Eaton NZM2-XMVR Manual

Electric current! Danger to life!

Only skilled or instructed persons may carry out the

following operations.

Lebensgefahr durch elektrischen Strom!

Nur Elektrofachkräfte und elektrotechnisch unterwiesene

Personen dürfen die im Folgenden beschriebenen Arbeiten

ausführen.

Tension électrique dangereuse !

Seules les personnes qualifiées et averties doivent

exécuter les travaux ci-après.

¡Corriente eléctrica! ¡Peligro de muerte!

El trabajo a continuación descrito debe ser realizado por

personas cualificadas y advertidas.

Tensione elettrica: Pericolo di morte!

Solo persone abilitate e qualificate possono eseguire le

operazioni di seguito riportate.

触电危险！

只允许专业人员和受过专业训练的人员进行

下列工作。

Электрический ток! Опасно для жизни!

Только специалисты или проинструктированные

лица могут выполнять следующие операции.

Emergency On Call Service: Local representative (http://www.eaton.com/moeller/aftersales) or +49 (0) 180 5 223822 (de, en) 1/4

Instruction Leaflet

Montageanweisung

Notice d’installation

Instrucciones de montaje

Istruzioni per il montaggio

安装说明

Инструкция по монтажу

09/12 IL01219035Z

(AWA1230-2350)

NZM2-XMVR

NZM2-XMVRL

NZM2/3-XMVR

NZM2/3-XMVRL

NZM2-…

NZM2/3-…

NZM2-XMVR(L), NZM2/3-XMVR(L)

NZM2-… NZM2/3-…

Z 2

charged OFF

Z 2

charged OFF

Z 2

0.8 Nm

(7.08 lb-in)

charged OFF

Z 2

1 Nm

(8.85 lb-in)

Z 2

1 Nm

(8.85 lb-in)

charged OFF

2/4 Emergency On Call Service: Local representative (http://www.eaton.com/moeller/aftersales) or +49 (0) 180 5 223822 (de, en)

09/12 IL01219035Z

OFF

4 x

Z 2

0.8 Nm

(7.08 lb-in)

NZM2-XMVRL

NZM2/3-XMVRL

NZM2-XMVRL

NZM2/3-XMVRL

NZM2/N2

NZM3/N3

R f60 mm

(R f2.36”)

NZM2-XMVR(L)

NZM2/3-XMVR(L)

NZM2-XMVR(L)

NZM2/3-XMVR(L)

NZM2/N2

NZM3/N3

NZM2/N2

R f60 mm

(R f2.36”)

NZM2/3-XMVR(L)

NZM2-XMVR(L)

charged OFF

discharged ON

NZM2-XMVR(L)

NZM2/3-XMVR(L) L

NZM2-XMVR(L)

NZM2/3-XMVR(L)

8 mm

1.5 Nm

(13.28 lb-in)

OFF

charged

discharged

OFF

NZM2/3-XMVR(L)

NZM

2-XMVR(L)

NZM2-XMVR(L)

NZM2/3-XMVR(L)

NZM2-XMVR(L)

NZM2/3-XMVR(L)

charged OFF

NZM2-XMVR(L)

NZM2/3-XMVR(L)

NZM2-XMVR(L)

NZM2/3-XMVR(L)

8 mm

1.5 Nm

(13.28 lb-in)

Emergency On Call Service: Local representative (http://www.eaton.com/moeller/aftersales) or +49 (0) 180 5 223822 (de, en) 3/4

09/12 IL01219035Z

Interlock is active if the switch is in tripped position (display OFF and discharged) and

the push to trip button is in the "operated" position.

Possible causes:

– Error in the electronic interlock

– Electrical or manual switch-on attempt at locked switch

– Switch was in tripping position (OFF), other switch was switched on

Steht der Schalter in Ausgelöst-Stellung (Display-Anzeige OFF und discharged) und der

push to trip-Taster in „Betätigt“-Stellung, so ist der Verriegelungsfall eingetreten.

Mögliche Ursachen:

– Fehler in der elektrischen Verriegelung

– Einschaltversuch elektrisch oder manuell am verriegelten Schalter

– Schalter war in Ausgelöst-Stellung (OFF), anderer Schalter wurde eingeschaltet

Le verrouillage est activé lorsque le disjoncteur se trouve en position « déclenché »

(indications sur l’afficheur : OFF et discharged) et que le bouton « push to trip » est en

position « activé »

Causes possibles :

– Défaut au niveau du verrouillage électrique

– Tentative d’enclenchement électrique ou manuelle au niveau du disjoncteur

verrouillé

– Le disjoncteur était en position « déclenché » (OFF) ; l’autre disjoncteur a été

enclenché

El enclavamiento se produce si el interruptor está en posición de disparo (indicador del

display OFF y discharged) y la tecla push to trip en posición “accionado”.

Posibles causas:

– Error en el enclavamiento eléctrico

– Intento de conexión eléctrica o manual con el interruptor bloqueado

– El interruptor estaba en posición de disparo (OFF), se conectó otro interruptor

L’interblocco ? attivo se l’interruttore si trova in posizione di sgancio

(display OFF e discharged) e se l’interruttore push to trip ? “attivato”.

Possibili cause:

– Errore nell’interblocco elettrico

– L’interruttore era in posizione di sgancio (OFF), l’altro interruttore era attivato

– Tentativo di azionamento elettrico o manuale sull’interruttore bloccato

–

Разомкнутое положение защитного автомата [на дисплее «OFF» («Выкл.»)

и «discharged» («нагрузка снята»)] и рабочее (нажатое) положение

размыкающей кнопки свидетельствуют о происшедшей блокировке.

Возможные причины:

– Неисправна защитная электроблокировка

– Заблокированный выключатель попытались включить электрически или

вручную

–Когда один автомат находился в разомкнутом состоянии, произошло

включение второго

OFF

discharged

TEST

NZM2-XR…, ≈ 15 x NZM2-XR…, ≈ 15 x

NZM3-XR…, ≈ 20 x

5TRIP

OFF

discharged

charged OFF

discharged

charged OFF

OFF

4/4 Emergency On Call Service: Local representative (http://www.eaton.com/moeller/aftersales) or +49 (0) 180 5 223822 (de, en)

09/12 IL01219035Z

Eaton Industries GmbH, Hein-Moeller-Straße 7-11, 53115 Bonn, Germany

09/12 IL01219035Z 12289662/DE08 Doku/DM

Printed in Germany (10/12)

Note – Hinweis – Remarque – Nota – Nota – – Примечание

Check the function of the mutual mechanical switch interlock after approx. 5000 operations and adjust Bowden cables if necessary.

Korrekte Funktion der gegenseitigen mechanischen Schalterverriegelung nach ca. 5000 Schaltungen überprüfen und Bowdenzüge gegebenenfalls nachjustieren.

Au bout de 5000 manœuvres, vérifier le fonctionnement correct du dispositif d’interverrouillage mécanique des disjoncteurs et ajuster le cas échéant les câbles sous gaine.

Comprobar la correcta función del enclavamiento mecánico del interruptor mutuo después de aprox. 5000 maniobras y ajustar de nuevo los cables Bowden en caso necesario.

Controllare il corretto funzionamento del blocco interruttore meccanico reciproco dopo ca. 5000 commutazioni e, all’occorrenza, regolare i tiranti Bowden.

Проверьте работу переключателя механической блокировки после 5000 рабочих циклов и при необходимости настройте тросы Боудена.

XMVR

XMVRL

NZM…XMVR

Mounting side-by-side – Maximum switch distance X...

Montage nebeneinander – Maximaler Schalterabstand X...

Montage côte-?-côte – Distance maximale entre disjoncteurs : X...

Montaje lateral – Distancia máxima de los interruptores X...

Montaggio affiancato – Massima distanza degli interruttori X...

–

Монтаж в горизонтальной плоскости – Макс. расстояние Х между защитными автоматами

NZM…XMVRL

Mounting in adjacent control panel sections – Maximum switch distance X...

Montage in benachbarten Schaltschrankfeldern – Maximaler Schalterabstand X...

Montage dans des colonnes d’armoire adjacentes – Distance maximale entre disjoncteurs : X...

Montaje en los paneles colindantes de los armarios de distribución – Distancia máxima de los interruptores X...

Montaggio in campi del quadro attigui – Massima distanza degli interruttori X...

–

Монтаж на смежных панелях приборного шкафа, – Макс. расстояние Х между защитными

автоматами

NZM...XMVRL

Mounting above each other – Maximum switch distance Y...

Montage übereinander – Maximaler Schalterabstand Y...

Montage superposé (l’un au-dessus de l’autre) – Distance maximale entre disjoncteurs Y...

Montaje en la parte superior – Distancia máxima de los interruptores Y...

Montaggio sovrapposto – Massima distanza degli interruttori Y...

–

Монтаж в вертикальной плоскости – Макс. расстояние Y между защитными автоматами

x3P

x4P

NZM2/N2

NZM3/N3

NZM-XMVR B

NZM2

X3p X4p

NZM3

X3p X4p

NZM4

X3p X4p

ANZM2/ 3p/4p 130 mm

(5.12“)

95 mm

(3.74“)

95 mm

(3.74“)

50 mm

(1.97“)

––

NZM3/ 3p/4p – – 135 mm

(5.31“)

90 mm

(3.54“)

155 mm

(6.10“)

85 mm

(3.35“)

NZM4/ 3p/4p – – – – 120 mm

(4.72“)

50 mm

(1.97“)

NZM-XMVRL B

NZM2

X3p X4p

NZM3

X3p X4p

NZM4

X3p X4p

ANZM2/ 3p/4p 350 mm

(13.78“)

315 mm

(12.4“)

420 mm

(16.54“)

385 mm

(15.16“)

––

NZM3/ 3p/4p – – 400 mm

(15.75“)

365 mm

(14.37“)

460 mm

(18.11“)

390 mm

(15.35“)

NZM4/ 3p/4p – – – – 420 mm

(16.54“)

350 mm

(13.78“)

NZM-XMVRL B

NZM2

NZM3

NZM4

ANZM2/ 3p/4p 220 mm

(8.66“)

255 mm

(10.04“)

–

NZM3/ 3p/4p – 220 mm

(8.66“)

230 mm

(9.05“)

NZM4/ 3p/4p – – 230 mm

(9.05“)

This manual suits for next models

Other Eaton Control Unit manuals

Eaton

Eaton Moeller SmartWire-Darwin EU5C-SWD-DP Manual

Eaton

Eaton Crouse-hinds series User manual

Eaton

Eaton 11 Series Installation manual

Eaton

Eaton KES 310+ Manual

Eaton

Eaton RF96APM User manual

Eaton

Eaton Crouse-hinds series Setup guide

Eaton

Eaton EP Control User manual

Eaton

Eaton eNMC2 User manual

Eaton

Eaton Scantronic i-on10 User manual

Eaton

Eaton Cutler-Hammer Digitrip RMS 510 Manual

Eaton

Eaton MEMSHIELD 4 User manual

Eaton

Eaton Vickers DG3V-8 Series User manual

Eaton

Eaton Crouse-hinds series User manual

Eaton

Eaton CMA User manual

Eaton

Eaton ELC-COPBDP User manual

Eaton

Eaton Vickers SF4-140-20-002-10 User manual

Eaton

Eaton DXE-EXT-SET Manual

Eaton

Eaton MN024002EN User manual

Eaton

Eaton Power Xpert PXGMS Programming manual

Eaton

Eaton DILM12-XMSM Manual

Eaton

Eaton SM65 User manual

Eaton

Eaton Crouse-hinds series User manual

Eaton

Eaton 9395 SSBM User manual

Eaton

Eaton Power XL SmartWire-DT DX-NET-SWD3 Manual

Popular Control Unit manuals by other brands

Festo

Festo Compact Performance CP-FB6-E Brief description

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Quick installation guide

JS Automation

JS Automation MPC3034A user manual

JAUDT

JAUDT SW GII 6406 Series Translation of the original operating instructions

Spektrum

Spektrum Air Module System manual

BOC Edwards

BOC Edwards Q Series instruction manual

KHADAS

KHADAS BT Magic quick start

Etherma

Etherma eNEXHO-IL Assembly and operating instructions

PMFoundations

PMFoundations Attenuverter Assembly guide

GEA

GEA VARIVENT Operating instruction

Walther Systemtechnik

Walther Systemtechnik VMS-05 Assembly instructions

Altronix

Altronix LINQ8PD Installation and programming manual

WAGO

WAGO 750-407/040-000 manual

Sony

Sony CCU-590 Operation manual

Graco

Graco 25D614 instructions

Task Force Tips

Task Force Tips YE-RF-900 Instructions for installation, safe operation and maintenance

Shini

Shini SPV-U Series manual

Flyron

Flyron FN-BC04 user manual