Maytag MDG30PCC User manual

WARNING: For your safety the information in

this manual must be followed to minimize the

risk of fire or explosion or to prevent property

dama e, personal injury or death.

 Do not store or use asoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

 WHAT TO DO IF YOU SMELL GAS:

 Do not try to li ht any appliance.

 Do not touch any electrical switch; do not

use any phone in your buildin .

 Clear the room, buildin or area of all

occupants.

 Immediately call your as supplier from a

nei hbors phone. Follow the as suppliers

instructions.

 If you cannot reach your as supplier, call

the fire department.

 Installation and service must be performed by a

qualified installer, service a ency or the as

supplier.

AVERTISSEMENT: Assurez-vous de bien

suivre les instructions données dans cette notice

pour réduire au minimum le risque dincendie

ou dexplosion ou pour éviter tout domma e

matériel, toute blessure ou la mort.

 Ne pas entreposer ni utiliser dessence ni

dautres vapeurs ou liquides inflammables à

proximité de cet appareil ou de tout autre

appareil.

 QUE FAIRE SI VOUS SENTEZ UNE ODEUR

DE GAZ:

 Ne pas tenter dallumer dappareils.

 Ne touchez à aucun interrupteur. Ne pas

vous servir des téléphones se trouvant dans

le bâtiment.

 Évacuez la pièce, le bâtiment ou la zone.

 Appelez immédiatement votre fournisseur

de az depuis un voisin. Suivez les

instructions du fournisseur.

 Si vous ne pouvez rejoindre le fournisseur

de az, appelez le service des incendies.

 Linstallation et lentretien doivent être assurés par

un installateur ou un service dentretien qualifié

ou par le fournisseur de az.

072303MGOLDSTEIN/tcosta Part No. 113201

MDG30PCC

(30 Lb Single Pocket, Phase 7 Coin)

Installation Manual

RETAIN THESE INSTRUCTIONS IN A SAFE

PLACE FOR FUTURE REFERENCE

IMPORTANT NOTE TO PURCHASER

Information must be obtained from your local as supplier on the instructions

to be followed if the user smells as. These instructions must be posted in a

prominent location near the dryer.

FOR YOUR SAFETY

Do not store or use asoline or

other flammable vapors and

liquids in the vicinity of this or

any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser dessence

ni dautres vapeurs ou liquides

inflammables à proximité de cet

appareil ou de tout autre appareil.

Retain This Manual In A Safe Place For Future Reference

Our products embody advanced concepts in engineering, design, and safety. If this product is properly maintained, it will

provide many years of safe, efficient, and trouble free operation.

ONLY qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with

the dryer.

The following FOR YOUR SAFETY caution must be posted near the dryer in a prominent location.

We have tried to ake this anual as co plete as possible and hope you will find it useful. The anufacturer reserves the

right to ake changes fro ti e to ti e, without notice or obligation, in prices, specifications, colors, and aterial, and to

change or discontinue odels. The illustrations included in this manual may not depict your particular dryer exactly.

Important

For your convenience, log the following information

DATE OF PURCHASE ________________________________ MODEL NO. __________________________________________

DEALERS NAME __________________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

________________________________________________________________________________________

For replacement parts, contact the dealer from which the dryer was purchased or contact:

MAYTAG CO.

403 West Fourth Street North

Newton, Iowa 5020

(641) 7 7-7000

MDG30PCC

WARNING

UNDER NO CIRCUMSTANCES should the door switch or the heat circuit devices

ever be disabled.

IMPORTANT

YOU MUST DISCONNECT AND LOC OUT THE ELECTRIC SUPPLY AND THE GAS

SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR GUARDS ARE

REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER OSHA

(Occupational Safety and Health Administration) STANDARDS.

WARNING

CHILDREN SHOULD NOT BE ALLOWED TO PLAY ON OR NEAR THE DRYER(S).

CHILDREN SHOULD BE SUPERVISED IF NEAR DRYERS IN OPERATION.

CAUTION

DRYERS SHOULD NE ER BE LEFT UNATTENDED WHILE IN OPERATION.

FOR YOUR SAFETY

DO NOT DRY MOP HEADS IN THE DRYER.

DO NOT USE DRYER IN THE PRESENCE OF DRY CLEANING FUMES.

Caution: Label all wires prior to

disconnection when servicing controls. Wiring

errors can cause improper operation.

«Attention: Au moment de lentretien des

commandes, étiquetez tous les fils avant de

les débrancher. Des erreurs de câblage

peuvent entraîner un fonctionnement

inadéquat et dangereux.»

WARNING

The dryer must never be operated with any of the back guards, outer tops, or service

panels removed. PERSONAL INJURY OR FIRE COULD RESULT.

IMPORTANT

PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment and/or

specified in the installation manual included with the dryer.

WARNING

DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN IN

PLACE, EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED.

Dryer must not be installed or stored in an area where it will be exposed to water or weather.

The wiring diagram for the dryer is located in the front electrical control box area.

IMPORTANT

Dryer must be installed in a location/environment, which the ambient temperature

remains between 40° F (4.44° C) and 130° F (54.44° C).

SECTION I

SAFETY PRECAUTIONS ......................................................................................... 3

SECTION II

SPECIFICATIONS ..................................................................................................... 5

SECTION III

INSTALLATION PROCEDURES ........................................................................... 7

A. Unpackin and Settin Up .......................................................................................................... 7

B. Location Requirements ............................................................................................................... 8

C. Dryer Enclosure Requirements .................................................................................................... 9

D. Fresh Air Supply Requirements ................................................................................................. 10

E. Exhaust Requirements ............................................................................................................... 11

F. Electrical Information ................................................................................................................ 17

G. Gas Information ........................................................................................................................ 20

H. Preparation For Operation and Start-Up ................................................................................... 24

I. Preoperational Tests ................................................................................................................. 25

J. Preoperational Instructions ........................................................................................................ 26

K. Shutdown Instructions ............................................................................................................... 27

SECTION V

SERVICE/PARTS INFORMATION ...................................................................... 28

A. Service ..................................................................................................................................... 28

B. Parts ........................................................................................................................................ 28

SECTION V

WARRANTY INFORMATION ............................................................................... 29

A. Returnin Warranty Cards ......................................................................................................... 29

B. Warranty .................................................................................................................................. 29

SECTION VI

ROUTINE MAINTENANCE .................................................................................. 30

A. Cleanin ................................................................................................................................... 30

B. Adjustments ............................................................................................................................. 31

C. Lubrication ............................................................................................................................... 31

SECTION VII

DATA LABEL INFORMATION ............................................................................. 32

Table of Contents

SECTION VIII

PROCEDURE FOR FUNCTIONAL CHECK OF REPLACEMENT

COMPONENTS ........................................................................................................ 3

SECTION IX

MANUAL RESET BURNER HI-LIMIT INSTRUCTIONS ............................... 36

SECTION I

SAFETY PRECAUTIONS

WARNING: For your safety, the information in this manual must be followed to minimize the risk of

fire or explosion or to prevent property damage, personal injury, or loss of life.

WARNING: The dryer must never be operated with any of the back guards, outer tops, or

service panels re oved. PERSONAL INJURY OR FIRE COULD RESULT.

1. DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

2. Purchaser or user should consult the local gas supplier for proper instructions to be followed in the event the

user smells gas. The instructions should be posted in a prominent location.

3. WH T TO DO IF YOU SMELL G S:

a. DO NOT try to light any appliance.

b. DO NOT touch any electrical switch.

c. DO NOT use any phone in your building.

d. Clear the room, building, or area of ALL occupants.

e. Immediately call your gas supplier from a neighbors phone. Follow the gas suppliers instructions.

f. If you cannot reach your gas supplier, call the fire department.

4. Installation and service must be performed by a qualified installer, service agency, or gas supplier.

5. Dryers must be exhausted to the outdoors.

6. lthough Maytag produces a very versatile dryer, there are some articles that, due to fabric composition or

cleaning method, should not be dried in it.

WARNING: Dry only water washed fabrics. DO NOT dry articles spotted or washed in dry

cleaning solvents, a combustible detergent, or all purpose cleaner.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry rags or articles coated or contaminated with gasoline, kerosene, oil, paint,

or wax.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry mop heads. Contamination by wax or flammable solvents will create a

fire hazard.

WARNING: DO NOT use heat for drying articles that contain plastic, foam, sponge rubber, or

similarly textured rubber materials. Drying in a heated basket (tumbler) may damage

plastics or rubber and may be a fire hazard.

7. program should be established for the inspection and cleaning of lint in the burner area, exhaust ductwork,

and area around the back of the dryer. The frequency of inspection and cleaning can best be determined

from experience at each location.

WARNING: The collection of lint in the burner area and exhaust ductwork can create a potential fire

hazard.

8. For personal safety, the dryer must be electrically grounded in accordance with local codes and/or the

National Electrical Code NSI/NFP NO. 70-L TEST EDITION or in Canada, the Canadian Electrical

Codes Parts 1 & 2 CS C22.1-1990 or L TEST EDITION.

NOTE: Failure to electrically ground the dryer properly will VOID THE WARRANTY.

9. UNDER NO CIRCUMSTANCES should the door switch or the heat circuit devices ever be disabled.

WARNING: PERSONAL INJURY OR FIRE COULD RESULT should the door switch or the

heat circuit devices ever be disabled.

10. This dryer is not to be used in the presence of dry cleaning solvents or fumes.

11. Remove articles from the dryer as soon as the drying cycle has been completed.

WARNING: Articles left in the dryer after the drying and cooling cycles have been completed can

create a fire hazard.

12. READ AND FOLLOW ALL CAUTION AND DIRECTION LA ELS ATTACHED TO THE

DRYER.

13. For safety, proper operation, and optimum performance, the dryer must not be operated with a load less

than sixty-six percent (66%) 19 lbs (8 kg) of its rated capacity.

WARNING: YOU MUST DISCONNECT AND LOCK OUT THE ELECTRIC SUPPLY

AND THE GAS SUPPLY BEFORE ANY COVERS OR GUARDS ARE

REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER

OSHA (Occupational Safety and Health Administration) STANDARDS.

IMPORTANT: Dryer must be installed in a location/environ ent, which the a bient

te perature re ains between 40º F (4.44º C) and 130º F (54.44º C).

SECTION II

SPECIFICATIONS

GAS

0$;,080&$3$&,7<'5<:(,*+7 OEV NJ

%$6.(7780%/(5',$0(7(5 ´ FP

%$6.(7780%/(5'(37+ ´ FP

%$6.(7780%/(502725  KS N:

'22523(1,1*',$0(7(5  ´ FP

%$6.(7780%/(592/80(   FXIW FXP

'5<(563(5 ¶¶&217$,1(5   

'5<(563(5¶¶758&.  

92/7$*($9$,/$%/(  Y¡¡Z+]

$3352;:(,*+781&5$7(' OEV NJ

$3352;:(,*+7&5$7(' OEV NJ

+($7,1387 %WXKU NFDOKU

$,5)/2: FIP FPP

,1/(73,3(&211(&7,21  ´0137

Shaded areas are stated in metric equivalents 8/1/03

* Size of piping to dryer varies with installation conditions. Contact factory for assistance.

NOTE: Manufacturer reserves the right to make changes in specifications at any time without notice or

obligation.

NOTE: Manufacturer reserves the right to make changes in specifications at any time without notice or

obligation.

SPECIFICATIONS  GAS ONLY

Other manuals for MDG30PCC

Table of contents

Other Maytag Dryer manuals

Maytag

Maytag MDG28PD User manual

Maytag

Maytag MD7657 User manual

Maytag

Maytag HY-1 53-4350 User manual

Maytag

Maytag Neptune MD4000 User manual

Maytag

Maytag MLG33 Administrator Guide

Maytag

Maytag MGDB835DC User manual

Maytag

Maytag EPIC z MEDZ600T Manual

Maytag

Maytag MGD6300TQ - Bravos Gas Dryer User manual

Maytag

Maytag MGD7100D User manual

Maytag

Maytag SD-7 User manual

Maytag

Maytag MLG45PDBWW User manual

Maytag

Maytag MGDB835DW4 User manual

Maytag

Maytag MLE27PN User manual

Maytag

Maytag 3397600 User manual

Maytag

Maytag 3397621 User manual

Maytag

Maytag NEPTUNE MD7500 User manual

Maytag

Maytag MEDE201YW User manual

Maytag

Maytag MDE6700A Series Manual

Maytag

Maytag MED5900TW0 User manual

Maytag

Maytag MEDE500VW - Performance Series 27 Inch Electric... User manual

Maytag

Maytag MEDX500BW User manual

Maytag

Maytag MDE22PNAGW0 User manual

Maytag

Maytag MAWADRGW04 Assembly instructions

Maytag

Maytag MDE9601 User manual

Popular Dryer manuals by other brands

Bosch

Bosch WTA79200GB Installation and operating instructions

Amana

Amana W10233410A Use and care guide

Miele

Miele TWH 780 WP operating instructions

Asko

Asko T760 user guide

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Original instructions

Bosch

Bosch Logixx 10 WTB76556GB Instruction manual and installation instructions

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Operation and installation

Electrolux

Electrolux EW2H328R2 user manual

Beko

Beko DS8433RX1M user manual

Dawlance

Dawlance Spinner DS 6000 C owner's manual

Electrolux

Electrolux TP5080TW user manual

AEG

AEG TR838P4OB user manual

Indesit

Indesit IDV 75 instruction manual

Infiniton

Infiniton SD-DG85C manual

BOMANN

BOMANN WT 5019 instruction manual

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Installation

Asko

Asko T793C operating instructions

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer installation instructions