HP 13255 Manual

13255

CARTRIOG~

TAPE

MODULE

Manual

Part

No.

13255-91032

PRINTED

AUG-Ol-76

DATA

TERMINAL

1~ECHNICAL

INFORMATION

_._._----------------------

HEWLETT~PACKARD

Printed

U.S.A.

13255

Cartridge

Tape

Module

1.0

IMTRODUCTION.

13255-91032/02

Rev AUG-Ol-76

The

cartridge

Tape

Module

consists

Cartridge

Tape

Unit

(CTU)

Interface

peA,

Read/Write

PCA, a CIU Top

Plane

Assembly,

two

CTU

Transport

Assemblies,

and

one

mini

tape

cartridges.

Each

tape

cartridqe

contains

150

teet

single-track

O.150-inch

tape

with

maximum

tOrmatted

storage

capacity

110K

eight-bit

data

bytes.

The

dual

cartridge

tape

units

provide

full

read

and

write

capabilities

for

phase-encoded

data.

Data,

command,

status

information,

and

address

interfacing

between

this

subsection

and

other

terminal

modules

pro-

vided

the

Backplane

Assembly

and

CTU

Interface

PCA. The

R~ad/Write

PCA

controls

recording,

reading,

and

tape

motion

the

two

CTU

Trans-

port

Assemblies.

Interfacing

between

the

two

PCA's

provided

the

CTU

TOp

Plane

Assembly

and

interfacing

between

the

Read/write

PCA

and

the

two

CTU

Transport

Assemblies

provided

Motor

cable

Assembly

and

two

CTU

ribbon

cable

assemblies.

2.0

OPERATING

PARAMETERS.

A summary

operating

parameters

for

the

Cartridge

Tape

Module

contained

tables

1.0

through

5.3.

Table

1.0

Physical

Parameters

----------------~---~---~----~--~---~-----~-~-~-~-~-~~--~---------~--~~--~~---~~

-----~~---------~-----~-----~-----------~-~~~----------------~---------~~-----~-

part

Size

x W x D)

Weight

Number

Nomenclature

+/-0.100

Inches

(Pounds)

-.-.--.-----...

_--

-~-------~-------~----------~~

=======================

=========

----_

...

_---_

....

---~------~-------~---~~------

O~640-60021

CTU

Top

Planp.

Assembly

4.4

1.1

0.7

0.10

02640-60032

Read/write

PCA

12.5

4.0

0.6

0.60

02640-60033

CTU

Interface

PCA

12.5

4.0

0.5

0.40

02640-60034

Cartridge

Flectronics

PCA

3.8

2.0

1.3

0.10

02640-60050

CTU

Transport

Assembly

5.1

3.6

3.8

0.80

02640-60054

Cl'U

Base

Assembly

N/A

02640-60055

Motor/Tachometer

Assembly

tv/A

N/A

02640-60056

Head

Bridge

Assembly

t-t/A

N/A

02640-60057

Tachometer

Coil

AssemblY

N/A N/A

02640-60066

CTU

Cable

Assembly

N/A

02640-60067

Head

Assembly

N/A

02640-60074

Magnet

Assembly

N/A

02640-60076

Disc/Capstan

Assembly

N/A

0~640-60085

Motor

Cable

Assembly

N/A

02640-60102

Cl'U

Bezel

Assembly

N/A

9162-0061

Mini

cartr1dge

N/A N/A

==============================================================================

Number

Backplane

Slots

Required:

================================:===============================================

13255

CARTRIDGE

TAPE

MODULE

Manual

Part

No.

13255-91032

PRINTED

AUG-Ol-76

____

...-_

....

_.-~

..........

-----------~-.a-------....~~---.-~----------...-.----

NOTICE

The

information

contained

this

document

subject

change

Without

notice.

H~WLETT-PACKARO

MAKES

WARRANTY

ANY

KIND

WITH

REGARD

THIS

MATERIAL,

INCLUDING,

BUT

NOT

LIMITED

THE

IMPLIED

WARRANTIES

MERCHANTABILITY

AND

FIT~ESS

FOR

PARTICULAR

PURPOS~.

Hewlett-Packard

shall

not

liable

for

errors

contained

herein

for

incidental

Consequential

damaqes

connection

with

the

turnishing,

performance,

use

tnis

material.

Tnis

document

contains

proprietary

information

which

protected

All

rights

are

reserved.

part

this

document

may

Photocopied

reproduced

without

the-orior

written

consent

He~lett

Pa.ckard

Company.

-~--

--~~------~~--~-~------.~--.~-~--~---~-------~~-~-----------~---------~----

1976

HE~L~TT-PACKARD

COMPANY

NOTE:

This

document

part

the

264XX

DATA

-TERMINAL

product

series

Technical

Information

Package

(HP

13255).

132~5

Cartridge

Tape

Module

1.0

IMTRODUCTION.

13255-91032/02

Rev

AUG-01-76

The

cartridge

Tape

Module

consists

Cartridge

Tape

Unit

(CTU)

Interface

peA,

Read/Write

PCA, a CiU Top

Plane

Assembly,

two

CTU

Transport

Assemblies,

and

one

mini

tape

cartridges.

Each

tape

cartridqe

contains

150

teet

Single-tracK

O.150-inch

tape

with

maximum

tormatted

storage

capacity

110K

eight-bit

data

bytes.

The

dual

cartridge

tape

units

provide

full

read

and

write

capabilities

for

phase-encoded

data.

Data,

command,

status

information,

and

address

interfacing

between

this

subsection

and

other

terminal

modules

pro-

vided

the

Backplane

Assembly

and

CTU

Interface

PCA. The

Read/Write

PCA

controls

recording,

reading,

and

tape

motion

the

two

CTU

Trans-

port

Assemblies.

Interfacing

between

the

two

PCA's

provided

the

CTU

TOp

Plane

Assembly

and

interfacing

between

the

Read/Write

PCA

and

the

two

CTU

Transport

Assemblies

provided

Motor

Cable

Assembly

and

two

CTU

ribbon

cable

assemblies.

2.0

OPERATING

PARAMETERS.

summary

operating

parameters

for

the

Cartridge

Tape

Module

contained

tables

1.0

through

5.3.

Table

1.0

Physical

Parameters

================================================================================

part

Number

=============

0:l640-60021

02640-60032

02640-60033

02640-60034

02640-60050

02640-60054

02640-60055

02640-60056

02640-60057

02640-60066

02640-60067

026,*0-60074

02640-60076

0:l640-60085

02640-60102

9162-0061

Nomenclature

-~------------~~-~--~~---~--~~

-~~~--------------~---------~-

CTU

Top

Plan~

Assembly

Read/Write

peA

CTU

Interface

PCA

Cartridge

Flectronics

peA

CTU

Transport

Assembly

CTU

Base

As~embly

Motor/Tachometer

Assembly

Head

Br1dge

Assembly

TaChometer

Coil

Assembly

CTU

Cable

Assembly

Head

Assembly

Magnet

Assembly

Disc/Capstan

Assembly

Motor

Cable

Assembly

CTU

Bezel

Assembly

Mini

cartridge

Size

(L x W x

+/-0.100

Inches

=======================

4.4

1.1

0.7

12.5

4.0

0.6

12.5

4.0

0.5

3.8

2.0

1.3

5.1

3.6

3.8

N/A

Weight

(Pounds)

=========

0.10

0.60

0.40

0.10

0.80

N/A

==============================================================================

Number

Backplane

Slots

Required:

================================================================================

13255

13255-91032/03

Cartrldge

Tape Module Fev AUG-Ol-76

Table

2.0

Peliabil1ty

and

Environmental

Information

=====::==========================================================================

I:.nvlronmentaJ.:

( X )

CldSS

B ( )

Other:

Restrictions:

Type

tested

product

level

except

the

cartridge

tape.

The

cartridge

tape

limits

temperature

and

humidity

conditions

follows.

Free

space

ambient

temperature:

Non-operating:

-10

degrees

(-15

+150

degrees

Operating:

+ 5

degrees

(+41

+104

degrees

F')

Humidity:

80%

(non-condensing)

====::=========================================================================

Failure

Rate

(percent

per

1000

hours)

Major

Assemblies:

CTU

Interface

PCA

Read/Write

peA

CTU

Top

Plane

Assembly

Motor

Cable

Assembly

CTU

Transport

Assembly

0.82340%

4.04199%

0.000R8%

0.00060%

4.17800%

Lite

expectancy

tor

components

the

CTU

Transport

Assembly

(the

maximum

insertion

rate

per

second.

Data

for

the

head,

motor,

and

motor

capstan

apply

start-stop

motion

inches

per

second):

E.ject,

Insert

Mechanism

20,000

insertions

min.

(50,000

typical)

cartridge

Insert

and

100,000

insertions

min.

file

Protect

Switches

Head/Write

Head

3,000

hours

min.

(10,000

hours

typical)

14otor

1,000

hours

min.

(

5,000

hours

typical)

I~Otor

Capstan

1,000

hours

min.

(

5,000

hours

typical)

=====::==========================================================================

13255

Cartridge

Tape Module

13255-91032/04

Rev AUG-Ol-76

laole

3.0

Total

Module power

Supply

and

Clock

Requirements

Measured

While

Accelerating

ips

(At

+/-5%

Unless

otherwise

Specified)

================================================================================

+5 VOlt

supply

+12

Volt

supply

1350

rnA

1630

rnA

-12

Volt

Supply

1580

rnA

+42

Volt

SupplY

rnA

NOT

APPLICABLE

======================================1=======================================

115

volts

220

volts

A A

NOT

APPLICABLE

NOT

APPLICABLE

==============================================================================

Clock

Frequency:

4.915

MHz

================================================================================

132~S

Cartridge

Tape

MOdule

13255-91032/05

Rev AUG-Ol-76

Table

4.0

Connector

Information

for

CTU

Interface

PCA

================================================================================

connector

and

NO.

===:===========

PI,

..2

-3

-4

-5

-6

-7

-8

··10

-11

-12

-13

-14

-15

-16

-11

-18

-19

-20

-21

-22

Signal

Name

-~--~-~---------

-~----~-------~-

+5V

GND

SYS

eLK

-l2V

ADORO

ADORI

ADOR2

ADOR3

ADDR4

ADDR5

ADDP6

ADDR7

ADORa

AODR9

ADDRI0

ADORl1

ADOH12

ADDR13

ADOH14

ADDR15

I/O

GND

Signal

Description

-----~-------~~---------------~~----~------~--

-~~~-----~-~--~---~-~--~----------------------

Volt

Power

Supply

Ground

Common

Return

(Power

and

Signal)

4.915

MHz

System

Clock

-12

Volt

Power

Supply

Negative

True,

Address

Ait

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negntive

True,

Address

Bit

Negative

True,

Address

8it

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negative

True,

Address

Bit

Negativ~

True,

Address

81t

Negative

True,

Address

Bit

Negative

True,

Input

Output/Memory

Ground

Common

Return

(Power

dnd

Signal)

================================-===============================================

13255

Cartridge

Tape

Module

13255-91032/06

Rev AUG-Ol-16

Table

4.0

Connector

Intormation

for

CTU

Interface

PCA

(Cont'd.)

=====:==========================================================================

Connector

Signal

and

NO. I

Name

==============1================

PI,

A I

GNO

-Ii

POLL

-c I

+12V

-I)

PWR

-E

BUSO

-F

RUS1

-H

BUS2

-J

BUS3

-K

BUS4

-L

BUS5

RUS6

-N BUS.,

---

-P

wRITE

-R

ATN2

-s

WAIT

-T

PRIOR

-u PRIOR

OUT

......

.....-.-------

-V

PROC

ACTIVE

-w

BUSY

-x

RUN

-y

REQ

-z

ATN

Siqnal

Description

----------------------------------------------

~------~-------------~--~-~----~--~-~----~--~-

Ground

Common

Return

(PGwer

and

Signal)

Negative

frue,

Polled

Interrupt

Identitication

Request

+12

Volt

Power

Supply

System

Power

Negative

True,

Data

Bus

Bit

Negative

True,

Data

Bus

Bit

Neqative

True,

Data

Bus

Bit

Negative

True,

Data

Bus

Bit

Negative

True,

Data

Bus

Bit

Negative

True,

Data

Bus

Bit

Neqative

True,

Data

Bus

Bit

Negative

True,

Data

Bus

Bit

Negative

'frue,

write/Read

Type

Cycle

Negative

True,

CTU

and

Polled

Interrupt

Request

Negative

True,

wait

Control

Line

Bus

Controller

Priority

Bus

Controller

Priority

Out

Negative

True,

Processor

Active

(Controlling

Bus)

Negative

True,

Bus

Currently

Busy

(Not

Available)

Allow

Processor

Access

Bus

Negative

True,

Request

(Bus

Data

Currently

Valid)

Negative

True,

Data

Comm

Interrupt

Request

================================================================================

13255

Cartrldge

Tape

~odule

13255-91032/07

Rev AUG-01-76

Table

4.1

connector

Information

for

CTU

Interface

PCA

================================================================================

Connector

Signal

and

NO.

