Char-Griller 5050 User manual

OWNER’S MANUAL

Duo

model #5050

LP Gas & Charcoal Grill

Duo

model

#5050

Features:

•Porcelain Coated Cast Iron

•Stainless Steel Thermometers

•

Chrome Plated Warming Racks

Gas Grill Features:

•40,800 BTU

•Stainless Steel Tube Burners

•

Chrome

Plated

Warming

Racks

•12,000 BTU Side Burner

•Cast Brass Side Burner

•Electronic Igniters WARNING:

er installation, ad

ustment, alteration, service or

Ch l G ill F t

pp j

maintenance could cause injury or property damage

Read the installation, operation and maintenance

instructions thoroughly before assembling or servicing

this equipment.

Failure to follow these instructions could result in fire or

explosion that could cause property damage, personal

injury or death.

arcoa

ill

ures:

•Start charcoal with gas burner

•Adjustable Height Charcoal Grate

•Side Fire Box O

tional for Texas

DANGER:

DO NOT use gas grill for indoor cooking or heating.

TOXIC fumes can accumulate and cause asphyxiation.

Do not use in or on boats or recreational vehicles.

PROP 65 WARNING:

Chemicals known to the state of California to cause

cancer birth defects or other reproductive harm are

SAVE THESE INSTRUCTIONS FOR FUTURE

Style Smoking

!WARNING

For Outdoor Use Only (outside any enclosure)

cancer

birth

defects

other

reproductive

harm

are

created by the combustion of propane.

REFERENCE. IF YOU ARE ASSEMBLING THIS UNIT

FOR SOMEONE ELSE, GIVE THIS MANUAL TO HIM

OR HER TO SAVE FOR FUTURE REFERENCE.

FOR CUSTOMER SERVICE, CALL 912-638-4724 A propane gas cylinder is required for operation.

This gas grill is not intended for commercial use.

DANGER

If you smell gas:

Shut off gas to the appliance.

Extinguish any open flame.

Open Lid.

If d i k f h li

or cont

nues,

eep away

rom t

e app

ance

and immediately call your gas supplier or your fire

department.

WARNING

1. Do not store or use gasoline or other flammable

liquids or vapors in the vicinity of this or any

other a

liance.

2. An LP cylinder not connected for use shall not be

stored in the vicinity of this or any other

appliance.

page 2

Table of Contents

Important Safety Information.………………………..page 4

Important

Safety

Information.………………………..page

Illustrated Parts List……………………………..…..page 6 – 8

Tools Re

uired

Assembl

s and Hardware List..…..

e 9

q, yp

Assembly Instructions……………………………....page 10 – 18

Operating Grill

Connecting Gas Cylinder……………………….page 19

Checking for Leaks……………………………...page 19

Lighting Grill…...…………………………………page 20

Cleaning and Care………………………………page 21

Gas Grill Troubleshooting……………………………page 22 - 23

Grill Preparation………………………………………page 24

Recipes……………………………………………..….page 25 - 27

Accessories…………………………………………….page 28 - 29

page 3

Duo model # 5050 Owner’s Manual

WARNING

FOR YOUR SAFETY

1. DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet (8m) of this or any other

appliance.

2. When cooking with oil/grease, do not allow the oil/grease to exceed 350˚F (177˚C). Do not store of use extra

cooking oil in the vicinity of this or any other appliance.

3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m) away from this or any other

appliance. Never fill the cylinder beyond 80 percent full. If the above information not followed exactly, a fire causing

death or serious injury may occur

death

serious

injury

may

occur

4. If you smell gas:

- Shut Off gas to the grill. - Extinguish any open flame.

- Open Lid. - If odor continues, immediately call your gas supplier or fire department.

For Your Safety

Stop! Call us first! Do Not return product to store. This grill has been made to high quality standards. If you have

any questions not addressed in this manual or if you need parts please call our customer service department at 1-

912-638-4724

(

USA

)

, Monda

-Frida

9am-5

(

EST

)

() y

p( )

NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National

Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code CSA B149.1, or Propane

Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192, and

CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

Minimum distance from sides and back of unit to walls or railings is 36 inches (914mm).

Do not use under overhead construction. This appliance not intended for commercial use.

Do not locate this outdoor cooking appliance under overhead unprotected combustible surface.

For Outdoor Use Only, If Store Indoors, Detach and Leave Cylinder Outdoors.

IMPORTANT NOTICE: read all instructions prior to assembly and use.

Read and understand all warnings and precautions prior to operating your grill.

CAUTION

1. This grill is for use with propane gas only (propane gas cylinder not included).

2. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor

home or house.

3. Never use charcoal or lighter fluid with the gas grill.

4. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be

constructed and marked in accordance with the specifications for propane gas cylinders of the

U S Department of Transportation (DOT) CFR 49 or the National Standard of Canada

Department

Transportation

(DOT)

CFR

the

National

Standard

Canada

CAN/CSA B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and

Commission, as applicable. This grill is not intended to be used in or installed on recreation

vehicles and/or boats..

5. Do not attempt to move the grill while it is lit.

6. Do not use the grill unless it is completely assembled and all parts are securely fastened and

ti ht d

page 4

ene

7. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible

materials, gasoline and other flammable vapors and liquids.

8. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns,

unless you are wearing protective gear (BBQ mittens, pot holders, etc.)

9. Do not alter this grill in any manner.

10. Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or

leaks, the hose must be replaced prior to operating the appliance. The replacement hose

assembly will be that which is specified by the manufacturer.

• Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

N k fill d t i i h t t k H t ill th t

•

ever

eep a

fill

con

ner

n a

car or car

run

ill

cause

e gas pressure

increase, which may open the relief valve and allow gas to escape.

• Keep the grill’s valve compartment, burners and circulating air passages clean. Inspect the grill

before each use.

WARNING

1. This grill is for outside use only, and should not be used in a building, garage or any other

enclosed area.

2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to

properly assemble or safely operate the grill.

3. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you

severely

4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or

blacktop surface may not be acceptable for this purpose.

5. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.

6. Do not place this grill on any type of tabletop surface.

Do not use the grill in high winds

not

use

the

grill

high

winds

DANGER

Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its characteristics

before using any propane product.

• Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in

pools and low areas.

• In its natural state, propane has no odor. For your safety, an odorant has been added.

• Contact with propane can cause freeze burns to skin.

• This grill is shipped from the factory for propane gas use only.

• Never use a propane cylinder with a damaged body, valve, collar or footing.

page 5

• Dented or rusted propane cylinders may be hazardous and should be checked by your propane

gas supplier.

1. GAS GRILL HOOD…....1PC 2. GAS GRILL BODY……...1PC 3. GAS CHIMNEY……..2PCS

ILLUSTRATED PARTS LIST:

4. THERMOMETER……2 PCS 5. HOOD HANDLE……..2 SETS 6.WARMING.RACK…..2PCS

7. BURNER (with shorter wire)..2PCS 8. BURNER (with longer wire)…1PC 9. FLAME SHIELD…..3PCS

10. CHARCOAL HOOD…1PC

11. CHARCOAL BODY….1PC

12.CHARCOAL CHIMNEY...1PC

10.

CHARCOAL

HOOD…1PC

11.

CHARCOAL

BODY….1PC

13.FIRE GRATE HANGER..2PCS 14. FIRE GRATE/ASH PAN..1PC 15. SIDE DAMPER…....1PC

16.SIDE HANDLE………...1PC 17.CONDIMENT BASKET….1PC 18. POT STAND.…………1PC

19. SIDE BURNER / CONTROL

PANEL / HOSE & VALVE….1SET

20. ‘S’ HOOK……..…….3PCS 21. GREASE TRAY……2PCS

PANEL

HOSE

VALVE….1SET

22. CATCH PAN……..…..1PC 23. LEG CROSS BAR….2PCS 24. LEFT LEG..…….…..2PCS

page 7

25. RIGHT LEG……..…2PCS 26. LEG BRACE….…….2PCS 27. BOTTOM SHELF……1PC

28. BASE…………………1PC 29. WHEEL……………..2PCS 30. AXEL………………….1PC

31. AXEL CAP………....2PCS 32. COOKING GRATE...6PCS 33. GRATE HOOK….....1PC

o to next page

the Hardware List

and Assembly Tips.

page 8

Assembly: Requires 2 people. Get another person to help.

Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.

NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit

parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated

parts

from

fitting

together.

All

Hex

Nuts

should

the

inside

the

grill

unless

stated

otherwise. Unpack all contents in a well cleared and padded area.

Estimated Assembly Time: 45 minutes

STOP! Do Not Return to Store. If you are missing parts or need assistance please email us at

info@chargriller.com or call 912-638-4724. Do not attempt assembly if you are missing parts.

HARDWARE:

¼-20x 1 ½” BOLT……8 PCS

HARDWARE:

¼-20x1/2” BOLT….... 43 PCS

SCREW……………….3 PCS

¼” FLAT WASHER…10 PCS

20 HEX NUT 19

PCS

HEX

NUT

……..

PCS

¼” LOCK WASHER…35 PCS

HINGE PINS………..2 PCS

HAIR COTTER PIN….3 PCS

page 9

CENTER HINGE PIN…1 PC

Step 1

Attach the LEFT LEGS & RIGHT LEGS to the BASE using four (4) ½” BOLTS and four (4) ¼”

LOCK WASHERS as shown. When

ou install the LEFT LEG & RIGHT LEG

lease make sure

Assembly Instructions

y,p

that the holes at the top of the LEGS are facing out.

Lock Washer

Step 2

Legs with

Axle Holes

Step

Attach the LEG CROSSBAR to the frame as shown making sure that the holes on the CROSSBAR

are facing inward. See below.

Step 3

Attach BOTTOM SHELF to the LEGS (as shown below). x

page 10

Other manuals for 5050

This manual suits for next models

Table of contents

Other Char-Griller Grill manuals

Char-Griller

Char-Griller Smokin Pro 1244 User manual

Char-Griller

Char-Griller SMOKIN' CHAMP User manual

Char-Griller

Char-Griller Pro Deluxe User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Char-Griller

Char-Griller Duo 5050 User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Char-Griller

Char-Griller BLAZER 2130 User manual

Char-Griller

Char-Griller 72424 User manual

Char-Griller

Char-Griller 2123 User manual

Char-Griller

Char-Griller Deluxe 2929 User manual

Char-Griller

Char-Griller King-Griller Smokin' Ace 3018 User manual

Char-Griller

Char-Griller Super Pro #2121 User manual

Char-Griller

Char-Griller Kamado Kooker 16619 User manual

Char-Griller

Char-Griller AKORN AUTO-KAMADO E6480 User manual

Char-Griller

Char-Griller Smokin' Outlaw 3724 User manual

Char-Griller

Char-Griller 2123 User manual

Char-Griller

Char-Griller 5030 User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Char-Griller

Char-Griller 2123 User manual

Char-Griller

Char-Griller Pro Deluxe 2727 User manual

Char-Griller

Char-Griller 789792021218 User manual

Char-Griller

Char-Griller Side Fire Box #2424 User manual

Char-Griller

Char-Griller Side Fire Box 72424 User manual

Char-Griller

Char-Griller Duo 8482 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide