Jacuzzi J - 375 User manual

•J-385™

•J-375™

•J-365™

•J-355™

•J-345™

•J-335™

•J-325™

•J-315™

J-300™ COLLECTION

OWNER’S MANUAL

2530-398D Rev A

Attention New Spa Owner!

Congratulations on the purchase of your new Jacuzzi®spa! The following is a

list of automated functions performed by your spa. These functions are listed

below in an attempt to alleviate any operational concerns you may have during

the rst 24 hours of ownership! Also listed below are important maintenance

recommendations you should observe on a regular basis to protect your new

investment.

Automated Operations

Your new spa is equipped with an automated “clean-up” cycle that clears all

plumbing lines daily to promote maximum water sanitation. Each day at 12:00

PM (noon), each pump will activate and run for one minute. If either pump

has just nished a 20 minute time out, it will not automatically activate for the

clean-up cycle.

Note: Turning off the corresponding jets pump that is running can deactivate the

feature.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters:

With CLEARRAY® Without CLEARRAY®

pH 7.4-7.6 7.4-7.6

Free Chlorine no less than 1.0 ppm 3.0-4.0 ppm

Free Bromine no less than 2.0 ppm 2.0-4.0 ppm

Total Alkalinity 100-150 ppm 100-150 ppm

Calcium Hardness 150-250 ppm 150-250 ppm

IMPORTANT: CLEARRAY® Water Purication System is factory installed. If

the CLEARRAY® system is altered or is not operating efciently then follow the

“without CLEARRAY®” water chemistry parameters as dened by the Asso-

ciation of Pool and Spa Professionals. CLEARRAY® requires an annual bulb

replacement to properly sanitize your water.

!TO DECREASE RISK OF INFECTION OR DISEASE! Always maintain

your spas lter as outlined below to ensure healthy spa water. Refer page 46

“Water Quality Maintenance” for additional information.

Required Filter Maintenance

Your new spa is equipped with an advanced water ltration system that provides

unsurpassed water quality! To ensure maximum water quality at all times, you

should clean both lter cartridges every month, or earlier as necessary. See page

39 for detailed lter cartridge cleaning/replacement instructions.

Required Water Replacement

!TO DECREASE RISK OF INFECTION OR DISEASE!

You should replace

the spa’s water every 3 months. The frequency depends on a number of variables

including frequency of use, number of users, and attention paid to water quality

maintenance. You will know it is time for a change when you cannot control

sudsing and/or you can no longer get

the normal feel or sparkle to the water,

even though the key water balance measurements are all within the proper

parameters. See page 46 for additional information.

**Specications and operations subject to change without notice.**

J-300

Table of Contents

1.0 Important Spa Owner Information...................................1

2.0 FCC Notice ........................................................................1

3.0 Important Safety Instructions for all Spa Owners .........2

3.1 Entrapment Risk .................................................................6

3.2 Hyperthermia ......................................................................7

3.3 Important Additional CSA Safety Instructions

(Canada Only) ....................................................................8

3.4 General Electrical Safety Instructions.................................8

4.0 Choosing A Location........................................................9

4.1 Outdoor Location ..............................................................10

4.2 Indoor Location.................................................................10

4.3 Location for the Optional ProLink™

Remote Monitoring System ..............................................11

5.0 General Electrical Safety Instructions..........................12

6.0 Power Requirements......................................................13

7.0 Electrical Wiring Instructions........................................15

8.0 Spa Fill Up Procedure ....................................................20

9.0 Control Functions...........................................................25

9.1 Control Panel....................................................................25

9.2 General Spa Features And Controls.................................26

10.0 Operating Instructions ...................................................27

10.1 Register Your New Spa ....................................................27

10.2 Completing Your Registration ...........................................28

10.3 Setting Water Temperature...............................................28

10.4 Activate Jet Pumps...........................................................29

10.5 Light On/Off Button...........................................................29

10.6 Light Mode Button.............................................................29

10.7 Jets ...................................................................................30

10.8 Selecting Desired Massage Action ...................................30

10.9 Waterfall Feature ..............................................................30

10.10 CLEARRAY on Demand...................................................30

10.11 Air Controls .......................................................................31

10.12 Optional BLUEWAVE® Spa Stereo System .....................31

10.13. Blow-Out Cycle .................................................................31

10.14 Cleanup Cycle ..................................................................31

J-300

11.0 Menu Features and Programming Instructions...........32

11.1 Primary Filtration Menu.....................................................32

11.2 Secondary Filtration Menu................................................33

11.3 Programming the Heating Mode.......................................34

11.4 Programming the Change Filter Timer .............................35

11.5 Programming the CLEARRAY Timer................................35

11.6 Programming the Water Refresh Timer............................36

11.7 Programming the Time .....................................................36

11.8 Programming the Date......................................................37

11.9 Programming the Temperature Format ............................37

11.10 Programming the Language .............................................37

11.11 Programming the Lock Feature ........................................38

11.12 Resetting the Wi-Fi Connection (optional feature)............38

12.0 Spa Maintenance ............................................................39

12.1 Cleaning The Filters..........................................................39

12.2 DrainingandRelling........................................................42

12.3 Pillow Care........................................................................43

12.4 Cleaning The Spa Interior.................................................43

12.5 Cover Care and Maintenance...........................................43

12.6 Tool Free Access Door .....................................................44

12.7 Maintaining The Synthetic Cabinet...................................45

12.8 Winterizing ........................................................................45

12.9 Restarting Your Spa in Cold Weather...............................46

13.0 Water Quality Maintenance............................................46

13.1 pH Control.........................................................................47

13.2 Sanitizing ..........................................................................47

13.3 CLEARRAY®(Ultraviolet)WaterPuricationSystem ......48

13.4 CLEARRAY® Bulb Replacement and

Quartz Tube Maintenance ................................................49

14.0 Error Conditions/Error Messages .................................51

14.1 Summer Logic...................................................................51

14.2 Panel Displays COOL.......................................................51

14.3 Panel Displays ICE...........................................................52

14.4 Panel Displays SN--1........................................................52

14.5 Panel Displays SN--2........................................................52

14.6 Panel Displays Change CLEARRAY Bulb........................52

14.7 Panel Displays Change Filter ...........................................52

14.8 Panel Displays Change Water..........................................52

14.9 Panel Displays FL--1 ........................................................53

14.10 Panel Displays FL--2 ........................................................53

14.11 Panel Displays OH............................................................53

14.12 Panel Displays (-- -- -- --) ..................................................53

J-300

15.0 Troubleshooting Procedures.........................................54

15.1 FL--1 and FL--2.................................................................54

15.2 None of the Components Operate (e.g. Pump, Light) ......54

15.3 Pump Does Not Operate ..................................................54

15.4 Poor Jet Action .................................................................55

15.5 Water is Too Hot ...............................................................55

15.6 No Heat.............................................................................55

16.0 Circuit Board Diagrams..................................................56

16.1 North American J-335, J-345, J-355, J-365,

J-375 and J-385 Dedicated Power Models (60 Hz)..........56

16.2 North American J-315 and J-325 Convertible Power

Models (For a 3-wire 120V 60 Hz connection) .................57

16.3 North American J-315 and J-325 Convertible Power

Models (For a 4-wire 240V 60 Hz connection) .................58

16.4 Export J-335, J-345, J-355, J-365, J-375 and

J-385 Models (50 Hz) .......................................................59

16.5 Export J-315 and J-325 Models (50 Hz)...........................60

17.0 Dip Switch Settings and Wiring.....................................61

17.1 Switch settings for Domestic 60Hz Models.......................61

17.2 Switch settings for Export 50Hz Models ...........................62

17.3 Single Service 50Hz Connection ......................................64

17.4 Dual Service 50Hz Connection.........................................64

17.5 Three Service 50Hz Connection.......................................65

18.0 Optional BLUEWAVE® Spa Stereo System..................66

18.1 Pairing the Remote and Stereo ........................................67

18.2 Audio Settings...................................................................67

18.3 Wireless Remote Control Functions .................................69

18.4 Electronic Device Connections and Functions .................70

18.5 Wireless Remote Battery Replacement Procedure ..........72

18.6 BLUEWAVE®SpaStereoSystemSpecications ............73

18.7 Stereo Cautions................................................................73

J-300

1.0 Important Spa Owner Information

Your Jacuzzi J-300 Collection spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for

efcient operation, an uncovered spa surface and wall ttings directly

exposed to sunlight and high temperatures for an extended period are

subject to permanent damage. Damage caused by exposing the spa

to this abuse is not covered under warranty. We recommend that you

always keep the spa full of water when it is exposed to direct sunlight

and that you keep the Jacuzzi premium insulating cover in place at

all times when the spa is not in use. Read and carefully follow the

requirements for your spa’s support base found in Section 4.0 titled,

“Choosing A Location” (page 9).

Jacuzzi constantly strives to offer the nest spas available,

therefore modications and enhancements may be made which

affect the specications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used in

accordance with the instructions, may cause harmful interference to radio

communications. However, there is no guarantee that interference will

not occur in a particular installation. If this equipment does cause harmful

interference to radio or television reception, which can be determined by

turning the equipment off and on, the user is encouraged to try to correct

the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver.

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

4. Consult the dealer or an experienced radio/TV technician for help.

Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

J-300

3.0 Important Safety Instructions for all Spa Owners

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

This spa was manufactured to meet the standards and specications

outlined in the “Virginia Graeme Baker Pool and Spa Safety Act” (VGB

Safety Act). When installing and using this spa, basic safety precautions

should always be followed, including:

1. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Extreme caution must be exercised to prevent unauthorized access

by children.

• To avoid accidents, ensure that children do not use this spa unless

supervised at all times. Adult supervision is a critical safety factor in

preventing children from drowning.

• Use the straps and clip tie downs to secure the spa cover when not

in use. This will help discourage unsupervised children from entering

the spa. Keep the spa cover secure in high-wind conditions.

• There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

2. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Keep hair, loose articles of clothing or hanging jewelry away from

suction ttings, rotating jets or other moving components to avoid

entrapment that could lead to drowning or severe injury.

• Never use the spa unless all suction guards, lter, lter lid, or

skimmer assembly are installed to prevent body and/or hair

entrapment.

• Never operate or use the spa if the lter, lter lid, or skimmer

assembly are broken or any part of the skimmer assembly is missing.

Please contact your dealer or nearest service center for service.

• The suction ttings and suction covers in this spa are sized to match

the specic water ow created by the pump(s). If it is necessary to

replace the suction ttings, suction covers or pump(s), be sure that

the ow rates are compatible and are in compliance with the VGB

Safety Act.

• Never replace a suction tting or suction cover with one rated less

than the ow rate marked on the original suction tting. Using

improper suction ttings or suction covers can create a body or hair

suction entrapment hazard that may lead to drowning or severe

injury.

3. !DANGER: RISK OF SEVERE INJURY FROM ELECTRIC

SHOCK OR DEATH FROM ELECTROCUTION!

• Install the spa at least 5 feet (1.5m), from all metal surfaces. As an

alternative, a spa may be installed within 5 feet of metal surfaces

if each metal surface is permanently connected (bonded) by a

minimum No. 8 AWG (8.4 mm²) solid copper conductor attached

to the wire connector on the grounding lug, inside the equipment

compartment on the equipment box.

J-300

• A grounding wire connector is provided on this unit to connect a

minimum No. 8 AWG (8.4 mm²) solid copper conductor between

this unit and any metal equipment, metal enclosures of electrical

equipment, metal water pipe, or conduit within 5 feet (1.5m) of the

unit.

• Never permit any electrical appliance, such as a light, telephone,

radio, television, etc. within 5 feet (1.5m) of a spa unless such

appliances are built-in by the manufacturer.

• Never bring any electrical appliances into or near the spa.

• Never operate any electrical appliances from inside the spa or when

you are wet.

• The electrical supply for this product must include a suitably rated

switch or circuit breaker to open all ungrounded supply conductors

to comply with section 422-20 of the National Electrical Code/USA,

ANSI/NFPA 70. The disconnecting means must be readily accessible

and visible to the spa occupant but installed at least 5 feet (1.5m),

from the spa.

• The electrical circuit supplied for the hot tub must include a suitable

ground fault circuit interrupter (GFCI) as required by NEC Article

680-42.

4. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Extreme caution must be exercised to prevent diving or jumping

into the spa or slipping and falling, which could result in

unconsciousness, drowning, or serious injury. Remember that wet

surfaces can be very slippery.

• Never stand, walk or sit on the top railing of the spa.

5. !WARNING: RISK OF HYPERTHERMIA (OVER-HEATING)

CAUSING SEVERE INJURY, BURNS, WELTS OR DEATH!

• Water temperature in excess of 104°F (40°C) may be injurious to

your health.

• Refer to Section 3.2 Hyperthermia for specic causes and symptoms

of this condition.

• The water in the spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are

considered safe for a healthy adult.

• Lower water temperatures are recommended for young children

(children are especially sensitive to hot water) and when spa use

may exceed 10 minutes.

• The Consumer Products Safety Commission/USA has stated that the

water temperature in a spa should not exceed 104°F (40°C).

• Always test the spa water temperature before entering the spa.

The user should measure the water temperature with an accurate

thermometer since the tolerance of water temperature-regulating

devices may vary as much as +/- 5°F (2°C).

J-300

6. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Since excessive water temperatures have a high potential for

causing fetal damage during the early months of pregnancy, if

pregnant or possibly pregnant, consult your physician before using a

spa.

• Pregnant or possibly pregnant women should limit spa water

temperatures to 100°F (38°C).

• Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult

a physician before using a spa.

• If you experience breathing difculties in association with using or

operating your spa, discontinue use and consult your physician.

• Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

• Persons suffering from any condition requiring medical treatment, the

elderly, or infants should consult with a physician before using a spa.

• The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

7. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Prolonged immersion in a spa may be injurious to your health.

• Observe a reasonable time limit when using the spa. Exposures

at higher temperatures can cause high body temperature (over-

heating). Symptoms may include dizziness, nausea, fainting,

drowsiness, and reduced awareness. These effects could possibly

result in drowning or serious injury.

• Never use a spa immediately following strenuous exercise. Enter

and exit the spa slowly. Wet surfaces can be slippery.

8. !WARNING: TO DECREASE RISK OF INFECTION OR DIS-

EASE!

• To reduce the risk of contracting a waterborne

illness (e.g. an infec-

tion, bacteria or virus) and/or respiratory ailments

, maintain water

chemistry within the parameters listed on the inside cover of this

manual and consult with a licensed engineer regarding proper venti-

lation if installed indoors or in an enclosed area.

• People with infectious diseases should not use a spa to avoid water

contamination, which could result in spreading infections to others.

• Always shower before and after using your spa. Maintain water

chemistry in accordance with manufacturer’s instructions. Failure to

do so may result in contracting a waterborne

illness (e.g. an infection,

bacteria or virus).

This manual suits for next models

Table of contents

Other Jacuzzi Hot Tub manuals

Jacuzzi

Jacuzzi Experience ALIMIA Parts list manual

Jacuzzi

Jacuzzi CAPELLA 60 User manual

Jacuzzi

Jacuzzi SALON SPA BATH SERIES User manual

Jacuzzi

Jacuzzi Select Series User manual

Jacuzzi

Jacuzzi Gallery R235-LH pump User manual

Jacuzzi

Jacuzzi Steam Enclosure User manual

Jacuzzi

Jacuzzi Experience SIENNA User manual

Jacuzzi

Jacuzzi J - 210 User manual

Jacuzzi

Jacuzzi U961000G User manual

Jacuzzi

Jacuzzi Milano H546 User manual

Jacuzzi

Jacuzzi BELLAVISTA 5.5 User manual

Jacuzzi

Jacuzzi Riva 5 User manual

Jacuzzi

Jacuzzi J - 480 User manual

Jacuzzi

Jacuzzi Unique Parts list manual

Jacuzzi

Jacuzzi LUNA PLUS User manual

Jacuzzi

Jacuzzi Duetta 6642 User manual

Jacuzzi

Jacuzzi nova 636 User manual

Jacuzzi

Jacuzzi J-400 Series User manual

Jacuzzi

Jacuzzi Riva 6 User manual

Jacuzzi

Jacuzzi ProTech LCD User manual

Jacuzzi

Jacuzzi SIGNA 5 User manual

Jacuzzi

Jacuzzi Fresco Y950 User manual

Jacuzzi

Jacuzzi Sabella EH90 User manual

Jacuzzi

Jacuzzi Signa 6 Pure Air II Bath EA90 User manual

Popular Hot Tub manuals by other brands

Bestway

Bestway Lay-Z-Spa 54189 manual

Morphy Richards

Morphy Richards Essentials PC4006 user manual

Softub

Softub PRESTIGE Owners Manual Water Treatment Guide

JNJ SPAS

JNJ SPAS SPA-318 Programming instructions

KIRAMI

KIRAMI Comfort Family Instructions for use

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) owner's manual

HoMedics

HoMedics FB-655HJ-GB manual

Everyday Hot Tubs

Everyday Hot Tubs 530 owner's manual

anko

anko SS-601A user manual

Pooli

Pooli OS030979B product manual

ab Solares Smart Spa operating manual

CalderaSpas

CalderaSpas CalderaSpas Utopia Series owner's manual

Outsunny

Outsunny 848-047V70 Assembly guide

Aquatic

Aquatic INFINITY 1 Specifications

Master Spas

Master Spas MP Force owner's manual

Asteria

Asteria 5630 owner's manual

Image

Image IMSB61610, IMSG61610 user manual

ViSAGE

ViSAGE FM-588D user manual