Danby DAC6020 User manual

nby °

USEANDCARE

MANUAL

MANUEL

D'UTILISATION

Model,M0dSle

DAC7003

DAC6020

ReadendFollowAI!SafetyRutes

andOperatingInstructionsBefore

Rrs!Useof'fhTaProduct,

PRI_CAUTION:

Vaulirezlirantlentlvament

leecone!onesdes_cud[6etlee

Insltucgonsd'uttffsagont_vant

I'utttlsatlontnillalade

caproduft,

•i.............

III I IIIII II II I II I

I I II II....

I IIIII "!

i .... _i ,i'

"1 III IIIIIII........................ IIIIIIII II !

I IIII llllllll llll i i

IIII I/ .......

II II I II I I

IIIII I II IILU[_i'Ii ilill

II I IIII _111 I I

,H,=II I IIIIIIIIIIII

I II iii I I IJ ....

IIII I I "

:iF a

.......IHI

Danby"

Room Air Conditioner

Table of contents ....................... 1

DallI_ _

Climatiseur de piece

Tabte of contents ....................... 14

DanbyProductsLimited,Guelph,OnladoCanadaNIH 6Z9

DanbyProductsInc.,Findlay,OhioUSA45840

Page

Introduction ........................ :........................................ 2

Unit Specifications .................. '............................................... 2

Electrical Specifications ...................................................... 3

Energy-Saving Tip€ ................................................................ 4

Window Instaltalior_ ................................................................... 4

Operating Instructions .............................................................. _ 0

Care and Maintenance ....................................................... 11

Trouble Shooting Guide ...................................................... 12

Warranty .................................................................. 13

Air _nlet

Exterior

Air i'ntBt

Fnterror

AirOul!et

Thank _/oufor choosinga Danby Room Air Condilioner to cool your home. This Use and Care Manual

provides information necessary for the proper care and maintenance of your new Room Air Conditioner, If

propedy maintained, your air conditioner will give you many years of trouble free operation. To avoid

installation difficufties,read these Instructionscompletely before Jnstallingloperating your unit,

NOTE: This unit Is NOT designed for through-the-wall Installation,,

For easy reference,you maywanttoattacha copyofyoursalesreceiptto this page, Note following

informationprovided(on themanufacturer'snameplate located on therightsideof the unit abovethepower

cord),,Thisinformationwill be neededwhen youcon!act a CustomerService Representative,

Model Number:

Serial Number:

Date o[ Purchase:

Dealer's Name and Address:

Refer to the trouble shooting section of this Use end Care Manual if the unit Is not operating correctly,

If these suggestions do not solve the problem, contact an authorized serv[ce representative or

call Danby TOLL FREE: 11-800-26- i1_'

Keepthose instructionsfor future reference.

This symbol denotes a caution or warntng

Do notleave a room air conditionerunattended in

aspace where people or animals who cannot

react to o failed unl_:are located° A failed unit can

cause extreme overheating or death in such an

enclosed, unattended space.

Model No.

Unit Specificaficatlons

Voltage

Coot!rigCapacity(atulh)

InputWattage

E_ner_lyEfi!c!encyRating (EER}

FanlCoolta_Speeds

€oottrl9Area Coverage(Sq:rL)

No}soLevel(dB)

Unit Dimensions Width

...................p_p!h

Height

Window Kit Dimensions Maximum Width _

Minimum Width

Minimum Height

Shipping Weight

DAC7003 DAC8O2O

i15VI6OHz '115Vt60Hz

7,000 6,000 '

710 610

9,8 9.8

3/3 3t3

......250 200

47 47

't7.75" t7.75"

22,5" 22.5 "°

13°5" 13,5"

37"

t5.S"

97 Ib

37"

24.5,-__

15.5"

97 Ib

NOTE; Specil'icationsare subject tochange without notice for fucthorimprovsmenL

All wiring must comply with local and national

electrical codes and must be installed by a

qualified elecViclan. Ifyou have any questions

regarding the following instructions,contact a

qualified electrician.

