Outback Hunter Plus 3 User manual

Photographs are not to scale.

Specifications subject to change

without prior notice.

Assembly and Operating Instructions for Outback®

Hunter Plus 3 Gas BBQ

WARNING

• For outdoor use only. Not for commercial use.

• Read instructions before using the appliance. Failure to follow instructions could

result in death, serious bodily injury, and/or property loss.

• Warning: accessible parts may be very hot. Keep young children and pets away.

• Do not move the appliance during use.

• Turn off the gas supply at the gas bottle after use.

• Any modification of the appliance, misuse, or failure to follow the instructions may be

dangerous and will invalidate your warranty. This does not affect your statutory rights.

• Retain these instructions for future reference.

• Leak test annually, and whenever the gas bottle is removed or replaced. Check that the

hose connections are tight and leak test each time you reconnect the gas bottle.

• For Flare-up control please refer to the ‘OPERATION’ section of this manual.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and

contact your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use shall not be

stored in the vicinity of this or any other

appliance.

0359

THG3302SB-7

Parts List

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see ‘Hardware Reference Diagram’.

CODE PART QTY Outback® Hunter Plus 3 Gas BBQ

HOOD

A1 Hood (Pre-Assembled to Body) 1 

A2 Hood Handle 1 

A3 Heat Indicator 1 

A4 Warming Rack 1 

BODY

B1 Cooking Grill 2 

B2 Cooking Griddle

B3 Lava Rock 2 

B4 Lava Rock Basket 2 

B5 Barbecue Body 1 

B6 Knob 3 

B7 Control Panel 1 

B8 Burner 3 

B9 Drip Tray 1 

B10 Drip Tray Left Bracket 1 

B11 Drip Tray Right Bracket 1 

B12 Drip Pan Handle 1 

B13 Hose and Regulator Assembly 1 

TROLLEY

C1 Side Burner Shelf 1 

C2 Side Shelf 1 

C3 Left Front Leg 1 

C4 Left Rear Leg 1 

C5 Right Front Leg 1 

C6 Right Rear Leg 1 

C7 Leg Top Support 1 

C8 Screen 1 

C9 Fixed support 2 

C10 Trolley Base 1 

C11 Leg Endcap 2 

C12 Axle 1 

C13 Wheel 2 

C14 Hubcap 2 

C15 Side Burner Knob 1 

C16 Side Burner Grid 1 

C17 Axle Washer 2 

C18 Locknut 2 

HARDWARE

D1 M6x95 Bolt 8 

D2 Spacer 8 

D3 1/4-20UNCx22 Step Bolt 4 

D4 1/4-20UNCx12 Bolt 8 

D5 1/4-20UNCx25 Bolt 8 

D6 1/4-20UNCx22 Bolt 8 

D7 M5x15 Bolt 4 

D8 Washer 4 

D9 M5 Nut 4 

Pre-Assembled Component

Quantity varies according to model purchased

 Appearance, size, and construction may differ according to model purchased

Parts Diagrams

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see hardware pack page.

B13

C4 C6

C12

C13 C14 C11

C3 C5

B10

B6 B7

B11

C10

C18

C15

C16

C17

B12

Hardware Reference Diagram

Specifications subject to change without prior notice.

D1,D2

Assembly

IMPORTANT!

• TOOLS NEEDED FOR ASSEMBLY: Medium size flat blade or Phillips/Crosspoint screwdriver,

adjustable spanner or metric spanner set.

• Remove any internal components or packaging from the barbecue body.

• Whilst every care is taken in the manufacture of this product, care must be taken during assembly in

case sharp edges are present.

• Please read the Important Information section carefully before assembly and use of your

barbecue.

Attach the Front Legs (C3, C5) and one Fixed Support (C9) onto the Trolley Base (C10) by

aligning corresponding holes and fixing with the 1/4-20UNCx25 Bolts (D5x4pcs) as shown.

Ensure Front legs with the hole for assembling Front Screen to them are at the facing inwards of

the barbecue.

C10

Attach the Rear Legs (C4, C6) and other Fixed Support (C9) onto the Trolley Base (C10) by

aligning corresponding holes and fixing with the 1/4-20UNCx25 Bolts (D5x4pcs) as shown.

Place the wheel Hubcaps (C14) onto the outsides of the wheels.

C13

C12

Unscrew the Locknuts (C18x2pcs) from both ends of the Axle (C12) and remove the Axle

Washers (C17x2pcs). Slide the axle through the corresponding holes in the left legs. Place axle

washers on each end of the axle. Slide the Wheels (C13) over each end of the axle. Secure the

wheels into place with the locknuts.

C18

C17

C14

Install a 1/4-20UNCx22 Step Bolts (D3x2pcs) on each leg, and then attach the Side Shelf (C2)

onto right legs using the 1/4-20UNCx22 Step Bolts (D3x2pcs). Hook the side shelves onto the

upper step bolts.

Attach one Leg Top Support (C7) between the left legs using the 1/4-20UNCx12 Bolts (D4x3pcs).

Repeat above process for the other leg top support.

Press the Side Burner Knob (C15) onto side burner valve stem.

Attach the Side Burner Shelf (C1) onto left legs using the 1/4-20UNCx22 Bolts (D6x8pcs).

C15

Insert M6x95 Bolts (D1x8pcs) through the trolley legs, the Spacers (D2x8pcs), and keep the tip of

the bolts inside the spacers. While holding the barbecue body into position (2-3 people required),

screw the bolts into the barbecue body as shown.

CAUTION! Care must be taken to ensure the hood or lid does not fall open unexpectedly or

becomes damaged when it is set on the ground.

When positioning the body of the barbecue, ensure the control panel is on the same side as the legs

with Velcro fastenings.

D1 D2

Attach Drip Tray Left Bracket (B10) to barbecue body using M5x15 Bolts (D7x2pcs), Washers

(D8x2pcs) and M5 Nuts (D9x2pcs) as shown. Repeat above process for Drip Tray Right Bracket

(B11).

NOTE: Ensure that the big tabs of the brakets which stop the drip tray are located at the

front of the barbecue.

B10

D7 D8

Unscrew retaining bolts from Drip Tray Handle (B12) ,and fix the drip tray handle onto Drip Tray

(B9) using the retaining bolts.

Insert the Drip Tray (B9) by sliding it underneath the barbecue body.

B9 B12

Front

view

Front

view

√ ×

Remove the plastic wrap from the Lava Rock (B3x2pcs) and then place a uniform layer into Lava

Rock Basket (B4x2pcs). Lay the lava rock carefully into the body ensuring it lies level within the

body. Lay the cooking grills (B1x2pcs) into place.

NOTE: Ensure that the lava rock lies directly underneath the grills.

Attach the Warming Rack (A4) to the Hood (A1) and Barbecue Body (B5) as shown. Make sure

that the swing legs fix to the body of the barbecue and the shorter fixed legs go through the holes

in the hood.

Step 1

Step 2

Step 3

Step 4

This manual suits for next models

Table of contents

Other Outback Grill manuals

Outback

Outback THG3302S-3 User manual

Outback

Outback RC4341C User manual

Outback

Outback Meteor MT-H4430-3 User manual

Outback

Outback Hunter User manual

Outback

Outback Orion User manual

Outback

Outback Omega 100 User manual

Outback

Outback Excel 100 User manual

Outback

Outback Meteor MT-H4461-3 User manual

Outback

Outback RG47F User manual

Outback

Outback Omega 200 User manual

Outback

Outback Ranger 3 User manual

Outback

Outback Excel 100 User manual

Outback

Outback OUT371036 User manual

Outback

Outback RS4491 User manual

Outback

Outback Trekker RG47B User manual

Outback

Outback CD200 User manual

Outback

Outback CK578T User manual

Outback

Outback Excel Onyx 2 User manual

Outback

Outback TRG2301P-3 User manual

Outback

Outback MS4464 User manual

Outback

Outback Omega 100 User manual

Outback

Outback Trooper Stainless Steel User manual

Outback

Outback Spectrum THG2302PA User manual

Outback

Outback OUTBACK TROOPER 359 Assembly and User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide