Prorack K890 User manual
K890
Fitting Kit
EN Fitting Instructions for Basic Carrier Glass/Panoramic roof CANNOT
be operated when roof bars are
installed
x 1 x 1 x 1 x 1
x 1 x 1 x 1 x 1
x 1 x 1 x 2
Revision No: 4D 1
Fitting Kit K890
MAX kgs (lbs)
W/P WHD
BMW
2 Series Active Tourer, 5dr MPV 14-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)
2 Series Active Tourer, 5dr MPV 14-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
2 Series Active Tourer, 5dr MPV 14-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)
2 Series Active Tourer, 5dr MPV 14-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit K890
X
A B C 1 2 3
2 Series Active Tourer, 5dr MPV 14-+ (AU) -255mm 435mm - 875mm 875mm -
-10 -1/16ths" 17 1/8ths" - 34 7/16ths" 34 7/16ths" -
2 Series Active Tourer, 5dr MPV 14-+ (NZ) -255mm 435mm - 875mm 875mm -
-10 -1/16ths" 17 1/8ths" - 34 7/16ths" 34 7/16ths" -
2 Series Active Tourer, 5dr MPV 14-+ (EU) -255mm 435mm - 875mm 875mm -
-10 -1/16ths" 17 1/8ths" - 34 7/16ths" 34 7/16ths" -
2 Series Active Tourer, 5dr MPV 14-+ (ZA) -255mm 435mm - 875mm 875mm -
-10 -1/16ths" 17 1/8ths" - 34 7/16ths" 34 7/16ths" -
3
Fitting Kit EN
K890
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
NOTE: Clamp images in these instructions may
not be representative of the clamps in this kit
4
Fitting Kit EN
K890
●Use keys to remove covers.
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
5
Fitting Kit EN
K890
●Remove locking screw.
●Apply protective strip as shown.
Trim if required.
●It is important to put the clamps in the
correct position on the vehicle.
●Letters refer to the part numbers stamped
on clamps.
●Clamp Part Number:
A = 563A
B = 564A
C = 565A
D = 566A
6
Fitting Kit EN
K890
●Attach clamp to each leg. NOTE; clamps
may have labels showing their positions on
the vehicle (For example; "Front Right").
●Refit locking screw so that it goes through
the hole in the clamp. Do not begin to
tighten the locking screw.
●Refer to the underside of the pad for the
part number.
7
Fitting Kit EN
K890
●It is important to put the pads in the correct
position on the vehicle.
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 242
B = 265
C = 266
●Place rubber pads (supplied with fitting kit)
on the vehicle roof. Pad may vary in shape
to that shown.
●Make sure the pad fits into the holes
underneath the foot.
8
Fitting Kit EN
K890
Fitment
●Clamps directly to edge of roof under the
doors
●Please check the front of this manual for
information relating specifically to your
vehicle.
●Place crossbar on vehicle. Minimum
recommended spacing between the bars is
700mm (27 1/2") (unless otherwise stated).
●Adjust the legs on the crossbar so that they
are positioned equally from the ends of the
crossbar, and the clamps engage firmly on
the body work of the vehicle.
●Tighten adjusting screw to 3 Nm (2.2 ft lb)
hand tight.
9
Fitting Kit EN
K890
●Tighten locking screw on both legs evenly,
3 Nm (2.2 ft lb).
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
10
Table of contents
Other Prorack Automobile Accessories manuals
Prorack
Prorack K546 Operation and installation manual
Prorack
Prorack K027 Operation and installation manual
Prorack
Prorack K934 Operation and installation manual
Prorack
Prorack K561 User manual
Prorack
Prorack K543 User manual
Prorack
Prorack K317 User manual
Prorack
Prorack K1003 User manual
Prorack
Prorack K1245 User manual
Prorack
Prorack K571 Install guide
Prorack
Prorack K382 User manual
Prorack
Prorack K137 Operation and installation manual
Prorack
Prorack K958 User manual
Prorack
Prorack K1187 User manual
Prorack
Prorack K577 Operation and installation manual
Prorack
Prorack K411 User manual
Prorack
Prorack T84HALF User manual
Prorack
Prorack K320 User manual
Prorack
Prorack PR3108 User manual
Prorack
Prorack K1020 User manual
Prorack
Prorack K938 User manual
