Whispbar K684W User manual
K684W
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 4 x 4 x 4 x 8
x 2 x 2 x 4 x 4
x 4 x 4 x 1 x 4
Revision No: 4D 1
Fitting Kit K684W
MAX kgs (lbs)
W/P WHD
Jeep
Compass, 5dr SUV 11-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
Compass, 5dr SUV 11-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)
Compass, 5dr SUV 11-+ ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
Compass, 5dr SUV 11-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)
Compass, 5dr SUV 11-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)
Compass, 5dr SUV 11-+ CN 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit K684W
X
A B C 1 2 3
Compass, 5dr SUV 11-+ (NZ) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
Compass, 5dr SUV 11-+ (AU) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
Compass, 5dr SUV 11-+ (ZA) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
Compass, 5dr SUV 11-+ (EU) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
Compass, 5dr SUV 11-+ (US) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
Compass, 5dr SUV 11-+ (CN) 110mm 800mm - 860mm 825mm -
4 5/16ths" 31 1/2ths" - 33 7/8ths" 32 1/2ths" -
3
Fitting Kit EN
K684W
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
4
Fitting Kit EN
K684W
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Set bars to length (revert to rear of these
instructions).
●Clamps onto flush roof rail. Pins locate on
inside of rail.
5
Fitting Kit EN
K684W
●Tighten adjusting screw to 5 Nm (3.7 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Remove both pins from each leg. Use
tapered end of spanner located inside left
hand cover to assist.
6
Fitting Kit EN
K684W
●Detach foot from leg. Store loose parts in a
safe place.
●Repeat for all legs.
●Select four feet assemblies and match the
left and right assemblies to the left and
right roof rack legs.
●Assemble foot from kit into leg by pressing
it down.
●Ensure foot interlocks with leg.
●Using short capscrew and washer, secure
assembly onto leg (use Hex Screwdriver
supplied with crossbar to assist)
●Do not over tighten.
●Repeat for all legs.
7
Fitting Kit EN
K684W
●Use two M5 x 12 mm self tapping screws to
secure the assembly onto the leg.
●Do not over tighten.
Fitment
●Apply protective strip as shown.
Trim if required.
●Place crossbar foot over fixed-point mount.
8
Fitting Kit EN
K684W
●Open or remove fixed-point covers.
●Place crossbar foot over fixed-point mount.
●Ensure back edge of foot sits flush with the
back edge of vehicle roof rail.
●Slide clamp through opening in leg.
●Using the Hex Key and the capscrews,
secure the clamps to the vehicle.
●Ensure spring washer is between clamp
and the head of the screw.
9
Fitting Kit EN
K684W
●Thread the coach bolt through the clamp
and the leg.
●Tighten the plastic knob.
●Ensure the plastic knob is in the position
shown when fully tightened.
●Do not over tighten.
●Repeat for all four positions.
●Use keys to fit and lock covers
●Check crossbar is securely attached to the
vehicle.
10
Table of contents
Other Whispbar Automobile Accessories manuals
Whispbar
Whispbar K930W User manual
Whispbar
Whispbar K832W User manual
Whispbar
Whispbar K524W User manual
Whispbar
Whispbar K868W User manual
Whispbar
Whispbar K050W Operation and installation manual
Whispbar
Whispbar K722W User manual
Whispbar
Whispbar K938W User manual
Whispbar
Whispbar WBT21 User manual
Whispbar
Whispbar K410W User manual
Whispbar
Whispbar K663W User manual
Whispbar
Whispbar PR3077 Operation and installation manual
Whispbar
Whispbar K078W User manual
Whispbar
Whispbar K860W User manual
Whispbar
Whispbar K489W User manual
Whispbar
Whispbar K471W User manual
Whispbar
Whispbar K333W User manual
Whispbar
Whispbar K199W User manual
Whispbar
Whispbar K901W User manual
Whispbar
Whispbar K888W User manual
Whispbar
Whispbar K549W User manual
