Outback THG3710SS-3 User manual

Photographs are not to scale.

Specifications subject to change

without prior notice.

Assembly and Operating Instructions for

Outback® Excelsior 3 Burner and Excelsior 6 Burner Gas Barbecues

0359

EN (Europe)

WARNING

For outdoor use only. Not for commercial use.

Read instructions before using the appliance. Failure to follow instructions could

result in death, serious bodily injury, and/or property loss.

Warning: accessible parts may be very hot. Keep young children and pets away.

Do not move the appliance during use.

Turn off the gas supply at the gas bottle after use.

Any modification of the appliance, misuse, or failure to follow the instructions may

be dangerous and will invalidate your warranty. This does not affect your statutory

rights.

Retain these instructions for future reference.

Leak test annually, and whenever the gas bottle is removed or replaced. Check that

the hose connections are tight and leak test each time you reconnect the gas bottle.

For Flare-up control please refer to the ‘OPERATION’ section of this manual.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and

contact your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use must not be

stored in the vicinity of this or any other

appliance.

THG3710SS-3 THG6710SS-3

CODE PART QTY Outback®

Excelsior 3 Burner

Outback®

Excelsior 6 Burner

HOOD

A1 Hood (Pre-Assembled to Body) 1  

A2 Hood Handle 1  

A3 Heat Indicator and Nuts 1  

A4 Warming Rack 1  

BODY

B1 Barbecue Body 1  

B2 Burner 3 6

B3 Control Panel 1  

B4 Knob 36

B5 Hose (if supplied) 

B6 Lava Rock in Basket / Flame Tamer  

B7 Cooking Grill 1  

B8 Cooking Griddle 1  

B9 Drip Tray Left Bracket 1  

B10 Drip Tray Right Bracket 1 

B11 Drip Tray 1  

B12 Drip Pan 1 

TROLLEY

C1 Side Burner Shelf 1  

C2 Side Shelf Shield 1  

C3 Front Left Endcap 1  

C4 Rear Left Endcap 1  

C5 Utensil Tray 2  

C6 Right Side Shelf 1  

C7 Right Insert 1  

C8 Left Front Leg 1  

C9 Left Rear Leg 1  

C10 Right Front Leg 1  

C11 Right Rear Leg 1  

C12 Bottom Slat Assembly 1  

C13 Base Tray 1  

C14 Gas Bottle Holder 1  

C15 Trolley Foot 1  

C16 Hubcap 2  

C17 Wheel 2  

C18 Axle 1  

C19 Retaining Rod 1  

C20 Gas Bottle Strap 1  

C21 Side Shelf Hook 2  

C22 Fixing Bracket 2  

C23 Side Burner Grid 1  

HARDWARE

D1 M4x15 Bolt 4  

D2 M5x15 Bolt 4  

D3 Ø5 Washer 4  

D4 M5 Nut 4  

D5 M6x15 Bolt 24  

D6 Ø6 Washer 4  

D7 M6x35 Bolt 16  

D8 1/4-20UNCx12 Bolt 6  

D9 Locknut 2  

1. Parts List

Quantity varies according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see the corresponding ‘Hardware Reference Diagram’.

Pre-Assembled Component

Quantity varies according to model purchased

 Appearance, size, and construction may differ according to model purchased

C17

C16

2. Parts Diagram

Quantity varies according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see the corresponding ‘Hardware Reference Diagram’.

C5C4C1 C6 C7

C21

A1 A3

C11

C10

C13

C12

C15

C14

C18

C19

C20

C23

C22

B10

B12

B11

3. Hardware Reference Diagram

Specifications subject to change without prior notice.

D2、D3、D4

D5、D6

Attach the Right Front Leg (C10) to the Trolley Foot (C15).

4. Assembly

IMPORTANT!

TOOLS NEEDED FOR ASSEMBLY: Medium size flat blade or Phillips/Crosspoint screwdriver,

adjustable spanner or metric spanner set.

The assembly of this barbecue requires 2 people.

The inlet connection of the gas rail assembly on the barbecue body is lower than the body. You must

never allow the pipe to rest on the ground during assembly as serious damage could result. We

recommend the body is left sitting in the box until required for assembly to trolley.

Whilst every care is taken in the manufacture of this product, care must be taken during assembly in

case sharp edges are present.

Please read the Important Information section carefully before assembly and use of your

barbecue.

Attach the Right Rear Leg (C11) to the Trolley Foot (C15). The legs are a push fit onto the

trolley foot and onto the gas bottle holder. In case of difficulty, they may need tapping lightly

with a soft faced mallet. Take care not to damage parts.

Attach the Bottom Slat Assembly (C12) to the Base Tray (C13) using M6x15 Bolts (D5).

Attach the leg assembly to the Base Tray (C13) using M6x15 Bolts (D5).

Align the Gas Bottle Holder (C14) with the Bottom Slat Assembly (C12).

Attach the Left Front Leg (C8) and Left Rear Leg (C9) to the Gas Bottle Holder (C14).

Note: Threaded inserts must be facing in the direction shown!

Threaded

Insert

Attach the Gas Bottle Holder (C14) to the Bottom Slat Assembly (C12) using

M6x15 Bolts (D5) and Ø6 Washers (D6).

Unscrew the Locknuts (D9) from both ends of the Axle (C18).

Insert the axle through the clamping brackets into the Gas Bottle Holder (C14) and tighten the

clamp bolts. Take care not to over tighten these bolts which will damage the plastic gas bottle

holder.

Slide the Wheels (C17) over each end of the axle. Secure the wheels

into place with the locknuts.

Carefully turn the completed trolley over, right side up.

Place the wheel Hubcaps (C16) onto the outsides of the wheels.

Remove all cooking components, lava rock / flame tamer, and any internal packaging from the

Barbecue Body (B1).

Carefully turn the barbecue body upside-down.

CAUTION! Care must be taken to ensure the hood or lid does not fall open unexpectedly or

becomes damaged when it is set on the ground.

Attach the Right Side Shelf (C6) to the barbecue body using M6x15 Bolts (D5).

Attach the Front Left Endcap (C3) to the barbecue body using M6x15 Bolts (D5).

Other manuals for THG3710SS-3

This manual suits for next models

Table of contents

Other Outback Grill manuals

Outback

Outback RC4343C User manual

Outback

Outback THG3302P User manual

Outback

Outback Excel 100T User manual

Outback

Outback Meteor MT-H4461-3 User manual

Outback

Outback Meteor MT-H4430-3 User manual

Outback

Outback NEW Apollo 4 User manual

Outback

Outback Hunter Plus 3 User manual

Outback

Outback Orion User manual

Outback

Outback Excelsior 3 User manual

Outback

Outback CD200 User manual

Outback

Outback Trooper User manual

Outback

Outback Outback Excel 210 User manual

Outback

Outback Charcoal Kettle CK575 User manual

Outback

Outback Excel Onyx 2 User manual

Outback

Outback THG2710 User manual

Outback

Outback THG3302S User manual

Outback

Outback Omega Charcoal 100 User manual

Outback

Outback Jupiter 4 User manual

Outback

Outback Mayfair User manual

Outback

Outback Professional Range Pro 6 User manual

Outback

Outback Party FS5680 User manual

Outback

Outback THG2216AW User manual

Outback

Outback Cuisine User manual

Outback

Outback Society/Granite User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide