Haier HPU-40CH03 Manual

Please read this operation manual before using the air conditioner.

No.0150500677

Operation & Installation Manual

CABINET TYPE AIR CONDITIONER

Please keep this manual carefully and safely.

HPU-42CH0

HPU-42HI0

Operation

Content

Cautions

Parts

Operation hints

Energy saving

Maintenance

Trouble shooting

When problems occur

Indoor & outdoor unit connection

Tools necessary

Installation procedures

Others

6 7

9 10

13 18

1 2

Cautions

Disposal of the old air conditioner

Before disposing an old air conditioner

that goes out of use, please make sure

it's inoperative and safe. Unplug the air

conditioner in order to avoid the risk of

child entrapment.

It must be noticed that air conditioner

system contains refrigerants, which

require specialized waste disposal. The

valuable materials contained in a air

conditioner can be recycled. Contact

your local waste disposal center for

proper disposal of an old air conditioner

and contact your local authority or your

dealer if you have any question. Please

ensure that the pipework of your air

conditioner does not get damaged prior

to being picked up by the relevant

waste disposal center, and contribute

to environmental awareness by

insisting on an appropriate, anti

pollution method of disposal.

Disposal of the packaging of your

new air conditioner

All the packaging materials employed

in the package of your new air

conditioner may be disposed without

any danger to the environment.

The cardboard box may be broken or

cut into smaller pieces and given to a

waste paper disposal service. The

wrapping bag made of polyethylene

and the polyethylene foam pads

contain no fluorochloric hydrocarbon.

All these valuable materials may be taken

to a waste collecting center and used again

after adequate recycling.

Consult your local authorities for the name

and address of the waste materials

collecting centers and waste paper

disposal services nearest to your house.

Safety Instructions and Warnings

Before starting the air conditioner, read

the information given in the User's Guide

carefully. The User's Guide contains very

important observations relating to the

assembly, operation and maintenance of

the air conditioner.

The manufacturer does not accept

responsibility for any damages that may

arise due to non observation of the

following instruction.

Damaged air conditioners are not to

be put into operation. In case of doubt,

consult your supplier.

Use of the air conditioner is to be

carried out in strict compliance with the

relative instructions set forth in the User's

Guide.

Installation shall be done by professional

people, don't install unit by yourself.

The machine is adaptive in following

situation

Applicable ambient temperature range:

Cautions

Cooling

Heating

Indoor

outdoor

Rated Maximum Minimum

27 2 18

19 2 14

5 4 10

24 26 6

20 27 15

14.5 -- --

7 24 -7

6 18 --

DB C

WB C

DB C

WB C

Indoor

outdoor DB C

WB C

DB C

WB C

For the purpose of safety, the air

conditioner must be properly grounded

in accordance with specifications.

Always remember to unplug the air

conditioner before opening inlet grill.

Never unplug your air conditioner by

pulling on the power cord. Always grip

plug firmly and pull straight out from

the outlet.

All electrical repairs must be carried

out by qualified electricians.

Inadequate repairs may result in a

major source of danger for the user of

the air conditoiner.

Do not damage any parts of the air

conditioner that carry refrigerant by

piercing or perforating the air

conditioner's tubes with sharp or

pointed items, crushing or twisting any

tubes, or scraping the coatings off the

surfaces. If the refrigerant spurts out

and gets into eyes, it may result in

serious eye injuries.

Do not obstruct or cover the

ventilation grille of the air conditioner.

Do not put fingers or any other things

into the inlet/outlet and swing louver.

Do not allow children to play with the

air conditioner. In no case should

children be allowed to sit on the

outdoor unit.

Specifications

The refrigerating circuit is leak proof.

Parts

1Outlet grill

2Operation panel

3Inlet grill

4Air filter [inside the unit]

Indoor unit

Outdoor unit

Note:For cooling only unit,the "HEATER" light is

invalid;

ON/OFF: If pressing this button,the unit will enter

Auto Run mode according to the room temperature.

POWER RUN TIMER HEATER

ON/OFF

POWER RUN TIMER HEATER

ON/OFF

HPU 42CH03 HPU 42HI03

Remote controller

HEAT

FRESH

HIGH/SO

TIMER

SET

FILTER

HEALTH

RESET LOCK

SLEEP

FAN

TEMP

OFF

SWING

MODE

CLOCK

CODE LIGHT

OFF

1Inlet grill

2Outlet grill

Unit operation

Protection devices inside the unit will activate to stop unit operation, when ambient

temp. is extremely low or high.

When unit is running under high humidity in cooling or dehumidifying mode, condensate

might appear at outlet grill.

3-min delay protection

Fan speed changes

Unit will not restart until 3 min have elapsed for the protection of the unit.

When Fan speed is set at Auto in cooling mode, it will be automatically reduced as

room temp. is approaching temp. setting.

In dry mode, fan speed will change automatically.

Operation hints

Cold draft prevention

Use objectively

efrosting

In heating mode, indoor fan will not run for the first 2 5 min. due to cold draft prevention.

When frost accumulates on heat exchanger in heating mode, unit will start defrosting

automatically.

During defrosting, both indoor and outdoor fan stop.

After defrosting, unit resumes running.

Heat pump works by means of absorbing outside heat to warm room air, so outdoor

temp. degree will affect unit's heating efficiency.

Energy saving

Keep proper room temp.

Too cold or too warm is no good

to your health, and power

consumption will be increased as

well.

Air filter should be periodically cleaned

If air filter is clogged:

It will cause poor cooling and

heating efficiency, higher power

consumption and even problem

may occur. In cooling operation,

water will flow out.

Use Timer effectively

You may use Timer mode to keep

a comfortable room temp.when

you wake up or come home from

outside.

Avoid direct sunlight

and air flow

Adjust air flow

properly

Proper temp.

8:00 5:00

AM PM

ON OFF

Don't spray any paint or insecticide

on the unit.

Don't splash water directly on indoor

unit.

This will cause damage or even fire accident.

This could be

very dangerous

Maintenance

Disconnect power supply Don't touch it with wet

hand

Don't wash with hot water

or solvent to clean the unit

Don't use hot water over 40 C, as this may cause damage to air filter.

Wipe air filter carefully.

Caution:

Pull it out from top as shown in Fig.

Use water or vacuum cleaner to clean it.

If it is extremely dirty, wash it with neutral

detergent or soap water.

Wash it with clean water and install it after

complete dry.

Air filter cleaning

Maintenance

After season maintenance

Before season maintenance

Let the unit run in Fan mode for half a day in a

fine weather to dry completely the unit inside.

Turn off the unit and pull out power plug.

There might be certain power consumption even

if unit is stopped.

Clean air filter and indoor unit, cover outdoor

unit after cleaning.

Check if there are obstacles at inlet and outlet of indoor and outdoor unit,

whick will reduce unit efficiency.

Don't fail to attach air filter after making sure it

is cleaned.

Dust will enter into unit causing damages or

faults if it is running without air filter.

To protect compressor at start, please connect external power supply to

the unit 12 hrs prior to starting. Also please keep the power supply switch

ON during the whole season.

Clean it with warm and wet cloth or with neutral detergent, then wipe it dry with

clean and soft cloth.

If air conditioner is very dirty, clean it with cloth soaked in neutral detergent,then

wipe off the detergent with clean water.

Don't use water higher than 40 C , which will cause discoloring and deformation.

Don't use insecticide or other chemical detergents.

Indoor and outdoor cleaning

Trouble shooting

Followings are not problems

Sound of water flowings are not

problems.

Sound of cracking is heard.

Smells are generated.

During operation, white fog or steam

comes out of indoor unit.

In cooling operation, unit switches to fan

operation.

Unit will not restart after stop.

Won't start?

No outlet air or fan speed can't be changed in

dry mode.

In heating operation, water or

steam are blown out of indoor

unit.

In heating operation, indoor fan won't stop even

if unit is stopped.

During unit start and operation or at stop, a swishing or

gurgling noise may be heard. This noise is generated by

refrigerant flowing in the system.

During unit operation, a cracking noise may be heard.

This noise is generated by the casing expanding or

shrinking because of temperatuer changes.

This is because the system circulates smells from the

interior air such as the smell of cigarettes or the painting

on the unit.

When unit is running at places like restaurant where dense

edible oil fumeis always exist, this will happen.

To prevent frost from accumulating on indoor heat

exchanger, unit will switch to fan operation for a while

then resume cooling operation.

Though ON/OFF button is set to

ON, unit won't resume cooling,dry

or heating operation in 3 min after

it is stopped, this is because of 3

min delay protection circuit.

Unit will reduce fan speed repeatedly and automatically

if room temp. is too low in dry operation.

This occurs when frost

accumulated on the outdoor unit

is removed.

(during defrosting operation)

After unit stops, indoor fan will go on running until indoor

unit cools down.

Please wait 3 minutes

This manual suits for next models

Other Haier Air Conditioner manuals

Haier

Haier HSU-09H03/R Manual

Haier

Haier HSU-07HRA03 User manual

Haier

Haier 10557172 User manual

Haier

Haier EST08XCM User manual

Haier

Haier InoSens MRV SI AU052FPEUA User manual

Haier

Haier AD182AMERA User manual

Haier

Haier HAS09FAAIN User manual

Haier

Haier ESA3063 User manual

Haier

Haier AS072XCEAA User manual

Haier

Haier HSU18VHJ(DB)-W User manual

Haier

Haier HBU-18CF03 Manual

Haier

Haier ADH071M1ERG User manual

Haier

Haier HWR05XCM User manual

Haier

Haier HWR05XCM User manual

Haier

Haier HSU-09LEA13-H - annexe 1 User manual

Haier

Haier HSU-18H03-R User manual

Haier

Haier HSU-18CRA03-T User manual

Haier

Haier HSU-09LEB13-H - annexe 1 User manual

Haier

Haier AS072AZADA User manual

Haier

Haier HWE24VCN User manual

Haier

Haier HPM09XC5 - Portable Air Conditioner User manual

Haier

Haier HSU12VHG-G User manual

Haier

Haier HM-09CB03/R1 User manual

Haier

Haier HW-12C03 User manual

Popular Air Conditioner manuals by other brands

Spheros

Spheros CC 355 instructions

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE owner's manual

Panasonic

Panasonic CS-E12HKEW operating instructions

nedis

nedis ACMB1WT7 quick start guide

Samsung

Samsung AR KV Series User & installation manual

Daikin

Daikin FCFV50A Operation manual

Fujitsu

Fujitsu Inverter ASBA30JFC operating manual

Toshiba

Toshiba RAS-M10SMUV-E installation manual

Daikin

Daikin FXLQ20MAVE Operation manual

Hitachi

Hitachi RAS-E24CAK instruction manual

CIAT

CIAT Magister 2 Series Installation, Operation, Commissioning, Maintenance

Bestron

Bestron AAC6000 instruction manual

Hisense

Hisense 7K Use and Installation Instructions

Frigidaire

Frigidaire FFRE0533S1E0 Use & care guide

Samsung

Samsung AS09HM3N user manual

Frigidaire

Frigidaire CRA073PU11 use & care

Soleus Air

Soleus Air GB-PAC-08E4 operating instructions

McQuay

McQuay MCK020A Technical manual