Jacuzzi J - 210 User manual

Ozonator

TB1

230 VAC, 3-Wire Connection

USE COPPER CONDUCTORS ONLY. WIRE SIZE MUST

BE APPROPRIATE PER NEC AND/OR LOCAL CODES

Flow Switch

Hi-limit/Freeze Sensor

Temperature Sensor

20A

250V

SC-20

Circ.

Pump

Main

Pump

Spa

Light

Transformer

230 VAC

HILO

GRN

Logic Jumper Settings

All Export 50 Hz Models:

JP1 1-2 ON = 20A Logic*

JP1 1-2 OFF = 30A Logic

*Factory Jumper Setting

Temp. Jumper Settings (All Models):

JP1 7-8 ON = Celsius Temp Display

JP1 7-8 OFF = Fahrenheit Temp Display

BLU BRN

JP1

6 5

8 7

Heater Specifications

• Export 50 Hz Model:

2.7 kW @ 230 VAC

J20

J21

J12

J14

J16

J11

J15

J13

J17 J7 J8 J9 J10

Heater IN Heater OUT

K5 K7 K8

BLK

WHT

BRN

BLU

BRN

BLK BLU BRN BLU BRN

Control Panel

LED Series Hot Tub Owner’s Manual

J-210, J-220, J-230 Models

2530-379, Rev-A

Attention New Spa Owner!

Congratulations on the purchase of your new Jacuzzi® spa! The following is a list

of automated functions performed by your spa. These functions are listed below

in an attempt to suppress any operational concerns you may have during the rst

24-hours of ownership! Also listed below are important maintenance recommen-

dations you should observe on a regular basis to protect your new investment.

Automated Operations

Approximately two minutes after power is applied to the spa, the rst ltration/

heating cycle turns on pump 1. In J-230 models, an automatic ve minute “blow-

out” function also activates pump 2 for a period of ve minutes to ush all lines.

Then, after ve minutes, pump 2 turns off and pump 1 continues to operate for

the duration of the cycle. Note: this function only occurs during the rst ltration/

heating cycle each day.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters as

dened by the Association of Pool And Spa Professionals/USA:

Always maintain your spas lter as outlined below to ensure healthy spa water.

Refer to page 29 “Water Quality Maintenance” for additional information.

Required Filter Maintenance

Your new spa is equipped with an advanced water ltration system that provides

unsurpassed water quality! To ensure maximum water quality at all times, you

should clean the lter cartridge every three months, or earlier as necessary. See

page 25 for detailed lter cartridge cleaning/replacement instructions.

Required Water Replacement

You should replace the spa’s water every 3 months. The frequency depends on

a number of variables including frequency of use, number of users, and attention

paid to water quality maintenance. You will know it is time for a change when you

cannot control sudsing and/or you can no longer get

the normal feel or sparkle to

the water, even though the key water balance measurements are all within the

proper parameters. See page 29-30 for additional information.

Free Chlorine

Free Bromine

Total Alkalinity

Calcium Hardness

7.4 - 7.6

100-120 ppm

150-250 ppm

3.0-4.0 ppm

2.0-4.0 ppm

Table of Contents

1.0 Important Spa Owner Information..............................................1

2.0 FCC Notice....................................................................................1

3.0 Important Safety Instructions .....................................................2

4.0 Choosing A Location ...................................................................7

4.1 Outdoor Location ...........................................................................7

4.2 Indoor Location ..............................................................................7

5.0 General Electrical Safety Instructions .......................................9

6.0 Power Requirements .................................................................10

7.0 Electrical Wiring Instructions ...................................................11

8.0 Spa Fill Up Procedure ...............................................................14

9.0 Control Functions ......................................................................18

9.1 Control Panel ...............................................................................18

9.2 Spa Features And Controls..........................................................19

9.3 Jet/Air Controls Diagram (J-210 & J-220 Models) .......................20

9.4 Jet/Air Controls Diagram (J-230 Models).....................................21

10.0 Operating Instructions ..............................................................22

10.1 Setting Water Temperature ..........................................................22

10.2 Activate Pumps ............................................................................22

10.3 Multi-Colored LED Light Operation..............................................22

10.4 Selecting Desired Message Action ..............................................23

10.5 Adjusting Individual Jet Flow .......................................................23

10.6 Air Controls ..................................................................................23

11.0 Automatic Filtration Cycles ......................................................24

11.1 Standard Filtration/Heating Modes (F1-F3) .................................24

11.2 Economy Filtration/Heating Modes (F4-F6).................................24

11.3 Lock Modes (L1-L2).....................................................................24

11.4 Selecting The Filtration/Heating Mode.........................................24

12.0 Spa Maintenance........................................................................25

12.1 Cleaning The Filter.......................................................................25

12.2 Draining and Refilling...................................................................26

12.3 Cleaning The Spa Interior............................................................26

12.4 Pillow Care (J-220/J-230 Only)....................................................27

12.5 Maintaining The Cover.................................................................27

12.6 Maintaining The Synthetic Cabinet ..............................................27

12.7 Winterizing ...................................................................................28

11.8 Restarting Your Spa in Cold Weather..........................................28

13.0 Water Quality Maintenance .......................................................29

13.1 pH Control....................................................................................29

13.2 Sanitizing......................................................................................29

13.3 Optional CD Ozone Water Maintenance System ........................30

14.0 Error Conditions/Error Messages ............................................30

14.1 Panel Displays SN1 .....................................................................30

14.2 Panel Displays SN2 .....................................................................30

14.3 Panel Displays FL1 ......................................................................30

14.4 Panel Displays FL2 ......................................................................30

14.5 Panel Displays COL.....................................................................30

14.6 Panel Displays ICE ......................................................................31

14.7 Panel Displays OH.......................................................................31

14.8 Panel Displays - - - - ...................................................................31

15.0 Troubleshooting Procedures ....................................................31

15.1 None of The Components Operate (e.g. Pump, Light)................31

15.2 Pump Does Not Operate But Light Does.....................................31

15.3 Poor Jet Action.............................................................................32

15.4 Water is Too Hot ..........................................................................32

15.5 No Heat........................................................................................32

16.0 J-210/J-220 Convertible Circuit Diagram (60Hz) .....................33

17.0 J-230 Circuit Diagram (60Hz) ....................................................34

18.0 J-220 Export Circuit Diagram (50Hz)........................................35

19.0 J-230 Export Circuit Diagram (50Hz)........................................36

page 1

1.0 Important Spa Owner Information

Your Jacuzzi®200 series spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for effi-

cient operation, an uncovered spa surface directly exposed to sunlight

and high temperatures for an extended period is subject to permanent

damage. Damage caused by exposing the spa to this abuse is not

covered under warranty. We recommend that you always keep the spa

full of water when it is exposed to direct sunlight and that you keep the

Jacuzzi premium insulating cover in place at all times when the spa is

not in use. Read and carefully follow the requirements for your spa’s

support base found in section 4.0 titled, “Choosing a Location” (page 7).

Jacuzzi constantly strives to offer the finest spas available, there-

fore modifications and enhancements may be made which affect

the specifications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to

try to correct the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modifications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

page 2

3.0 IMPORTANT SAFETY INSTRUCTIONS

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY

When installing and using this electrical equipment, basic safety precau-

tions should always be followed, including:

1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm2) solid copper conduc-

tor between this unit and any metal equipment, metal enclosures

of electrical equipment, metal water pipe, or conduit within 5 feet

(1.5m) of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

4. DANGER: Risk of Injury. The suction fittings in this spa are sized to

match the specific water flow created by the pump. Should the need

arise to replace the suction fittings or the pump, be sure that the

flow rates are compatible. Never operate the spa if the suction fit-

tings are broken or missing. Never replace a suction fitting with one

rated less than the flow rate marked on the original suction fitting.

5. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m), from

all metal surfaces. As an alternative, a spa may be installed within

5 feet of metal surfaces if each metal surface is permanently con-

nected (bonded) by a minimum No. 8 AWG (8.4 mm2) solid copper

conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

6. DANGER: Risk of Electric Shock. Do not permit any electrical appli-

ance, such as a light, telephone, radio, television, etc. within 5 feet

(1.5m) of a spa unless such appliances are built-in by the manufac-

turer.

7. ELECTRICAL SUPPLY: The electrical supply for this product

must include a suitably rated switch or circuit breaker to open all

ungrounded supply conductors to comply with section 422-20 of the

National Electrical Code/USA, ANSI/NFPA 70. The disconnect must

be readily accessible and visible to the spa occupant but installed at

least 5 feet (1.5m), from the spa water.

page 3

8. WARNING: To Reduce the Risk of Injury:

9. The water in the spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are consid-

ered safe for a healthy adult. Lower water temperatures are recom-

mended for young children and when spa use may exceed 10 min-

utes.

10. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant or

possibly pregnant women should limit spa water temperatures to

100°F (38°C). If pregnant, please consult your physician before

using a spa.

11. Before entering the spa, the user should measure the water

temperature with an accurate thermometer since the tolerance of

water temperature-regulating devices may vary as much as +/- 5°F

(2°C).

12. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

13. Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deficiency syndromes should consult

a physician before using a spa. If you experience breathing difficul-

ties in association with using or operating your spa, discontinue use

and consult your physician.

14. Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

15. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, dis-

continue use and seek medical attention.

page 4

IMPORTANT CSA SAFETY INSTRUCTIONS (CANADA ONLY)

When using this electrical equipment, basic safety precautions should

always be followed, including the following:

1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol* is located inside the supply terminal

box or compartment. To reduce the risk of electric shock, this

terminal must be connected to the grounding means provided in the

electric supply service panel with a continuous copper wire equiva-

lent in size to the circuit conductors that supply this equipment.

*IEC Publication 417, Symbol 5019.

3. At least two lugs marked “Bonding Lugs” are provided on the exter-

nal surface or on the inside of the supply terminal box/compartment.

To reduce the risk of electric shock, connect the local common

bonding grid in the area of the spa to these terminals with an insu-

lated or bare copper conductor not smaller than No. 6 AWG (10

mm2).

4. All field installed metal components such as rails, ladders, drains

or other similar hardware within 10 feet (3m) of the spa shall be

bonded to the equipment grounding buss with copper conductors

not smaller than No. 6 AWG (10 mm2).

5. SAVE THESE INSTRUCTIONS.

WARNING: Children should not use spas without adult supervision.

WARNING: Do not use spas unless all suction guards are installed to

prevent body and hair entrapment.

WARNING: People with infectious diseases should not use a spa.

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING: Do not use drugs or alcohol before or during the use of a

spa to avoid unconsciousness and possible drowning.

WARNING: Pregnant or possibly pregnant women should consult a

physician before using a spa.

page 5

WARNING: Water temperature in excess of 40°C (104°F) may be injuri-

ous to your health.

WARNING: Before entering the spa, measure the water temperature

with an accurate thermometer.

WARNING: Do not use a spa immediately following strenuous exercise.

WARNING: Prolonged immersion in a spa may be injurious to your

health.

WARNING: Do not permit electric appliances (such as lights, telephone,

radio, television, etc.) within 5 feet (1.5m) of this spa unless such appli-

ances are built-in by the manufacturer.

CAUTION: Maintain water chemistry in accordance with manufacturer’s

instructions.

WARNING: The use of alcohol or drugs can greatly increase the risk of

fatal hyperthermia in spas.

SAVE THESE INSTRUCTIONS

HYPERTHERMIA

Prolonged immersion in hot water may induce hyperthermia. A descrip-

tion of the causes, symptoms, and effects of hyperthermia are as fol-

lows:

Hyperthermia occurs when the internal temperature of the body reaches

a level several degrees above the normal body temperature of 98.6°F

(37°C). The symptoms of hyperthermia include drowsiness, lethargy,

and an increase in the internal temperature of the body. The effects of

hyperthermia include:

1. Unawareness of impending hazard;

2. Failure to perceive heat;

3. Failure to recognize the need to exit spa;

4. Physical inability to exit spa;

5. Fetal damage in pregnant women; and

6. Unconsciousness and danger of drowning.

page 6

A warning sign is provided in your warranty packet. Please

install it at a location near your spa, where it is visible to the

user of the spa. For additional or replacement signs please

contact your local Jacuzzi spas dealer and reference item num-

ber #6530-082.

CAUTIONS

1. Persons suffering from heart disease, diabetes, high or low blood

pressure, and any condition requiring medical treatment, pregnant

women, the elderly, or infants should consult with a physician before

using a spa.

2. The Consumer Products Safety Commission/USA has stated that

the water temperature in a spa should not exceed 104°F (40°C).

Immersion in water in excess of 104°F (40°C) can be hazardous to

your health.

3. Observe a reasonable time limit when using the spa. Long expo-

sures at higher temperatures can cause high body temperature.

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drown-

ing.

4. Do not use the spa under the influence of alcohol, narcotics, or

other drugs. Use of the spa under these conditions may lead to seri-

ous consequences.

5. Always test the spa water temperature before entering the spa.

Enter and exit the spa slowly. Wet surfaces can be very slippery.

6. Never bring any electrical appliances into or near the spa. Never

operate any electrical appliances from inside the spa or when you

are wet unless such appliances are built-in by the manufacturer.

7. Proper chemical maintenance of spa water is necessary to

maintain safe water and prevent possible damage to spa compo-

nents.

8. Use the straps and clip tie downs to secure the cover when not in

use. This will help to discourage unsupervised children from enter-

ing the spa and keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

Other manuals for J - 210

This manual suits for next models

Table of contents

Other Jacuzzi Hot Tub manuals

Jacuzzi

Jacuzzi Amiga BE30-LH User manual

Jacuzzi

Jacuzzi J - 480 User manual

Jacuzzi

Jacuzzi Finestra 6036 User manual

Jacuzzi

Jacuzzi Spa MAXI Andros User manual

Jacuzzi

Jacuzzi J - 375 User manual

Jacuzzi

Jacuzzi Laser User manual

Jacuzzi

Jacuzzi Signa 5 Whirlpool Bath and Soaking Bath 9625 User manual

Jacuzzi

Jacuzzi NOVA 6 User manual

Jacuzzi

Jacuzzi Finestra 6036 User manual

Jacuzzi

Jacuzzi AERO PLUS PortableWhirlpoolSpa User manual

Jacuzzi

Jacuzzi PowerActive Swim Spa Series User manual

Jacuzzi

Jacuzzi 200 Series User manual

Jacuzzi

Jacuzzi Pure Air User manual

Jacuzzi

Jacuzzi Fuzion 7260 User manual

Jacuzzi

Jacuzzi J-300 Series Instruction manual

Jacuzzi

Jacuzzi 2003+ User manual

Jacuzzi

Jacuzzi J-300 J-315 User manual

Jacuzzi

Jacuzzi NOVA 6 User manual

Jacuzzi

Jacuzzi LCD Series User manual

Jacuzzi

Jacuzzi Profile User manual

Jacuzzi

Jacuzzi J - 400 SERIES J - 465 User manual

Jacuzzi

Jacuzzi Platinum Series User manual

Jacuzzi

Jacuzzi J-ALLURE J-ALLURELuxury Bathing and Entertainment... User manual

Jacuzzi

Jacuzzi Opalia 9635 User manual

Popular Hot Tub manuals by other brands

Bestway

Bestway Lay-Z-Spa 54189 manual

Morphy Richards

Morphy Richards Essentials PC4006 user manual

Softub

Softub PRESTIGE Owners Manual Water Treatment Guide

JNJ SPAS

JNJ SPAS SPA-318 Programming instructions

KIRAMI

KIRAMI Comfort Family Instructions for use

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) owner's manual

HoMedics

HoMedics FB-655HJ-GB manual

Everyday Hot Tubs

Everyday Hot Tubs 530 owner's manual

anko

anko SS-601A user manual

Pooli

Pooli OS030979B product manual

ab Solares Smart Spa operating manual

CalderaSpas

CalderaSpas CalderaSpas Utopia Series owner's manual

Outsunny

Outsunny 848-047V70 Assembly guide

Aquatic

Aquatic INFINITY 1 Specifications

Master Spas

Master Spas MP Force owner's manual

Asteria

Asteria 5630 owner's manual

Image

Image IMSB61610, IMSG61610 user manual

ViSAGE

ViSAGE FM-588D user manual