Char-Griller E2137 User manual

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg.

OWNER’S MANUAL

Charcoal Grill

Model# E2137

Outlaw

Keep your receipt with this manual for Warranty.

CUSTOMER SERVICE 1-912-638-4724

Se[email protected]

Contents of this manual are Trademarked and Copyrighted

by Char-Griller® | A&J Manufacturing

Using the information contained in this manual without consent

of Char-Griller® and/or A&J Manufacturing is strictly prohibited

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 2

STOP! CALL FIRST! DO NOT RETURN PRODUCT TO STORE.

CALL (912) 638-4724 This product has been built to the highest quality standards.

Call us should you have any questions not addressed in these instructions, or for

service information.

Have your grills serial number (located on the back of the grill body or on the leg)

when calling.

7 19

No Returns on

Used Grills

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 3

PARTS LIST AND TOOLS REQUIRED

(Tools Not Included)

Pliers and 7/16" nut driver

ITEM QTY PART NAME PART NUMBER

1 1 HOOD 20-0082

2 1 GRILL BODY 20-0083

3 1 HEAT GAGE 55-0010

4 1 HOOD HANDLE 55-0014

5 1 WARMING RACK 30-0058

6 1 BOTTOM SHELF 20-0130

7 2 LONG LEG 10-0120

8 2 SHORT LEG 10-0121

9 1 ASH PAN 20-0135

10 5 COOKING GRATE 10-0049

11 2 WHEEL 55-0003

12 2 LEG BRACE 10-0051

13 1 AXLE 10-0324

14 2 ASH PAN HANGERS 20-0024

15 3 UTENSIL HOOK 50-0003

16 1 DAMPER CIRCLE 10-0036

17 1 SIDE SHELF 30-0016

18 2 HUB CAP 55-0007

19 2 FRONT SHELF SLAT 10-0115

20 2 FRONT SHELF SUPPORTS 10-0053

21 2 FRONT SHELF BRACKETS 10-0052

22 1 STACK 30-0088

23 1 GRATE LIFTER 10-0045

2 ¼”

35 pcs.

2 ¼”

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 4

Page Intentionally Left Blank For Notes

OM E2137 B.4

™ & © Char-Griller / A&J Mfg.

1. Attach LEGS to BOTTOM SHELF using (4) FOUR 2 1/2” Hex Bolts

and Nuts as shown below.

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 6

2. Attach LEG BRACE to the outside of the LONG LEG using 2 1/4” Hex Bolts and

Nuts as shown but only finger tight.

3. Attach the other end of the LEG BRACES to the corresponding legs using 2 1/4"

Hex Bolts and Nuts but only finger tight. See below.

4. Insert the AXLE through the SHORT LEGS and through the BASE. Slide WHEELS

onto AXLE, install washer and cotter pin then hammer HUB CAPS onto each end of

the AXLE to secure WHEELS.

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 7

5. Stand the CART/LEG ASSEMBLY upright. Attach the bottom half of the BODY to

the CART/LEG ASSEMBLY (make sure damper is on same side as wheels) with

four 2 1/4" Hex Bolts. There are two holes in the front and two in the back of the

grill BODY. See below.

6. Attach two (2) 8" FRONT SHELF BRACKETS to the front edge of BOTTOM HALF

of grill body using two (2) 3/4" Hex Bolts and Nuts (with the nuts on the inside

of the grill). Attach the long WOOD SLATS to the FRONT SHELF BRACKETS and

at the same time attach the FRONT SHELF SUPPORT BRACES to the underside

of the outer Holes of the FRONT SHELF BRACKETS with four (4) 1" Carriage

Bolts and Nuts. Attach the other end of the Support Braces to the Grill Body.

See below.

7. Insert SMOKESTACK from INSIDE the HOOD up through the hole. Attach with two

(2) 3/4" hex bolts with the nuts on the inside. See below. Note: It is not neces-

sary to remove the Stack Damper.

Damper

Hex Bolt

Hex Nut

Smokestack

( Insert from inside)

Carriage Bolt

Front Shelf

Bracket

Front Shelf Support Brace

Attach to Grill Body

Bottom Half of

Grill Body

Hex Nut

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 8

8. Insert HEAT GAUGE through hole in hood (from outside) and push the SPLIT

RING over tabs on the side of HEAT GAUGE from inside the hood.

9. Attach WOOD HOOD HANDLE to the center of the HOOD with two (2) 3/4" hex

bolts, lock washers, and hex nuts. See below.

10. Set the HOOD, in the CLOSED POSITION, on top of the bottom Half of the grill

body. Line up the Hinge holes and insert the Hinge Pins. This may require lifting

up on the back of the Hood. Then, carefully open the hood, making sure to not

let the Hinge Pins fall out, and insert the Hair Cotter Pins into the Hinge Pins.

See below.

Hood

Hinge

Hair Cotter Pin

Hinge Pin

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 9

11. Attach the DAMPER CIRCLE from the inside of bottom half of grill body with a

3/4" Bolt. The bolt goes thru a Flat Washer, thru the Damper Circle, thru the

Grill Body, thru another Flat Washer, thru a Lock Washer, and finally attached to

a Hex Nut. The small tab on the Damper Circle should protrude outward. Fig. J.

12. Attach SIDE SHELF to the four (4) holes on left side of grill with 1/2" hex bolts

and nuts. See below.

Hex Nuts

Hex Bolts

Side Shelf

Inside of

Charcoal

Grill Body

OM E2137 B.4 ™ & © Char-Griller / A&J Mfg. 10

13. ATTACHING WARMING RACKS PIVOT BOLTS: On each END of the HOOD just

back of center, insert one (1) 2" HEX BOLT (total 2) (from outside in) in holes (A)

with HEX NUTS on inside of HOOD. See Below.

On each END of the LOWER GRILL BODY 4" from the back corner, insert one (1)

3/4" HEX BOLT (total 2) (from outside in) in holes (B) with HEX NUTS on inside

of GRILL BODY. See below.

Do not install WARMING RACK until after tightening all four WARMING RACK

PIVOT BOLTS.

ATTACH THE WARMING RACK’S (4) WIRE LOOP HOLES, located on the WARM-

ING RACK’S SIDES and WIRE LEGS, over the four (4) PIVOT BOLTS in the HOOD

and GRILL BODY. Attach left side first. Hint: You may flex the WIRE LEG out-

wards for a tighter fit and to center. See below.

14. Tighten ALL nuts and bolts.

15. Place FIRE GRATE, with ADJUSTABLE HANGERS attached, into BOTTOM HALF of

grill body. See Below. Install the COOKING GRATES.

CONGRATULATIONS, ASSEMBLY COMPLETE!

Fire Grate

2” Bolt

3/4” Bolt

Inside of

Hood Hex Nut

Table of contents

Languages:

Other Char-Griller Grill manuals

Char-Griller

Char-Griller Smokin' Pro 1224 User manual

Char-Griller

Char-Griller SMOKIN' CHAMP User manual

Char-Griller

Char-Griller Stealth 2903 User manual

Char-Griller

Char-Griller Smokin' Outlaw 3724 User manual

Char-Griller

Char-Griller DC50 User manual

Char-Griller

Char-Griller Outlaw #2137 User manual

Char-Griller

Char-Griller E3072 User manual

Char-Griller

Char-Griller Side Fire Box #2424 User manual

Char-Griller

Char-Griller Patio Pro 1515 User manual

Char-Griller

Char-Griller Outlaw #2137 User manual

Char-Griller

Char-Griller Akorn Jr. 6714 User manual

Char-Griller

Char-Griller GRAND CHAMP 8250 User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Char-Griller

Char-Griller Grillin' Pro 3001 User manual

Char-Griller

Char-Griller Pro Deluxe 2727 User manual

Char-Griller

Char-Griller Kamado Kooker 16619 User manual

Char-Griller

Char-Griller 2123 User manual

Char-Griller

Char-Griller Competition Pro 8125 User manual

Char-Griller

Char-Griller Akorn JR. Kamado 06614 User manual

Char-Griller

Char-Griller 5050 User manual

Char-Griller

Char-Griller Duo 8482 User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Char-Griller

Char-Griller Deluxe 2929 User manual

Char-Griller

Char-Griller Portable Table Top 2-2424 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide