Outback RC4343C User manual

Photographs are not to scale.

Specifications subject to change

without prior notice.

Assembly and Operating Instructions for Outback®

Ranger 3 Gas BBQ and Ranger 3S Gas BBQ

WARNING

 For outdoor use only. Not for commercial use.

 Read instructions before using the appliance. Failure to follow instructions could

result in death, serious bodily injury, and/or property loss.

 Warning: accessible parts may be very hot. Keep young children and pets away.

 Do not move the appliance during use.

 Turn off the gas supply at the gas bottle after use.

 Any modification of the appliance, misuse, or failure to follow the instructions may be

dangerous and will invalidate your warranty. This does not affect your statutory rights.

 Retain these instructions for future reference.

 Leak test annually, and whenever the gas bottle is removed or replaced. Check that the

hose connections are tight and leak test each time you reconnect the gas bottle.

 For Flare-up control please refer to the ‘OPERATION’ section of this manual.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and

contact your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use shall not be

stored in the vicinity of this or any other

appliance.

0359

RC4343C

RC4341C

Parts List

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see ‘Hardware Reference Diagram’.

CODE PART QTY Ranger 3

Gas BBQ

Ranger 3S

Gas BBQ

HOOD

A1 Hood (Pre-Assembled to Body) 1  

A2 Hood Handle 1  

A3 Heat Indicator 1  

A4 Warming Rack 1  

BODY

B1 Cooking Grill 2  

B2 Round Grill 1  

B3 Charcoal Basket 1  

B4 Flame Tamer 3  

B5 Barbecue Body 1  

B6 Knob 3  

B7 Control Panel 1  

B8 Burner 3  

B9 Drip Tray Handle 1  

B10 Drip Tray 1  

B11 Drip Tray Left Bracket 1  

B12 Drip Tray Right Bracket 1  

B13 Hose and Regulator Assembly 1  

TROLLEY

C1 Side Burner Shelf 1  

C2 Side Burner Base 1  

C3 Side Burner Ignition Pushbutton 1  

C4 Side Burner 1  

C5 Side Burner Electrode 1  

C6 Side Burner Grid 1  

C7 Side Burner Knob 1  

C8 Side Shelf 1  

C9 Tool Hook Support 1  

C10 Tool Hook 3  

C11 Beer Bottle Opener 1  

C12 Left Front Leg 1  

C13 Left Rear Leg 1  

C14 Right Front Leg 1  

C15 Right Rear Leg 1  

C16 Front Screen 1  

C17 Trolley Base 1  

C18 Axle 1  

C19 Wheel 2  

C20 Hubcap 2  

HARDWARE

D1 M5x15 Bolt 4  

D2 Spacer 4  

D3 M5 Nut 4  

D4 M6x95 Bolt 8  

D5 Washer 8  

D6 1/4-20UNCx25 Bolt 16  

D7 1/4-20UNCx12 Bolt 10  

D8 M6x10 Bolt 2  

D9 M6x15 Bolt 4  

D10 M6 Nut 4  

D11 M4 Step Screw 2  

D12 M4x10 Bolt 2  

D13 Butterfly Nut 1  

D14 Locknut 2  

 Pre-Assembled Component

 Quantity varies according to model purchased

Appearance, size, and construction may differ according to model purchased

Parts Diagrams

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see hardware pack page.

C13C12

B13

C16

B10

B11 B12 C8

C15

C17

C20

C11

C10

C14

C19

D14

C18

D13

Hardware Reference Diagram

Specifications subject to change without prior notice.

D1,D2,D3

D4,D5

D9,D10

D11

D12

Assembly

IMPORTANT!

 TOOLS NEEDED FOR ASSEMBLY: Medium size flat blade or Phillips/Crosspoint screwdriver,

adjustable spanner or metric spanner set.

 The assembly of this barbecue at least requires 2 people.

 Remove any internal components or packaging from the barbecue body.

 Whilst every care is taken in the manufacture of this product, care must be taken during assembly in

case sharp edges are present.

 Please read the Important Information section carefully before assembly and use of your

barbecue.

Attach the Legs (C12,C13,C14,C15) onto the Trolley Base (C17) use 1/4-20UNCx12 Bolts

(D7x8pcs) as shown.

Ensure Front legs with the hole for assembling Front Screen to them are at the facing

inwards of the barbecue.

C12

C13

C14

C15

C17

Unscrew the Locknuts (D14x2pcs) from both ends of the Axle (C18). Slide the axle through the

corresponding holes in the left legs. Slide the Wheels (C19) over each end of the axle. Secure the

wheels into place with the locknuts. Place the Hubcaps (C20) ont the outsides of the wheels.

C20 C19

D14 C18

Insert M6x95 Bolts (D4x8pcs) through the trolley legs, the Washers (D5x8pcs), and keep the tip of

the bolts inside the washers. While holding the barbecue body into position (2 people required),

screw the bolts into the barbecue body as shown.

CAUTION! Care must be taken to ensure the hood or lid does not fall open unexpectedly or

becomes damaged when it is set on the ground.

D5 D4

Attach Drip Tray Left Bracket (B11) to barbecue body using M5x15 Bolts (D1x2pcs), Spacers

(D2x2pcs) and M5 Nuts (D3x2pcs) as shown. Repeat above process for Drip Tray Right Bracket

(B12).

NOTE: Ensure that the big tabs of the brakets which stop the drip tray are located at the

front of the barbecue.

FRONT

REAR

B11D1 D2 D3

Remove the retaining bolts from Drip Tray Handle (B9), and then attach it onto the Drip Tray (B10)

using the retaining bolts.

Insert the Drip Tray by sliding it underneath the barbecue body.

B10

Attach the Beer Bottle Opener (C11) to the Right front leg using 1/4-20UNCx12 Bolts (D7x2pcs).

C11

C9C10 C8

Attach the Tool Hook (C10) to the Tool Hook Support (C9) as shown, Make sure the direction of

tool hook is facing outward. Attach the Tool hook assembly to the Side Shelf (C8) using M6x10

Bolts (D8x2pcs).

Attach the Side shelf and Tool hook assembly to the Right Front / Rear Legs using 1/4-20UCNx25

Bolts (D6x8pcs) as shown.

Attach the Side Burner Shelf (C1) to the Left Front / Rear Legs using 1/4-20UNCx25 Bolts

(D6x8pcs) as shown.

Nut

Unscrew the pre-assembled nut of the Ignition Button (C3). Insert the Ignition Button (C3) into the

hole at the Side Burner Base(C2) and secure with the pre-assembled nut.

Carefully lay the Side Burner Base(C2) into the Side Burner Shelf (C1) and make sure it is horizontal,

Then fixing the Side Burner Base using M6x15 Bolts (D9x4pcs) and M6 Nuts (D10x4pcs).

D10

Attach the side burner valve onto the Side Burner Base (C2) using M4x10 Bolts (D12x2pcs) as

shown.

Press the Side Burner Knob (C7) onto side burner valve stem.

D12

This manual suits for next models

Table of contents

Other Outback Grill manuals

Outback

Outback Omega 100 User manual

Outback

Outback THG3302S-3 User manual

Outback

Outback Omega 150 User manual

Outback

Outback Excelsior 3 User manual

Outback

Outback THG3302P User manual

Outback

Outback THG2302P-3 User manual

Outback

Outback Spectrum Flamer User manual

Outback

Outback Dual Fuel 2 User manual

Outback

Outback RS4491SC User manual

Outback

Outback Omega 100 User manual

Outback

Outback Orion User manual

Outback

Outback THG2216AW User manual

Outback

Outback Phoenix 4 Burner Black User manual

Outback

Outback Meteor 4S User manual

Outback

Outback Omega 201 User manual

Outback

Outback Omega 200 User manual

Outback

Outback Trekker User manual

Outback

Outback Hunter Plus 3 User manual

Outback

Outback CD200 User manual

Outback

Outback Modern Classic Trooper User manual

Outback

Outback THG3710SS-3 User manual

Outback

Outback NEW Apollo 4 User manual

Outback

Outback Excel 100T User manual

Outback

Outback Gourmet 4 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide