Emerson Fisher FIELDVUE DVC6200 SIS Configuration guide

www.Fisher.com

Fisher™FIELDVUE™DVC6200 SIS Digital Valve

Controller PST Calibration and Testing using

ValveLink™Software

The test procedure contained in this Instruction Manual Supplement is to be considered as a guideline only and should

be modified to address site‐specific requirements. Use this procedure in conjunction with the DVC6200 Series quick

start guide (D103556X012) and the DVC6200 SIS instruction manual (D103557X012). In addition, exercise good

engineering practices and abide by specific plant safety guidelines for safe operation.

WARNING

This document is not intended to be used as a stand‐alone document. It must be used in conjunction with the following

documents:

Safety Manual for FIELDVUE DVC6200 SIS Digital Valve Controller and Position Monitor (D103601X012)

Fisher FIELDVUE DVC6200 SIS Instruction Manual (D103557X012)

Failure to use this instruction manual supplement in conjunction with the above referenced manuals could result in

personal injury or property damage. If you have any questions regarding these instructions or need assistance in obtaining

any of these documents, contact your Emerson sales office.

For additional information on Partial Stroke Testing and associated parameters refer to Partial Stroke Test Information

on page 19.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

PST Calibration

This document covers the basic PST calibration, as well as details for making adjustments to the normal end, using

Advanced Settings (see figure 11).

Figure 1. Calibration > Partial Stroke

Confirm SIS Tier

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 2. Set Instrument Out of Service and start Partial Stroke Test calibration

Refer to figure 11 for

information on Advanced

Settings

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 3. Enter the Desired Outgoing Ramp Rate

Supports separate ramp

rates for outing and

incoming strokes

Figure 4. Enter the Desired Incoming Ramp Rate

Additional ramp

rates for the

incoming stroke

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 5. Enter the Travel Target Movement

Target Travel Movement is the

percentage of travel from the

normal end

Figure 6. Partial Stroke Calibration progress

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 7. Partial Stroke Calibration progress

Will calibrate to 30% from

the normal end

Figure 8. Configuring SIS Triggers

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 9. Partial Stroke Calibration Progress

Figure 10. Calibration Procedure Complete

List of parameter values

being downloaded to the

device

If you need to make adjustments to the normal end default settings, select Advanced Settings, as shown in figure 11,

and make the necessary adjustments.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 11. Select Advanced Settings to Make Adjustments to the Normal End

Select to define the

normal end

Figure 12. Set Travel High End

Defines the normal end of travel

(where the valve is when the

process is running normally)

The point at which valve

seating occurs will vary slightly

every time. Do not set this

higher than 99.5% or lower

than 0.5%.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 13. Enter Target Travel Movement

Figure 14. Partial Stroke Calibration Progress

Running a PST calibration will enable Short Duration PST. If this is not desired, refer to figure 24 for information on

disabling Short Duration PST.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Configuration

After successfully calibrating the valve for PST go to the Detailed Setup SIS/Partial Stroke tab and verify the values for

the parameters in the Test Configuration group box are correct. Then go to the SIS Options group box and enable any

of the behaviors required for the PST.

Figure 15. Verify Test Configuration and Test Acceptance Criteria

Other manuals for Fisher FIELDVUE DVC6200 SIS

Table of contents

Other Emerson Controllers manuals

Emerson

Emerson TARTARINI FL Series User manual

Emerson

Emerson M200-01200024A10101AB100 User manual

Emerson

Emerson CASH VALVE A-360 Manual

Emerson

Emerson Unidrive M400 User manual

Emerson

Emerson MR98 Series User manual

Emerson

Emerson Hytork XL26 Instruction manual

Emerson

Emerson ET124 Series User manual

Emerson

Emerson XM670 User manual

Emerson

Emerson Site Supervisor User manual

Emerson

Emerson Bettis PressureGuard Manual

Emerson

Emerson FISHER FIELDVUE DLC3010 User manual

Emerson

Emerson Dixell WING XW264K Wiring diagram

Emerson

Emerson Fisher 627 User manual

Emerson

Emerson Unidrive SPM User manual

Emerson

Emerson Tartarini M Series User manual

Emerson

Emerson SI-DeviceNet User manual

Emerson

Emerson FISHER 66 User manual

Emerson

Emerson FPCSK User manual

Emerson

Emerson Fisher 1052 User manual

Emerson

Emerson numatics g3 series User manual

Emerson

Emerson EXD-SH1 User manual

Emerson

Emerson Fisher L2e Configuration guide

Emerson

Emerson Dixell XR20CH Wiring diagram

Emerson

Emerson Dixell IEV12D Wiring diagram

Popular Controllers manuals by other brands

Digiplex

Digiplex DGP-848 Programming guide

YASKAWA

YASKAWA SGM series user manual

Sinope

Sinope Calypso RM3500ZB installation guide

Isimet

Isimet DLA Series Style 2 Installation, Operations, Start-up and Maintenance Instructions

LSIS

LSIS sv-ip5a user manual

Rockwell Automation

Rockwell Automation 1769-L31 installation instructions

Airflow

Airflow Uno hab Installation and operating instructions

ABB

ABB ACS580-01 drives Hardware manual

Panasonic

Panasonic GM1 Series Reference manual

AutoAqua

AutoAqua Smart ATO micro SATO-120P manual

Panasonic

Panasonic FP? Positioning Unit RTEX Technical manual

Samson

Samson Type 5824 Mounting and operating instructions

Alpha IP

Alpha IP MIOB 21001 manual

Siemens

Siemens OpenAir GMA 1 Series Mounting instructions

Surecom

Surecom SR-629 user manual

Fishman

Fishman TriplePlay installation guide

Regulus

Regulus SRS1 T Installation and operation manual

3M MicroTouch EX113 reference guide