2_ Check available power supply and resolve any

wiring problems BEFORE installing and

operating this unit,

3,, This 115V air cond{fioner uses 12.0 or less

nameplate amps and may be used in any

properly wired, general purpose household

receplacle See Table 1 for specifications for

individual branch circuit.

4, For your safely and protection, this unitis

grounded through the power cord plug when

plugged into into amatching wall outleL If

you are not sure whether your wall oulret _s

properly grounded, please consult a

qualified electrlclan.

5. The walt outlet (3-pin) must match the plug (3_

pin) on the service cord supplied with the unit.

DO NOT use plug adapters, See "Table2for

receptacle and fuse information°if [t fs necessary

to use an extension cord to connect your air

conditioner, use an approved "air condilfoner"

extension cord only. (available at most local

hardware stores)

6. The rating plate on the unit contains electrical

and other technical data. The rating plate

is located on the right side of the unit, above the

power cord,

Table 1: Suggested Individual Branch Clrcull

Nameplate Ampa AWG Wire Size"

5.0 to 12 14

AWG- American Wire Gage

"Based on copper wire at 60 "C temperatore rating..

Table 2: Receptacle and FuseTypes

Rated Vo_ls 125

Amps 15

Wall Oultel

Fuse Size 15

Time Delay Fuse Plug Type

(or circuit breake0

Your RoomAirConditionerIs designedto be

highly efffiolenttn erte_gysavings, Followthese

recommendationsforgreater efficiency,,

t. Select thermostatsettingthatsuiteyour

comfortneedsand leavethermostatatthat

chosensetting.

2. Thefilterlsvery efficientIn removingairborne

particles.Keep airfillerclean. Normally,filter

shouldbe cieanedevery2 weeks. More

frequentcteantngmay be necessarydepending

onoutdoorend Indoorair qualty.

3. Usedrapes,curtains,or shadesto keep

directsunlight fromheatingroom,butDONOT

obstructtheairconditioner.Allow airto cfrculate

aroundtheunitwithoutobstruction.

4. Startyourair conditionerbeforeoutdoorair

becomeshotand uncomforlsble. Thisavoidsan

Inffialperiodofdiscomfortwhileunitis cooing

off theroom.

5. Whenoutdoortemperaturesarecooleheugh,

useHIGH, MED,or LOW FANonly(depending

on yourmodel)oThis circulatesindoor air,

providingsome coolingcomfort,and utilizes

teseelectdcltythanwhenoperatingona

coolingsetting.

_"[[mt_E'_,,. ,,.- ,; ,, .l_;[",Lr',]_ -

_F.t¢JRF_ E_

_1_ Toavoidthepossiblly of personalinjury,disconnect powerto theUnit

beforeinstallingorservicing°

Tools Needed for Window Installation

Screw Drivers: Both Phillpsand flat head

Power Drill: 1/8inchdiameter drill bit

Pencil

Measuring'rape

Scissors

Carpenters Level

Adjustable Wrench

(_) Flat Washers (8) _;_huts r Brackets (2)

3'4"Screws(8)

(_t 1/4" Seraws(18) Side Curtain,RH (1)

(_ Top Channel(1) Side Cudain LH (1)

Bottom Channel(_)

LockWashers(4)

1_1/2_x1/4" Bolts (4)

'_) t/4" Nuts (4) FoamS_tal(4)

"_ 90 _,Alglt

Brackets(2) Leveling Legs (2)

YourRoomAir ConditionerIs designedfor easy

installationin a singleor double-hungwlndowoNOTE:

Thisunitle NOTdesignedforvertical(slidertype)

windowsand/orthrough-the-wal applications.NOTE:

Savetheshippingcarton and packingmaterialsfor

futurestorage ortransportoftheunit_Removefrom

carton,the plastic bag containingthe tnstalation

hardwarekit necessaryfortheinstataton ofyour air

conditioner.Pleasecheck thecontents o_'hardware

kil egoistthe correspondingmodel checklist,priorto

instellalono(the uniL

See Fi'g.1

Because the compressor is located on the

controls side of the unit (right side), this side will

be heavier and more awkward to manipulate,

Inadequate support on control side of the unit

can result In personal injury and damage to your

unit and properl_ Therefore, it is recommended

to have someone assist you during the

installation of this unit.

