NG025E PJ025L SH025S UG025F UU025R

BU025E HA025N HT025S NG025L PJ025N SJ025D UG025L UU025S

BU025F HA025R HU025E NG025N PJ025S SJ025E UG025N

Introduction

DO NOT COPY or TRANSMIT

8 Part No. 70579901EN

30 Series (13 Kg)

BA030E BU030L HA030S HU030F NG030S PK030N SJ030F UG030R

BA030F BU030N HG030D HU030L NH030E PT030E SJ030L UG030S

BA030L BU030R HG030E HU030N NH030L PT030L SJ030N UH030E

BA030N BU030S HG030F HU030R NH030N PT030N SJ030R UH030F

BA030R GA030E HG030L HU030S NH030S PT030S SJ030S UH030L

BA030S GA030L HG030N KT030E NJ030E PU030E SK030N UH030N

BG030D GA030N HG030R KT030L NJ030L PU030L SK030R UH030R

BG030E GA030S HG030S KT030N NJ030N PU030N ST030E UH030S

BG030F GG030E HH030E KT030S NJ030S PU030S ST030F UJ030D

BG030L GG030L HH030F MG030D NK030N SA030E ST030L UJ030E

BG030N GG030N HH030L MG030E NU030E SA030F ST030N UJ030F

BG030R GG030S HH030N MG030F NU030L SA030L ST030R UJ030L

BG030S GH030E HH030R MG030L NU030N SA030N ST030S UJ030N

BH030E GH030L HH030S MG030N NU030S SA030R SU030E UJ030R

BH030F GH030N HJ030D MG030R PA030E SA030S SU030F UJ030S

BH030L GH030S HJ030E MG030S PA030L SG030D SU030L UK030N

BH030N GJ030E HJ030F MJ030D PA030N SG030E SU030N UK030R

BH030R GJ030L HJ030L MJ030E PA030S SG030F SU030R UT030E

BH030S GJ030N HJ030N MJ030F PG030E SG030L SU030S UT030F

BJ030D GJ030S HJ030R MJ030L PG030L SG030N UA030E UT030L

BJ030E GK030N HJ030S MJ030N PG030N SG030R UA030F UT030N

BJ030F GU030E HK030N MJ030R PG030S SG030S UA030L UT030R

BJ030L GU030L HK030R MJ030S PH030E SH030E UA030N UT030S

BJ030N GU030N HT030E NA030E PH030L SH030F UA030R UU030E

BJ030R GU030S HT030F NA030L PH030N SH030L UA030S UU030F

BJ030S HA030E HT030L NA030N PH030S SH030N UG030D UU030L

BK030N HA030F HT030N NA030S PJ030E SH030R UG030E UU030N

BK030R HA030L HT030R NG030E PJ030L SH030S UG030F UU030R

BU030E HA030N HT030S NG030L PJ030N SJ030D UG030L UU030S

BU030F HA030R HU030E NG030N PJ030S SJ030E UG030N

Introduction

DO NOT COPY or TRANSMIT

9 Part No. 70579901EN

T30 Series (13/13 Kg)

BAT30E BUT30L HAT30S HUT30F NGT30S PKT30N SJT30F UGT30R

BAT30F BUT30N HGT30D HUT30L NHT30E PTT30E SJT30L UGT30S

BAT30L BUT30R HGT30E HUT30N NHT30L PTT30L SJT30N UHT30E

BAT30N BUT30S HGT30F HUT30R NHT30N PTT30N SJT30R UHT30F

BAT30R GAT30E HGT30L HUT30S NHT30S PTT30S SJT30S UHT30L

BAT30S GAT30L HGT30N KTT30E NJT30E PUT30E SKT30N UHT30N

BGT30D GAT30N HGT30R KTT30L NJT30L PUT30L SKT30R UHT30R

BGT30E GAT30S HGT30S KTT30N NJT30N PUT30N STT30E UHT30R

BGT30F GGT30E HHT30E KTT30S NJT30S PUT30S STT30F UJT30D

BGT30L GGT30L HHT30F MGT30D NKT30N SAT30E STT30L UJT30E

BGT30N GGT30N HHT30L MGT30E NUT30E SAT30F STT30N UJT30F

BGT30R GGT30S HHT30N MGT30F NUT30L SAT30L STT30R UJT30L

BGT30S GHT30E HHT30R MGT30L NUT30N SAT30N STT30S UJT30N

BHT30E GHT30L HHT30S MGT30N NUT30S SAT30R SUT30E UJT30R

BHT30F GHT30N HJT30D MGT30R PAT30E SAT30S SUT30F UJT30S

BHT30L GHT30S HJT30E MGT30S PAT30L SGT30D SUT30L UKT30N

BHT30N GJT30E HJT30F MJT30D PAT30N SGT30E SUT30N UKT30R

BHT30R GJT30L HJT30L MJT30E PAT30S SGT30F SUT30R UTT30E

BHT30S GJT30N HJT30N MJT30F PGT30E SGT30L SUT30S UTT30F

BJT30D GJT30S HJT30R MJT30L PGT30L SGT30N UAT30E UTT30L

BJT30E GKT30N HJT30S MJT30N PGT30N SGT30R UAT30F UTT30N

BJT30F GUT30E HKT30N MJT30R PGT30S SGT30S UAT30L UTT30R

BJT30L GUT30L HKT30R MJT30S PHT30E SHT30E UAT30N UTT30S

BJT30N GUT30N HTT30E NAT30E PHT30L SHT30F UAT30R UUT30E

BJT30R GUT30S HTT30F NAT30L PHT30N SHT30L UAT30S UUT30F

BJT30S HAT30E HTT30L NAT30N PHT30S SHT30N UGT30D UUT30L

BKT30N HAT30F HTT30N NAT30S PJT30E SHT30R UGT30E UUT30N

BKT30R HAT30L HTT30R NGT30E PJT30L SHT30S UGT30F UUT30R

BUT30E HAT30N HTT30S NGT30L PJT30N SJT30D UGT30L UUT30S

BUT30F HAT30R HUT30E NGT30N PJT30S SJT30E UGT30N

Introduction

DO NOT COPY or TRANSMIT

10 Part No. 70579901EN

Other manuals for 25 Series

This manual suits for next models

248

Table of contents

Other Alliance Laundry Systems Dryer manuals

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen FF7009WN User manual

Alliance Laundry Systems

Alliance Laundry Systems LES33AW User manual

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DF7000WG User manual

Alliance Laundry Systems

Alliance Laundry Systems SFE107*A User manual

Alliance Laundry Systems

Alliance Laundry Systems 506126R5 User manual

Alliance Laundry Systems

Alliance Laundry Systems CA170L Owner's manual

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers none User manual

Alliance Laundry Systems

Alliance Laundry Systems HE-HG Seies Assembly instructions

Alliance Laundry Systems

Alliance Laundry Systems DC0220SFG User manual

Alliance Laundry Systems

Alliance Laundry Systems 510977R9 Guide

Alliance Laundry Systems

Alliance Laundry Systems 503806R1 User manual

Alliance Laundry Systems

Alliance Laundry Systems SDE807 Guide

Alliance Laundry Systems

Alliance Laundry Systems 70444901R3 Owner's manual

Alliance Laundry Systems

Alliance Laundry Systems BA025E User manual

Alliance Laundry Systems

Alliance Laundry Systems 602004144 Troubleshooting guide

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guide

Alliance Laundry Systems

Alliance Laundry Systems 25 Pound Capacity User manual

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers none Operating manual

Alliance Laundry Systems

Alliance Laundry Systems TMB795C User manual

Alliance Laundry Systems

Alliance Laundry Systems HSE117*C802 Assembly instructions

Alliance Laundry Systems

Alliance Laundry Systems Dryer Tumblers User manual

Alliance Laundry Systems

Alliance Laundry Systems DRY735C-SVG User manual

Alliance Laundry Systems

Alliance Laundry Systems ADG3SRGS117TW01 User manual

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guide

Popular Dryer manuals by other brands

Bosch

Bosch WTA79200GB Installation and operating instructions

Amana

Amana W10233410A Use and care guide

Miele

Miele TWH 780 WP operating instructions

Asko

Asko T760 user guide

Bosch

Bosch Logixx 10 WTB76556GB Instruction manual and installation instructions

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Operation and installation

Electrolux

Electrolux EW2H328R2 user manual

Beko

Beko DS8433RX1M user manual

Dawlance

Dawlance Spinner DS 6000 C owner's manual

Electrolux

Electrolux TP5080TW user manual

AEG

AEG TR838P4OB user manual

Indesit

Indesit IDV 75 instruction manual

Infiniton

Infiniton SD-DG85C manual

BOMANN

BOMANN WT 5019 instruction manual

Asko

Asko T793C operating instructions

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer installation instructions

Frigidaire

Frigidaire CAQE7077KW0 use & care

Bosch

Bosch WTX8HKM9SN User manual and installation instructions