Sun Microsystems Sun Enterprise 4500 User manual

This document applies only to the Sun Enterprise 4500 system using the

464-MHz CPU/Memory modules.

Note – The 464-MHz 8-Mbyte CPU modules in Sun Enterprise 6500/5500

and rackmounted Sun Enterprise 4500 systems should not exceed

temperatures of 35°C between 0–6,000 foot altitude or exceed 32°C between

6,000–10,000 foot altitude. Standalone Sun Enterprise 4500 and 3500 systems

cannot exceed 40°C between 0–6,000 feet or exceed 37°C between

6,000–10,000 feet.

Before beginning subassembly procedures, notify users that the system is

going to be powered off. Refer to Chapter 11, “Powering Off and On” in

the Sun Enterprise 6500/5500/4500 Systems Reference Manual for power-off

procedures.

Removing Subassemblies

1. Unlock and remove the front panel bezel.

a. Press inward on the serrated edges at the lower left and right

sides of the bezel.

b. Tilt the bezel up 45 degrees to remove it.

2. Remove the media tray

a. Loosen the three captive screws that hold the media tray in place.

b. Insert a screwdriver in the notch at the top center of the media

tray and pull the tray forward a few inches.

c. Then grasp the tray with both hands to remove it completely out

of the system.

3. Remove the seven flathead screws on top of the media tray and lift

the tray cover off to access the DVD-ROM and tape drive, if there is

one.

4. Remove the DVD-ROM

a. Disconnect the power connector and the SCSI connector from the

DVD-ROM.

b. Unfasten the three captive screws on the mounting plate on which

the DVD-ROM rests.

c. Lift the back of the DVD-ROM and gently pull it out at an angle

to clear the DVD-ROM opening. Set it aside on an ESD mat.

d. Repeat Steps b and c for removing the tape drive, if necessary.

Installing the Spring Gaskets and Subassemblies

1. Peel the adhesive from the bottom of one of the spring gaskets and

apply the closed-edge side of the gasket against the inside front of

the media tray.

Center each spring gasket using the opening of the DVD-ROM and

tape drive as a guide.

2. Repeat Step 1 to apply the second spring gasket.

3. Install the DVD-ROM and tape drive by reversing the order of the

DVD-ROM removal procedures.

4. Fasten the seven flathead screws on the cover of the media tray.

5. Insert the media tray back into the card cage.

6. Fasten the three captive screws on the card cage.

7. Power the system back on.

Refer to Chapter 11, “Powering Off and On” in the Sun Enterprise 6500/

5500/4500 Systems Reference Manual for powering on procedures.

DVD-ROM

Spring gaskets

Please

Recycle

Accessing Sun Documentation Online

A broad selection of Sun system documentation is located at the following

web site:

http://www.sun.com/products-n-solutions/hardware/docs

To locate the most current documentation at this site, select a product

category. The documents at that location may include updated information

that did not ship with your product, such as product notes, release notes,

late-breaking news, or later revisions of manuals.

Ordering Sun Documentation

Fatbrain.com, an Internet professional bookstore, stocks select product

documentation from Sun Microsystems, Inc. For a list of documents and

how to order them, visit the Sun Documentation Center on Fatbrain.com

at:

http://www1.fatbrain.com/documentation/sun

Sun Welcomes Your Comments

Sun is interested in improving its documentation and welcomes your

comments and suggestions. You can email your comments to Sun at:

[email protected]

Please include the part number (816-1472-10) of the document in the

subject line of your email.

Sun Enterprise™4500 System

EMI Spring Gasket

Installation Guide

Part Number: 816-1472-10

June 2001, Revision A

software, including font technology, is copyrighted and licensed from Sun suppliers. Sun, Sun

Microsystems, the Sun Logo, AnswerBook2, docs.sun.com, Sun Enterprise, and Solaris are trademarks or

registered trademarks of Sun Microsystems, Inc. in the U.S. and other countries. RESTRICTED RIGHTS:

Use, duplication, or disclosure by the U.S. Federal Acquisitions: Commercial Software—Government

Users Subject to Standard License Terms and Conditions. Federal Acquisitions: Commercial Software—

Government Users Subject to Standard License Terms and Conditions.

restreignent l’utilization. Le logiciel détenu par des tiers, et qui comprend la technologie relative aux

polices de caractères, est protégé par un copyright et licencié par des fournisseurs de Sun. Sun, Sun

Microsystems, le logo Sun, AnswerBook2, docs.sun.com, et Solaris sont des marques de fabrique ou des

marques déposées de Sun Microsystems, Inc. aux Etats-Unis et dans d’autres pays.

Sun Microsystems, Inc. • 901 San Antonio Road • Palo Alto, CA 94303-4900

USA• 650 960-1300 • Fax 650 969-9131

Table of contents

Other Sun Microsystems Server manuals

Sun Microsystems

Sun Microsystems SPARC Enterprise T5240 User manual

Sun Microsystems

Sun Microsystems Sun Enterprise 10000 User manual

Sun Microsystems

Sun Microsystems Sun SPARC Enterprise M3000 Instruction Manual

Sun Microsystems

Sun Microsystems Sun Fire X2250 Installation and operating manual

Sun Microsystems

Sun Microsystems Sun Java SystemDirectory Server User manual

Sun Microsystems

Sun Microsystems Netra T2000 User manual

Sun Microsystems

Sun Microsystems Fire V210 User manual

Sun Microsystems

Sun Microsystems Enterprise 250 User manual

Sun Microsystems

Sun Microsystems Netra X4450 User manual

Sun Microsystems

Sun Microsystems Sun Fire V440 User manual

Sun Microsystems

Sun Microsystems Sun GlassFish Enterprise Server 2.1 Instruction Manual

Sun Microsystems

Sun Microsystems Enterprise 250 Quick start guide

Sun Microsystems

Sun Microsystems Netra T4 AC100 User manual

Sun Microsystems

Sun Microsystems SunSwift SPARCserver 1000 User manual

Sun Microsystems

Sun Microsystems V250 Use and care manual

Sun Microsystems

Sun Microsystems Sun Netra CP3220 User manual

Sun Microsystems

Sun Microsystems Netra t1 100 Instruction Manual

Sun Microsystems

Sun Microsystems Fire High-End Server Systems Programming manual

Sun Microsystems

Sun Microsystems Netra T4 AC100 User manual

Sun Microsystems

Sun Microsystems Netra 440 User manual

Sun Microsystems

Sun Microsystems SunSwift SPARCserver 1000 User manual

Sun Microsystems

Sun Microsystems Sun Fire T1000 User manual

Sun Microsystems

Sun Microsystems Netra 440 User manual

Sun Microsystems

Sun Microsystems Sun Fire X4140 User manual

Popular Server manuals by other brands

HP AlphaServer ES47 Cli reference manual

Dell

Dell PowerEdge R410 Getting started

PowerNAS

PowerNAS CMA quick start guide

Supero

Supero FatTwin F617R3-FT user manual

MSI

MSI P1-109N-L70 user manual

Dell

Dell PowerEdge XE9640 Installation and service manual

Dell

Dell PS4100 Hardware

EtroVISION

EtroVISION EV3151 user manual

NEC

NEC Express5800/T110j System configuration guide

HP ProLiant Gen9 user guide

Compaq

Compaq ProLiant 3000 Maintenance and service guide

Dell

Dell PowerEdge 3YPMN Getting started guide

iRobo

iRobo IPC2U user manual

Nortel

Nortel 1000 Con?guration guide user manual

Asus

Asus AP7500 Hardware reference guide

Avid Technology

Avid Technology AirSpeed 5000 manual

HP Integrity rx2600 overview

Milestone

Milestone Husky IVO 350T Getting started