Dimplex DFO2307 Quick start guide

PARTS AND SERVICE MANUAL

FOR

DIMPLEX 23” OUTDOOR

ELECTRIC FIREPLACE

Model DFO2307

TABLE OF CONTENTS

OPERATION PAGE 2

PARTS DRAWING PAGE 3

PARTS LIST PAGE 4

WIRING DIAGRAM PAGE 5

FRONT GLASS REMOVAL PAGE 6

UPPER LIGHT REPLACEMENT PAGE 7

LOWER LIGHT REPLACEMENT PAGE 8

MAIN ON/OFF REPLACEMENT PAGE 9

FLAME ROD AND MOTOR REPLACEMENT PAGE 10

CIRCUIT BOARD REPLACEMENT PAGE 11

DFO2307

OPERATION

ELECTRIC FIREPLACE MANUAL CONTROL

The manual controls for the firebox are located in the upper right hand corner behind the

access panel. To access the controls, open the upper access panel by pulling forward

and down.

To locate controls refer to Figure 3.

A. Main On/Off Switch

The ON/OFF SWITCH supplies power to the flames and over head lights.

NOTE: This unit does not have a heat option.

Figure 3

Main

On/Off

Switch

DFO2307

REPLACEMENT PARTS

FIREBOX, 23” – Dimplex

CATALOGUE NO. DFO2307

PART NO. 6903100100

REPLACEMENT PART

1. MOTOR, ASSEMBLY 3000240200

2. LED LIGHT, 1 WATT 3700060100

3. ON/OFF SWITCH 2800150100

4. CIRCUIT BOARD 3000520100

5. MIRROR 5900750100

6. GLASS FRONT 5900710100

7. LED LIGHT, BOTTOM 3700060200

8. TRANSFORMER 2100200100

9. FLAME ROD 5900780100

10.BUSHING 8500000400

11. LOGSET 0478270100

WIRING DIAGRAM

CONNECTOR, FEMALE

(HARNESS INCLUDED)

THIS END TO BE CONNECTED TO

TRANSFORMER. REFER TO TABLE

FOR P/N.

"A" TERMINAL

LIGHT WIRE HARNESS

MAIN PCB BOARD

(BACK SIDE VIEW)

SQUARE

SOLDER PAD

INCLUDED IN

LIGHT WIRE HARNESS

"A" TERMINAL

FLICKER MOTOR

(HARNESS INCLUDED)

1 WATT LED

TOP LIGHT

YELLOW WIRE OF

CABLE TO LINE UP

WITH SQUARE

SOLDER PAD OF

CONNECTOR ON

BOARD.

FLAME LIGHT

1 WATT LED

MAIN ON/OFF

SWITCH

CONNECTOR, WIRE

TWISTER

"B" TERMINAL

TYP.

FLAME LIGHT

1 WATT LED

FLAME LIGHT

3 WATT LED

DFO2307

Disconnect power before attempting any maintenance or cleaning to reduce the risk of

electric shock or damage to persons.

FRONT GLASS REMOVAL

1. Remove top from mantel.

2. Lift firebox out of mantel.

3. Lay firebox on it’s back.

4. Remove screws from the left and right side of the front glass lower support.

5. Insert the tip of a slot screwdriver between the glass edge on either the left or right

side trim.

6. Using the screwdriver as a lever, apply pressure in a downward motion forcing the

edge of the glass up.

DFO2307

Disconnect power before attempting any maintenance or cleaning to reduce the risk of

electric shock or damage to persons.

It is a good idea to replace all of the lights at one time if they are close to the end of their

rated life. Group replacement will reduce the number of times you need to open the unit

to replace the lights.

UPPER LIGHT REPLACEMENT

1. Remove the front glass as shown on page 6 of this manual.

2. Remove the top trim piece by removing the 3 retaining screws.

3. Remove the 10 retaining screws and lift the top off of the unit.

4. Unplug the light wiring harness from the circuit board.

5. Remove the 3 screws and remove the light from the unit.

6. Reassemble in the reverse order.

LIGHT BULB REQUIREMENTS

Quantity of 2 clear chandelier or candelabra bulbs with an E-12 (small) socket base,

60 watt rating.

DFO2307

Disconnect power before attempting any maintenance or cleaning to reduce the risk of

electric shock or damage to persons.

Lights need to be replaced when you notice a dark section of the flame. There are

three lights under the log set which generate the flames and embers located under the

emberbed.

It is a good idea to replace all of the lights at one time if they are close to the end of their

rated life. Group replacement will reduce the number of times you need to open the unit

to replace the lights.

LOWER LIGHT REPLACEMENT

1. Remove the front glass as shown on page 6 of this manual.

2. Remove the top trim piece by removing the 3 retaining screws.

3. Remove the 10 retaining screws and lift the top off of the unit.

4. Unplug the lower light wiring harness from the circuit board.

5. Remove the flame rod.

6. Remove the 3 screws holding each light and remove the light assembly from the

unit.

7. Reassemble in the reverse order.

DFO2307

Disconnect power before attempting any maintenance or cleaning to reduce the risk of

electric shock or damage to persons.

MAIN ON/OFF SWITCH REPLACEMENT

1. Remove the front glass as shown on page 6 of this manual.

2. Remove the top trim piece by removing the 3 retaining screws.

3. Remove the 10 retaining screws and lift the top off of the unit.

4. Locate the main on/off switch mounted on the top panel and disconnect the wiring

clips and connections noting their original locations.

5. Depress the retainer clips on the rear of the switch and push the switch out of the

rear of the cover.

6. Reassemble in the reverse order.

Other manuals for DFO2307

Table of contents

Other Dimplex Indoor Fireplace manuals

Dimplex

Dimplex THWG XLF50 User manual

Dimplex

Dimplex VF5452L User manual

Dimplex

Dimplex DNV20AB User manual

Dimplex

Dimplex DF2426 User manual

Dimplex

Dimplex DF3033-EU User manual

Dimplex

Dimplex IN-STUD V1525BT User manual

Dimplex

Dimplex Pro Series Technical manual

Dimplex

Dimplex Optiflame MiniMozart FGA15E Instruction Manual

Dimplex

Dimplex Pro Series User manual

Dimplex

Dimplex DLW1500B12 User manual

Dimplex

Dimplex BF8000ST User manual

Dimplex

Dimplex BFSL33 User manual

Dimplex

Dimplex Burgate BRG20 User manual

Dimplex

Dimplex XLF60 User manual

Dimplex

Dimplex Mini Mozart User manual

Dimplex

Dimplex SILVERTON User manual

Dimplex

Dimplex BF42ST-230 Operation manual

Dimplex

Dimplex DFOP25 User manual

Dimplex

Dimplex DF2500L User manual

Dimplex

Dimplex Siena Fire SNA20 User manual

Dimplex

Dimplex TFA36E User manual

Dimplex

Dimplex JUNEAU User manual

Dimplex

Dimplex Conner CNR15-AU User manual

Dimplex

Dimplex EF2570G-IR User manual

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual