Felton USMC User manual

INSTALLATION GUIDE

MAXIMUM STATIC PRESSURE

Maximum static pressure 700kPa. If the water pressure exceeds or is likely to exceed 700kPa, an

approved pressure limiting valve must be tted.

MINIMUM STATIC PRESSURE

HOT COLD

Mains Pressure 150kPa 150kPa

Unequal Pressure 36kPa 150kPa

Equal Low Pressure 36kPa 36kPa

System Requirements

To ensure the optimum performance and customer satisfaction please adhere to the following:

•Flush out all pipework prior to installation.

• Maximum hot water temperature: 80°C. If the water temperature exceeds 80°C an approved tempering

valve must be fitted.

• Installation should comply with relevant local authority requirements.

• In accordance with good plumbing practice, filters should be fitted to supply lines to eliminate damage

to the ceramic cartridge from suspended solids.

Urban Sink Mixer

(USMC)

Ensure that the brown or yellow plastic regulator supplied is tted to the brass nipple and tted to the cold

supply hose. Remove the “aerator” tting from the mixer outlet and replace it with the ow straightener

provided.

Unequal Pressure

Ensure that any brown plastic regulators are removed from the brass nipples. Remove the “aerator” tting

from the mixer outlet and replace it with the ow straightener provided.

Equal Low Pressure

Mains Pressure

Ensure that the 2 pink plastic regulators supplied are tted to the brass nipples and tted to both supply hoses.

1 x sink mixer 2 x brass nipples 1 x brown or yellow regulator

1 x hot supply hose 1 x ow straightener 2 x pink regulators

1 x cold supply hose 1 x sink xings

Contents of Pack

280514VC

1. Cut a mounting hole 35mm in diameter. There must be a minimum 15mm width of at around the hole.

2. Fit benchtop rubber seal onto benchtop around 35mm hole.

3. Screw the two threaded studs into the mixer base.

4. Screw the “HOT” supply hose (with red marking) into mixer base hole ‘H’ (with red marking)

5. Screw the “COLD” supply hose (unmarked) into the last hole in the mixer base.

6. Lower the tted hoses, one hose at a time, into mounting hole.

7. From UNDERNEATH the bench, t ‘C’ rubber washer (if supplied), and metal washer around both hoses

and over the threaded stud.

8. Screw on the two M6 nuts and tighten with your ngers.

9. Check the mixer and the benchtop seal are correctly aligned on the bench. Secure with spanner.

10. Flush the supply pipes to remove debris.

11. Connect the water supply and check all the ttings are tight.

12. Turn on water supply and check for leaks.

Mixer Installation

Maximum bend for ﬂexible hose is 35mm radius. The nipples on the hoses must be con-

nected to ﬁttings which have machined end faces, not “sawn off” threaded tube.

Warranty, Maintenance & Care - USMC

For technical assistance please ring: 0800 743 358 or +64 9 528 0810

Felton Industries Limited - 8 Farmhouse Lane Glen Innes Auckland 1072 New Zealand www.felton.co.nz

Felton Industries Limited guarantees these mixers to be free from defects in materials and workmanship for a period of ten (10) years

from the date of purchase.

This warranty is effective for 10 years from the date of purchase and covers supply of replacement parts only and 5 years of plumbers

labour relating solely to repairing or replacing the mixer from the date of purchase, provided the product is installed by a registered

plumber. You must retain proof of purchase of the Mixer (such as an invoice or receipt) and proof of installation by a registered plumber

and provide these to Felton on request.

This warranty is for manufacturing defects only and does not cover any damage to product due to abuse, negligence or improper

installation. This warranty is given on the understanding that the product is installed by a registered plumber and operated according

to Felton’s installation guide and the Australian/New Zealand standard AS/NZS3500. This warranty is provided to persons who are a

“consumer” under the Consumer Guarantees Act 1993 only and for use in domestic/residential dwellings only (not for commercial use).

Please ll in the details below, attach your receipt to this installation guide and keep as your proof of purchase.

Purchased at:

Date of purchase:

Installed by:

At no stage should plated surfaces be cleaned with cleaning agents that contain a corrosive acid or a scour-

ing additive. Plated surfaces should be cleaned with liquid detergent or soap and water. Any damage caused

through the use of an unsuitable cleaner will not be covered by warranty.

This warranty is subject to any other rights or remedies that you may have under the Consumer Guarantees Act

1993 (or any other applicable legislation) and to Felton’s Terms of Trade.

Table of contents

Other Felton Plumbing Product manuals

Felton

Felton AXISS FUSION PLUS AXFSPCSMB User manual

Felton

Felton AERLUX TATE User manual

Felton

Felton CARE FCSMCA User manual

Felton

Felton TATE SMARTFLOW User manual

Felton

Felton TATE AERLUX User manual

Felton

Felton DESIGNER III User manual

Felton

Felton QUE Q2RSCC User manual

Felton

Felton QUE QRHCMCA User manual

Felton

Felton ODYSSEY II O2HSKC User manual

Felton

Felton mix U User manual

Felton

Felton HALO II H2RSCC User manual

Felton

Felton AXISS AXRHCMCA User manual

Felton

Felton AXISS Smartflow AXISS FD-SFCSMC User manual

Felton

Felton REFLEX FUSION PLUS RFSPCSMCL User manual

Felton

Felton REFLEX SINK MIXER RSMCA User manual

Felton

Felton DESIGNER III D3SHCGDA User manual

Felton

Felton QUE QRHCMSC User manual

Felton

Felton WILLO II W2RSCBN User manual

Felton

Felton AXISS FUSION PLUS AXFSPCSMC User manual

Felton

Felton RW User manual

Felton

Felton Axiss Smartview FD-SVCSMC User manual

Felton

Felton HALO HRHWMC User manual

Felton

Felton AXISS AXBMBA User manual

Felton

Felton Halo User manual

Popular Plumbing Product manuals by other brands

Weka

Weka 506.2020.00E ASSEMBLY, USER AND MAINTENANCE INSTRUCTIONS

Kohler

Kohler K-6228 Installation and care guide

UBERHAUS DESIGN

UBERHAUS DESIGN 75175017 Operator's manual

American Standard

American Standard DetectLink 6072121 manual

Uponor

Uponor Contec TS Mounting instructions

Pfister

Pfister Selia 49-SL Quick installation guide

Fortis

Fortis VITRINA 6068700 quick start guide

Fortis

Fortis MILANO 78211JS installation instructions

Kohler

Kohler K-12183 Homeowner's guide

Maxxus

Maxxus MX-M206-01 instruction manual

Moen

Moen 5922 Series installation instructions

Viega

Viega Prevista Pure 8512 Instructions for use

Kohler

Kohler Centerset K-15240 Homeowner's guide

Viega

Viega Prevista Dry 8522.33 Instructions for use

Sanela

Sanela Lema SLP 59RB Instructions for use

Elkay

Elkay EDF15AC Installation, care & use manual

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Instructions for use/assembly instructions

baliv

baliv WT-140 manual