Extech Instruments IR300UV User manual

USERMANUAL

InfraRedThermometer

Built‐inUVRefrigerantLeakDetectorandFlashlight

ModelIR300UV

Visit us at www.TestEquipmentDepot.com

EXTECHINSTRUMENTS

2 IR300UV‐en‐GB_V1.01/16

Introduction

CongratulationsonyourpurchaseoftheIR300UVIRThermometer.Thisthermometermakes

non‐contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐incoaxial

laserpointerincreasestargetaccuracywhilethebacklitLCDandhandymulti‐switchcombinefor

convenient,ergonomicoperation.TheUVlightsourceisconvenientforlocatingleakssuchas

refrigerants.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,willprovide

yearsofreliableservice.

Features

Measuresnon‐contactsurfacetemperatureupto500°C(932°F)

12:1DistancetoSpotRatio(FieldofView)

AreaandSingle‐pointlasertargeting

DisplayMAX,MIN,AVGorMAX‐MINDifference

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Selectabletemperatureunits(°F/°C)

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

UVleakdetectorwith5UV/BlueLEDs

Brightflashlightwith5WhiteLEDs

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolor

terminal,indicatestheusermustrefertothe

manualforfurtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyes

ofapersonorananimal

oInspectfordamageorforanyshortageofpartsor

accessoriesbeforeuse

oReplacethebatteriesimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethemeasuredtemperaturevaluetoread

muchlowerthantheactualtemperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments

EXTECHINSTRUMENTS

3IR300UV‐en‐GB_V1.01/16

Description



MeterDescription

1. LCDDisplay

2. Multi‐Switchcontrol

3. BatteryCompartment

4. Laserpointer

5. White/BlueLEDs

6. IRsensor

7. Lenscovercontrol

8. MeasurementScanTrigger

DisplayDescription

Laserpointeractiveicon

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimum/Averagetemperatureicons

Batterycapacityindicator

WhiteLEDsactive

Temperatureunits(°F/°C)

TemperatureAlarmicons

UVLEDsactive

Emissivitysetting

EXTECHINSTRUMENTS

4IR300UV‐en‐GB_V1.01/16

Operation

MeterPower

Themeterispoweredbythree1.5VAAbatteries.Withfreshbatteriesinstalled,themeter

switchesONwhenthetriggerispulled.RefertotheMaintenancesectionforBatteryInstallation

instructions.Thebatteryiconprovidesbatterystatusindication.Replacethebatteriesassoonas

thebatterystatusiconindicatesalowbattery.

SettingMode

Thevariousparametersofthemeteraresetusingthefive‐waymulti‐switchlocatedbelowthe

display.Theavailableparametersarelistedbelow:

Flashlight(ONOFF)

UVlight(ONOFF)

TemperatureUnits(°C°F)

Emissivity(0.10to1.00)

Laserpointer(ONOFF)

Max/Min/Avg&Max‐Min(ONOFF)

HILOAlarm(ONOFF)

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Beeper(ONOFF)

SettingModeOverview

TheSettingsswitchhasfivepositionstoselectaparameter,turna

parameterONorOFF,andtoadjustparametervalues.

PressandreleasetheMeasurementTrigger.

PressthebuttonlefttoentertheSettingMode.The

parameterselectedwillappearinthedisplay.

Pressthebuttonrighttoadvancetothenextparameter.

Presstheupordown buttonstochangeaparameterstatusoradjustaparameter

value.

Pressthe buttontostoreparameterchangesandadvancetothenextparameter.

Pressthe buttonlefttoexittheSettingsmodeandreturntoMeasurementmode.

Note:IfnobuttonispressedwithintheAPOtimethemeterwillshutdown.Itmaybehelpful

toextendtheAPOtimewhenmakingadjustmentsintheSettingsmode.

EXTECHINSTRUMENTS

5IR300UV‐en‐GB_V1.01/16

SettingModeDetail

1. FlashlightSetting

EntertheSettingmode.The Flashlighticonflashes.

PressupforONorOFF.Press tostorethesetting

2. UVlightSetting

EntertheSettingmode.AdvanceuntiltheUViconflashes.

PressupforONorOFF.Press tostorethesetting

3. TemperatureUnitsSetting

EntertheSettingmode.Advanceuntilthe°For°Ciconflashes.

Pressuptochangetheunits.Press tostorethesetting

4. EmissivitySetting

EntertheSettingmode.AdvanceuntiltheEMSiconflashes.

Pressupordowntoadjustthesetting.Presstostorethesetting

5. LaserPointerSetting

EntertheSettingmode.Advanceuntiltheiconflashes.

PressupforONorOFF.Press tostorethesetting

6. MaxMinAvgMax‐MinSetting

EntertheSettingmode.AdvanceuntiltheMAX–MINAVGiconflashes.

PressupforONorOFF.Press tostorethesetting

7. AlarmHISetting

EntertheSettingmode.AdvanceuntiltheAlarmHIiconflashes.

PressupordownforONorOFF.Press tostorethesetting

IfONwasselected,Pressupordowntoadjustthelimit.

Presstostorethesetting

8. AlarmLOSetting

EntertheSettingmode.AdvanceuntiltheAlarmLOiconflashes.

PressupordownforONorOFF.Presstostorethesetting

IfONwasselected,Pressupordowntoadjustthelimit.

Presstostorethesetting

9. BacklightSetting

EntertheSettingmode.AdvanceuntiltheLItEiconflashes.

PressupordownforONorOFF.Presstostorethesetting

10. AutoPowerOFFSetting

EntertheSettingmode.AdvanceuntiltheAPOiconflashes.

Pressupordowntoadjustthesetting.Presstostorethesetting

EXTECHINSTRUMENTS

6IR300UV‐en‐GB_V1.01/16

SurfaceTemperatureMeasurements

1. Typicalsettingshouldbe:LaserpointerON,BacklightON,Temperatureunitssetasneeded,

Emissivitysetto0.95,APO(autopowerOFF)setto10secondsandFlashlightONif

measuringinadimlylitarea.

2. Openthelensprotectivelenscoverbyrotatingthe

coverwheelclockwise(facingthelens)untilthedotis

visibleonthewheel.

3. HoldthemeterbyitsHandleGripandpointittoward

thesurfacetobemeasured.

4. PullandholdtheTriggertoturnthemeteronand

begintestinginScanmode.Thedisplaywilllightifthe

batteriesaregood.Replacethebatteriesifthedisplay

doesnotlight.

5. ReleasetheTrigger;thereadingwillHOLDforthetime

setintheAPOsetting.Thebacklightwillturnoffafterapproximately4seconds.

6. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.

LaserPointer

Thelaserpointercircleidentifiestheareabeing

measured.Thesizeoftheareaisdeterminedbythe

distancetospotratio.Objectsoutsidethecircleare

notmeasured.Thespotmeasuredshouldalwaysbe

largerthanthecircleforaccuratemeasurements.

MAX,MIN,AVERAGEandMAX‐MIN

IntheMAXMINAVGmodethemeterwillrecordtheMaximumvaluescanned,Minimumvalue

scanned,theAverageofthescannedvaluesandtheDifferencebetweentheMaxandMinvalue.

1. TurnMaxMinONinthesettingsmode

2. Pressandholdthetriggertoscananarea.Max,Min,AvgorMax‐Min

willbedisplayedinthelowerrightdisplay.Presstheupbuttonto

selecttheparametertobedisplayed.Thevalueswillbecontinuously

updatedforthelengthofthescan.



EXTECHINSTRUMENTS

7IR300UV‐en‐GB_V1.01/16

UVLeakDetector

Injectasmallamountofflorescentdyeintothesystemundertest.Thedye/systemmixture

(refrigerant,forexample)willescapeandaccumulateatallleaksites.TurntheblueUVLEDson

intheSettingmodeandscanthesystem.Theresidueofthedyeattheleakcanbeeasily

observedundertheUVlight.DyesareavailableatmostHVACsupplyoutlets.



LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyond

thetargetandthenscantheentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris60cm(24

inches)fromthetarget(spot),thediameterofthetargetmustbeatleast5cm(2inches).Other

distancesareshownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadefurtherthan60cm(24inches)fromthe

target.Themetercanmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedby

externalsourcesoflight.Inaddition,thespotsizemaybesolargethatitencompassessurface

areasnotintendedtobemeasured.



2.5cm@30cm5cm@60cm10cm@120cm

1”@12”2”@24”4”@48”



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.



EXTECHINSTRUMENTS

8IR300UV‐en‐GB_V1.01/16

Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

HighLowLimits

TheHI/LOlimitsprovideanalarmwhenapresettemperatureisexceeded.

LensCover

Thelenscoverprotectsthelensfromdustwhenthemeterisnotinuse.Alwaysclosethecover

whenstoringthemeter.

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

8. Whenthemeterisheldattheoptimumdistancefromthetarget,thesinglelaserdotwill

appearatthetopofthecircularlasertarget.Aslongasthesinglelaserdotiswithinthe

circularlasertarget,themeterwillmakeanaccuratemeasurement.

EXTECHINSTRUMENTS

9IR300UV‐en‐GB_V1.01/16

Maintenance

Cleaning

Tocleanthelensusecompressedairtocleardustandotherparticles,thencarefullycleanwitha

wetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR300UVinwaterorotherliquid.

ReplacingBatteries

Whenthebatteryiconindicatesalowbattery,orwhenthemeter

doesn’tswitchON,replacethebatteries.

Thebatterycompartmentlidislocatedontherearofthehandle.

RemovetheonePhilipsheadscrewandliftthelidoff.

Replacethethree1.5VAAbatteriesfollowingcorrectpolarityandthen

replaceandsecurethebatterycompartmentlid.

BatterySafetyNotes:Pleasedisposeofbatteriesresponsibly;neverdisposeof

batteriesinafire,batteriesmayexplodeorleak.Ifthemeterisnottobeused

for60daysormore,removethebatteryandstoreseparately.Donotmix

batterytypesorfreshnesslevels;pleaseusebatteriesofthesametypeandofthesamefreshnesslevel.

Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriatecollectionsites,the

retailstorewherethebatterieswerepurchased,orwhereverbatteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotakeend‐of‐life

devicestoadesignatedcollectionpointforthedisposalofelectricalandelectronicequipment.

Specifications

InfraredThermometerSpecifications

Range/Resolution‐30~500oC(‐22~932oF)

Accuracy0°C:±1.5°Cor1.5%ofreading(whicheverisgreater)

32°F:±3°For1.5%ofreading(whicheverisgreater)

‐10°Cto0°C:±2°C

14°to32°F:±4°F

Note:Accuracyisspecifiedfortheambienttemperaturerange:

21~25°C(70~77°F)

ResponseTime500ms(95%ofreading)

Repeatability(%ofreading)±8%ofreadingor±1.0°C(1.8°F)whicheverisgreater

EmissivityAdjustablefrom0.10to1.00

Temp.Coefficient0.1°C/°Cor±0.1%/°Cofreading(whicheverisgreater)

FieldofViewD/S=Approx.12:1ratio(D=distance,S=spot)

LaserpowerLessthan1mW

Spectralresponse8to14microns

EXTECHINSTRUMENTS

10 IR300UV‐en‐GB_V1.01/16

GeneralSpecifications

Display BacklitLCDdisplaywithfunctionindicators

Displayresolution0.1°C(0.2°F)

Flashlight5whiteLEDs

UVlight5blueLEDs

OperatingTemperature 0°Cto50°C(32°Fto122°F)

OperatingHumidity10to90%RHnoncondensing@30°C(86°F)

StorageTemperature ‐20°Cto60°C(‐4°Fto140°F)withoutbattery

OperatingAltitude2000m(7000ft.)abovesealevel

StorageAltitude12,000m(40,000ft.)abovesealevel

DropProof1.2m(4ft.)

PowerSupply3x1.5VAAIECLR06batteries

AutomaticPowerOffAdjustable1to60seconds

Weight 300g(10.6oz.)

Dimensions185x54x104mm(7.3x2.1x4.1”)

VibrationandShockIEC60068‐2‐62,5g,10Hzto200Hz

IEC60068‐2‐2750g,11ms

EMCEN61326‐1:2006EN61326‐2:2006

ComplianceEN/IEC61010‐1

Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176

TestEquipmentDepot.com

Table of contents

Other Extech Instruments Thermometer manuals

Extech Instruments

Extech Instruments IR200 User manual

Extech Instruments

Extech Instruments 42512 User manual

Extech Instruments

Extech Instruments RHT510-NIST User manual

Extech Instruments

Extech Instruments IR301 User manual

Extech Instruments

Extech Instruments SDL200 User manual

Extech Instruments

Extech Instruments 42530 User manual

Extech Instruments

Extech Instruments IRT600 User manual

Extech Instruments

Extech Instruments RH30 User manual

Extech Instruments

Extech Instruments RH200W-T User manual

Extech Instruments

Extech Instruments VIR50-NISTL User manual

Extech Instruments

Extech Instruments RHT510 User manual

Extech Instruments

Extech Instruments 42509 User manual

Extech Instruments

Extech Instruments TM100 User manual

Extech Instruments

Extech Instruments EasyView 10 User manual

Extech Instruments

Extech Instruments 42545 User manual

Extech Instruments

Extech Instruments 42510A User manual

Extech Instruments

Extech Instruments 421501 User manual

Extech Instruments

Extech Instruments 445703 User manual

Extech Instruments

Extech Instruments 445580 User manual

Extech Instruments

Extech Instruments 42570 User manual

Extech Instruments

Extech Instruments IR267 User manual

Extech Instruments

Extech Instruments RH250W User manual

Extech Instruments

Extech Instruments 42540a User manual

Extech Instruments

Extech Instruments RH200W User manual

Popular Thermometer manuals by other brands

Delton

Delton 981A instruction manual

Baker

Baker MM2P instruction manual

Tarmo

Tarmo 320281 manual

Citizen

Citizen CTD 504 instruction manual

TFA

TFA 14.1500 instruction manual

Vive

Vive DMD1010 user manual

Gotemp

Gotemp THB4002 user guide

GREISINGER

GREISINGER G 1202 Quick reference guide

Amprobe

Amprobe TMD-53W user manual

Trotec

Trotec BP10 operating manual

Radiance instruments

Radiance instruments RT616 Series product manual

Eurolec

Eurolec IR151 operating instructions

Scaneo

Scaneo TS42B instruction manual

Sper scientific

Sper scientific 800043 instruction manual

Microlife

Microlife NC 200 Operating instructions manual

Motorola

Motorola MBP69SN General questions

The MeatStick

The MeatStick The MeatStick quick start guide

Hama

Hama TH35-A operating instructions