Prorack K621 User manual
K621
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 4 x 4 x 2 x 2
x 4 x 4 x 4 x 4
x 1 x 1
Revision No: 6C 1
Fitting Kit K621
MAX kgs (lbs)
W/P WHD
Mercedes
CLS Class W219, 4dr Sedan 04-10 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 US 75 kgs (165 lbs) 75 kgs (165 lbs)
CLS Class W219, 4dr Sedan 05-10 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
S Class W221, 4dr Sedan 06-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Subaru
WRX , 4dr Sedan 11-14 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
WRX , 4dr Sedan 11-14 US 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit EN
K621
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
3
Fitting Kit EN
K621
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Attaches to factory-fitted mounting points
●Please check the rear of this manual for
information relating specifically to your
vehicle.
●Adjust crossbar in or out to suit vehicle.
Refer to the crossbar instructions for
crossbar adjustment.
4
Fitting Kit EN
K621
●Tighten adjusting screw to 3 Nm (2.2 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Select plastic internal block (from fitting kit)
and insert into foot.
5
Fitting Kit EN
K621
●Repeat for all four positions.
●Open or remove fixed-point covers.
●Select four grubscrews and assemble them
into the adaptor using 3 mm (1/8") Hex
Key.
●NOTE: Mercedes only
●Select grubscrews and screw into the
vehicle's fixed points.
●Do not over tighten.
●Repeat for all four positions.
6
Fitting Kit EN
K621
●Sort M6 grubscrews into lengths.
●A = Mercedes CLS Class
B = Mercedes S Class / Subaru WRX
C = Not applicable unless advised
●Using the supplied Hex Key, tighten
grubscrew into position.
●Repeat for all four positions.
Fitment
●Refer to the underside of the pad for the
part number.
7
Fitting Kit EN
K621
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 224A
B = 225A
●Close all fixed-point covers so they rest on
the grubscrew and place pads over
grubscrews.
●It is important to put the pads in the correct
position on the vehicle.
8
Fitting Kit EN
K621
●Place crossbars on pads ensuring the pads
fit into the holes underneath the foot and
the grubscrew pass through the hole in the
foot.
All Configurations:
●Tighten the plastic knob. The side with the
nut showing should be facing up.
●Ensure the plastic knob is in the position
shown when fully tightened.
●Repeat for all four positions.
9
Fitting Kit EN
K621
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
CAUTION: Recheck all fasteners immediately after
a load is applied to the crossbars.
Regularly check screws are tight.
10
Table of contents
Other Prorack Automobile Accessories manuals
Prorack
Prorack K443 User manual
Prorack
Prorack K988 User manual
Prorack
Prorack K063 User manual
Prorack
Prorack K192 User manual
Prorack
Prorack K1094 User manual
Prorack
Prorack K482 Operation and installation manual
Prorack
Prorack K402 User manual
Prorack
Prorack K310 User manual
Prorack
Prorack K358 User manual
Prorack
Prorack K449 User manual
Prorack
Prorack K585 User manual
Prorack
Prorack K793 User manual
Prorack
Prorack K102 User manual
Prorack
Prorack K919 User manual
Prorack
Prorack PR3097 User manual
Prorack
Prorack K601 User manual
Prorack
Prorack K1143 User manual
Prorack
Prorack K122 User manual
Prorack
Prorack K546 Operation and installation manual
Prorack
Prorack K530 User manual