Your unit Is designed to evaporate condensation

under normai conditions. However, under

extreme humidity conditions, excess condensation

may cause basepan to ovedlow to the outside°

The Unit shouId be installed where condensation

run-elf cannot dr_pon pedestrians or neighboring

properties,

A drain tube connection (excluding hose) is provided

to redirect condensalion ovediowo See Fig. 25,

Select the Best Location

A. This room air conditioner is designed to fit easily

into a single or double hung window. However,

since window designs vary, it may be necessary

to make soma modifications for safe, proper

installation,

B. Make sure window and frame are structurally

sound and free from dry and rotted wood,

C. For maximum efficiency, Install the alr conditioner

on a side of a house or building which favors

more shade than sunlight. If the unit is in direct

sunlight, ff Is advisable to provide an awning over

the unit,

D. Provide sufficient clearance around the cabinet to

allow for ampte air circulation through the unit.

See Fig,2. The rear of the unitshould be

outdoors and not in a garage nor inside a

building. Keep unil as far away as possible from

obstacleslobstructtons and al least 30" above the

floor or ground. Curtains and olher objects within

aroom should be prevented from blockingthe air

flow.

E, Be certain the proper electrical outletis wtlhln

reach of the tnstailafion. Use only a single

outlel circuit rated at 15 amps. Ail wiring should

be in accordance wilh local and national

electrical codes.

EDO NOT USE "REGULAR" EXT,_NSION CORDS

WITH THIS UNIT If it is necessary to use an

extension cord to connect your air conditioner,

use an approved "air conditioner" extension cord

only. (available at most local hardware stores)

G. DO NOT instatf unitwhere leakage ofcombustible

gas issuspected. Your air conditioner may fail to

operate in air containing oils (including machine

dis), sulfide gas, near hot springs, etc...

2O"

MIn,

30"

Side Mtn

ob_truclloa

Ground._

Fig,2

1. Preparation to Remove the

Air Cond[tloner Slide-Out Chassis

•Positionthe air conditionerIn the normal (upright)

position,,

• Remove the air fitter by grasping the filler handte

(on front grill) and sliding it to the right.

•Remove the phillips screw (behind filter) securing

the grill frontto the chass[s_(Fig.,2)

•Remove the phiilipsscrews located on the (lower

left/right) edge of front grill, (Fig,l)

To remove the frontgrill, grasp the lower front

corner of 'thegrill, pulling (gently) oulward and

upward. (Fig3)

Repeat this step on the 3 remaining corners,

•Remove the two IJhtllIpsscrews (lower left/rlght

side of cabine't)seeudng the slide-out-chassis

to the cabtneL(Fig,5)

NOTE:These screws must be reinstalled

upon completion of the window installation.

(to secure slide-out-chassis) •

. Grasp the pull handle at the front of the

slide-out-chassis and carefully slide the air

conditioner out of the cabinet. (Fig.4)

Please seek assistance for this procedure,

Fig, 1

GRItJLFRONT 8 CRE'W

Fig. 2 Fig. 3

Fig,4

Fig. S

5. Completing the Inslsllatlon for All Models

•Carefully slide the air conditioner back into

the cabinet, (in window)

(please seek assistance for this procedure)

Reinstall (slide-out-chassis) secudly screws

removed earlier on the (lower left]right) side of

Ihe cabinet, Fig. 7

• Expand Ihe shutter frames (fully) on each side

and secure the top of the frames to Ihe window

sash using one 314" screw & flat washer on

each side. Fig. 23

•Install shutter clamp on each s]de of the Oower)

shutler and secure to window sill using one

3/4" screw & flat washer on each side. Figo23

58,

Reinstalling Front Panel Grill:

Positionthe front panel assembly on the

cabinet starting at the top. The front panel lock

labs must be inserted inlo the retaining slots in

the cabinet.

Repeat this procedure on al[ sides, making sure

the fresh air ventilation lever arm and power

cord are properly installed back to their original

positlon_

Secure the front gdfl tothe cabinet using the

phillips screws removed eartier_ Flg'xo1 & 2

install the air filtar_

Cut the second foam seal Is fit the opening

between the lop of the inside and outside

window. (Fig..24,)

Some Installations may require additional

sealing around the window and air conditioner..

Check for any air teaks and seal where

necessary.

LJndervery humid conditions, water removai

may be excessive enough to overflow from Ihe

rear of the unit or increase noise levels of the

air conditioner° If this occurs,consider attaching

astandard drain (garden) hose (not

included) to the drain plug at the rear of the

unit, allowing condensation to run off

conveniently (Fig° 254)

che_l_

Fig,7

Clamp

Fig. 23

2nd Fo_n

Seal

Fig, 24

, iii

DrainHose

(nbt Included) Fig. 25

Other manuals for DAC6020

This manual suits for next models

Table of contents

Languages:

Other Danby Air Conditioner manuals

Danby

Danby DPA140B1WDB-6 User manual

Danby

Danby DPAC11012BL Assembly instructions

Danby

Danby DPA100B2WDB Assembly instructions

Danby

Danby DAC080BGUWDB User manual

Danby

Danby DPAC5011 Assembly instructions

Danby

Danby DAS120BAHWDB User manual

Danby

Danby Simplicity SAC5000EE User manual

Danby

Danby Designer DPAC8020 User manual

Danby

Danby DPA100B9IWDB-RF User manual

Danby

Danby Premiere DPAC 5009 Assembly instructions

Danby

Danby DPA140E1BDB-6 User manual

Danby

Danby DTAC100B1WDB User manual

Danby

Danby DDR586R User manual

Danby

Danby DPAC7008 User manual

Danby

Danby DAC060BGUWDB User manual

Danby

Danby DPA100E1BDB Assembly instructions

Danby

Danby Premiere DPAC13012H Assembly instructions

Danby

Danby DPA080C2SDB Assembly instructions

Danby

Danby SAC5299 User manual

Danby

Danby DTAC100B1WDB-RF User manual

Danby

Danby DPA120B8WDB-RF User manual

Danby

Danby DAC145EB6WDB-6 User manual

Danby

Danby DAC150EUB2GDB Assembly instructions

Danby

Danby DPA072B8WDB-6 User manual

Popular Air Conditioner manuals by other brands

Spheros

Spheros CC 355 instructions

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE owner's manual

Panasonic

Panasonic CS-E12HKEW operating instructions

nedis

nedis ACMB1WT7 quick start guide

Samsung

Samsung AR KV Series User & installation manual

Daikin

Daikin FCFV50A Operation manual

Fujitsu

Fujitsu Inverter ASBA30JFC operating manual

Toshiba

Toshiba RAS-M10SMUV-E installation manual

Daikin

Daikin FXLQ20MAVE Operation manual

Hitachi

Hitachi RAS-E24CAK instruction manual

CIAT

CIAT Magister 2 Series Installation, Operation, Commissioning, Maintenance

Bestron

Bestron AAC6000 instruction manual

Hisense

Hisense 7K Use and Installation Instructions

Frigidaire

Frigidaire FFRE0533S1E0 Use & care guide

Samsung

Samsung AS09HM3N user manual

Frigidaire

Frigidaire CRA073PU11 use & care

Soleus Air

Soleus Air GB-PAC-08E4 operating instructions

McQuay

McQuay MCK020A Technical manual