I Name I

==============1================

P3,

1 I

tnru

-22

---------~---~I------~---------

p3,

-8

HOLO

-C

-0

HOLI

-E

+SV

-F

-H

USO

-J

DATA

-K

2Xl'ACH

-L

RUNG

-M

TACH

-N

DZX

-p

GAP

-R

CINO

-S

ClNl

-T

RIP

-u DZX

-v STOP

-w

FF'U

-x

SFt>

-y

FREV

-z SREV

Signal

Description

-~--~~~~-~--~--~--~~-----~--------~-~---------

----~-----~--~-------~---~--~--~-~--~--~--~---

} Not

} Used

--------~-----.-----~-----------~-------------

Negative

True,

Lamp

Unit

Negative

True,

Hole

Unit

Detected

Negative

True,

Lamp

Unit

Negative

True,

Hole

Unit

Detected

+5V

Supply

-~-.----

Negative

True,

Record

Enable

(Read

E~nable)

Unit

Select

(select

left

unit)

Negative

True,

~rite

Data

(high

writes

flux

north

seeking

pole

direction)

Two

Times

Tachometer

Frequency

Running

(>1

ips

forward

reverse)

Tachometer

frequency

Data

Zero

Crossing

(testing

purposes

onlY)

Gap

Detector

Cartridge

Inserted

Unit

Cartridge

Inserted

Unit

Record

Progress

Negative

True,

Data

Zero

Crossing

Obsolete

(tied

+5V

thru

4.7

kilohms)

Negative

True,

Fast

Forward

Negative

True,

Slow

Forward

Negative

True,

fast

Reverse

Negative

True,

Slow

Reverse

-~--~-------~--

------~---~-------------------~-----~------------------------~-

~~------------~-~----~-----~~---------~------~-----~-~~~-~------~-~-------------

132~5

Cartridge

Tape Module

13255-91032/08

Fev AUG-Ol-16

Table

4.2

Connector

Intormation

for

Read/Write

peA

===============================:================================================

conn~ctor

ana

NO.

==============

-2

-3

-4

-5

-6

-7

-8

-9

-10

-11

-12

-13

-14

Signal

Name

--~-~---~-~-----

-~~----~--------

TCOM

HEAD-

HEAD

GNU

HOLE

+5V

+SV

RET

HEADCT

HEAD+

TGND

Signal

Description

---~--------------~~--~~-~----------~-~--~---~

~------------~-~------~--~---------~~~~~-~~--~

Tacnometer

coil

(common),

D.C.

Level

+2.5V

Not Used

Head

(-)

Signal,

Data

Dependent

Head Ground

Neqatlve

True,

Cartridge

Inserted

Negative

True,

Hole

+5V

Supply

+5V

Return

Negative

True,

Lamp

Head

Center

Tap,

Signal,

Data

Dependent,

Active

Write

Only

Head

(+)

Signal,

Oata

Dependent

Tachometer

Ground

Not Used

Tachometer

Coil,

Signal,

Frequency

Depends

on Motor

Speed

-------------- ---------------- ----------------------------------------------

-1

Motor

(-)

-2

Motor

(+)

-3

Motor

1 ( .. )

-4

Motor

(+)

================================================================================

Other manuals for 13255

Popular Control Unit manuals by other brands

Festo

Festo Compact Performance CP-FB6-E Brief description

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Quick installation guide

JS Automation

JS Automation MPC3034A user manual

JAUDT

JAUDT SW GII 6406 Series Translation of the original operating instructions

Spektrum

Spektrum Air Module System manual

BOC Edwards

BOC Edwards Q Series instruction manual

KHADAS

KHADAS BT Magic quick start

Etherma

Etherma eNEXHO-IL Assembly and operating instructions

PMFoundations

PMFoundations Attenuverter Assembly guide

GEA

GEA VARIVENT Operating instruction

Walther Systemtechnik

Walther Systemtechnik VMS-05 Assembly instructions

Altronix

Altronix LINQ8PD Installation and programming manual

Eaton

Eaton Powerware Series user guide

WAGO

WAGO 750-407/040-000 manual

Sony

Sony CCU-590 Operation manual

Graco

Graco 25D614 instructions

Task Force Tips

Task Force Tips YE-RF-900 Instructions for installation, safe operation and maintenance

Shini

Shini SPV-U Series manual