Outback RC4340S User manual

Photographs are not to scale.

Specifications subject to change

without prior notice.

Assembly and Operating Instructions for Outback®

Ranger 3S Gas BBQ and Ranger 3 Gas BBQ

WARNING

• For outdoor use only. Not for commercial use.

• Read instructions before using the appliance. Failure to follow instructions could

result in death, serious bodily injury, and/or property loss.

• Warning: accessible parts may be very hot. Keep young children and pets away.

• Do not move the appliance during use.

• Turn off the gas supply at the gas bottle after use.

• Any modification of the appliance, misuse, or failure to follow the instructions may be

dangerous and will invalidate your warranty. This does not affect your statutory rights.

• Retain these instructions for future reference.

• Leak test annually, and whenever the gas bottle is removed or replaced. Check that the

hose connections are tight and leak test each time you reconnect the gas bottle.

• For Flare-up control please refer to the ‘OPERATION’ section of this manual.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and

contact your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use shall not be

stored in the vicinity of this or any other

appliance.

0359

RC4340S RC4341

Parts List

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see ‘Hardware Reference Diagram’.

CODE PART QTY Ranger 3S

Gas BBQ

Ranger 3

Gas BBQ

HOOD

A1 Hood (Pre-Assembled to Body) 1  

A2 Hood Handle 1  

A3 Heat Indicator 1  

A4 Warming Rack 1  

BODY

B1 Cooking Grill 2  

B2 Lava Rock 2 

B3 Lava Rock Basket 2 

B4 Barbecue Body 1  

B5 Knob 3  

B6 Control Panel 1  

B7 Burner 3  

B8 Drip Tray Handle 1 

B9 Drip Tray 1 

B10 Drip Tray Left Bracket 1 

B11 Drip Tray Right Bracket 1 

B12 Hose and Regulator Assembly 1  

TROLLEY

C1 Side Burner Shelf 1

C2 Side Burner Assembly 1

C3 Side Burner Grid 1

C4 Side Shelf 21

C5 Tool Hook Support 1 

C6 Tool Hook 3  

C7 Left Front Leg 1  

C8 Left Rear Leg 1  

C9 Right Front Leg 1  

C10 Right Rear Leg 1  

C11 Beer Bottle Opener 1  

C12 Front Screen 1  

C13 Fixing Support 2  

C14 Trolley Base 1  

C15 Axle 1 

C16 Wheel 2 

C17 Hubcap 2  

HARDWARE

D1 M5x15 Bolt 4  

D2 Spacer 4  

D3 M5 Nut 4  

D4 M6x95 Bolt 8  

D5 Washer 8  

D6 1/4-20UNCx25 Bolt 16  

D7 1/4-20UNCx12 Bolt 8  

D8 M6x10 Bolt 2  

D9 M6x15 Bolt  4

D10 M6 Nut  4

D11 M4 Step Screw  2

D12 Locknut 2  

D13 1/4-20UNCx30 Bolt 8  

Pre-Assembled Component

Quantity varies according to model purchased

 Appearance, size, and construction may differ according to model purchased

Parts Diagrams (Ranger 3S Gas BBQ)

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see hardware pack page.

C15

C17

B12

C11

C12

D12

B10 B11 C4

C13

C14

C10

C16

Parts Diagrams (Ranger 3 Gas BBQ)

Quantities vary according to model purchased. Specifications subject to change without prior notice. For

more details on hardware, please see hardware pack page.

C7C8

B12

C12

B10 B11 C4

C13

C14

C17

C11

C10

C16

D12

C15

Hardware Reference Diagram (Ranger 3S Gas BBQ)

Specifications subject to change without prior notice.

D1,D2,D3D7

D4,D5

D13

Hardware Reference Diagram (Ranger 3 Gas BBQ)

Specifications subject to change without prior notice.

D1,D2,D3

D4,D5

D9,D10

D11

D13

Assembly

IMPORTANT!

• TOOLS NEEDED FOR ASSEMBLY: Medium size flat blade or Phillips/Crosspoint screwdriver,

adjustable spanner or metric spanner set.

• The assembly of this barbecue at least requires 2 people.

• Remove any internal components or packaging from the barbecue body.

• Whilst every care is taken in the manufacture of this product, care must be taken during assembly in

case sharp edges are present.

• Please read the Important Information section carefully before assembly and use of your

barbecue.

Attach the Front Legs (C7, C9), Fixing Support (C13) onto the Trolley Base (C14) by aligning

corresponding holes and fixing with the 1/4-20UNCx30 Bolts (D13x4pcs) as shown.

Ensure Front legs with the hole for assembling Front Screen to them are at the facing

inwards of the barbecue.

Attach the Rear Legs (C8, C10), Fixing Support (C13) onto the Trolley base by aligning

corresponding holes and fixing with the 1/4-20UNCx30 Bolts (D13x4pcs) as shown.

C13

C14

C7 C9

C8 C13 C10

D13

Unscrew the Locknuts (D12x2pcs) from both ends of the Axle (C15). Slide the axle through

the corresponding holes in the left legs. Slide the Wheels (C16) over each end of the axle.

Secure the wheels into place with the locknots. Place the Hubcaps (C17) ont the outsides of

the wheels.

Attach the Front Screen (C12) to the Front Left / Right Legs using 1/4-20UCNx12 Bolts

(D7x6pcs) as shown.

C17 C16

D12 C15

Rear view

C12

Insert M6x95 Bolts (D4x8pcs) through the trolley legs, the Washers (D5x8pcs), and keep the

tip of the bolts inside the washers. While holding the barbecue body into position (2 people

required), screw the bolts into the barbecue body as shown.

CAUTION! Care must be taken to ensure the hood or lid does not fall open

unexpectedly or becomes damaged when it is set on the ground.

Attach Drip Tray Left Bracket (B10) to barbecue body using M5x15 Bolts (D1x2pcs), Spacers

(D2x2pcs) and M5 Nuts (D3x2pcs) as shown. Repeat above process for Drip Tray Right

Bracket (B11).

NOTE: Ensure that the big tabs of the brakets which stop the drip tray are located at the

front of the barbecue.

D5 D4

FRONT

REAR

B10D1 D2 D3

Attach the Beer Bottle Opener (C11) to the Right front leg using 1/4-20UNCx12 Bolts (D7x2pcs).

Attach the Tool Hook (C6) to the Tool Hook Support (C5) as shown, Make sure the direction of

tool hook is facing outward. Attach the Tool hook assembly to the Side Shelf (C4) using M6x10

Bolts (D8x2pcs).

Remove the retaining bolts from Drip Tray Handle (B8), and then attach it onto the Drip Tray

(B9) using the retaining bolts.

Insert the Drip Tray by sliding it underneath the barbecue body.

C11 C5C6 C4

This manual suits for next models

Table of contents

Other Outback Grill manuals

Outback

Outback Omega 100 User manual

Outback

Outback Party Select 6 Burner Gas BBQ FS5680 User manual

Outback

Outback TPA101-4 User manual

Outback

Outback Omega 201 User manual

Outback

Outback Jupiter 4S User manual

Outback

Outback Comet Kettle K102 User manual

Outback

Outback MS4464 User manual

Outback

Outback Omega Charcoal 100 User manual

Outback

Outback NEW Apollo 4 User manual

Outback

Outback THG3302P User manual

Outback

Outback Spectrum 2 Burner User manual

Outback

Outback Meteor MT-H4430-3 User manual

Outback

Outback Jupiter 4S User manual

Outback

Outback Hunter Plus 3 User manual

Outback

Outback Excel 100T User manual

Outback

Outback THG3710SS-3 User manual

Outback

Outback RC4341PC User manual

Outback

Outback RS4491SC User manual

Outback

Outback Senator 6 User manual

Outback

Outback Charcoal Roaster 2000 User manual

Outback

Outback TRG2301P-3 User manual

Outback

Outback OUTBACK TROOPER 359 Assembly and User manual

Outback

Outback Excel 100 User manual

Outback

Outback Omega 150 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide