Dual XD230M Operating instructions

INSTALLATION/OWNER'S MANUAL

AM/FM/CD/PA Ready Receiver

XD230M

TYPICAL FRONT-LOAD DIN MOUNTING METHOD

Please read entire manual before installation.

Before You Start

•Disconnectnegativebatteryterminal.Consultaqualifiedtechnicianforinstructions.

•Avoidinstallingtheunitwhereitwouldbesubjecttohightemperatures,suchasfrom

directsunlight,orwhereitwouldbesubjecttodust,dirtorexcessivevibration.

Getting Started

•Remove2transitscrewslocated

ontopoftheunit.

•Insertthesuppliedkeysintothe

slotsasshown,andslidetheunit

outofthemountingsleeve.

•Installmountingsleeveinto

opening,bendingtabstosecure.

•Connectwiringharnessand

antenna.Consultaqualified

technicianifyouareunsure.

•Certainvehiclesmayrequirean

installationkitand/orwiring

harnessadapter(soldseparately).

•Testforcorrectoperationandslide

intomountingsleevetosecure.

•Snaptrimringintoplace.

XD230M INSTALLATION

Preparation

XD230M INSTALLATION

Wiring Diagram

FUSE

Whenreplacingthefuse,

makesurenewfuseisthe

correcttypeandamperage.

Usinganincorrectfuse

coulddamagetheradio.

TheXD230Musesone

10ampAGCfuselocated

in-line.

XD230M OPERATION

Control Locations

Eject

Mode

Volume/Audio/Setup

Tune/TrackUp

Loudness

Display

AuxiliaryInput

Local/Distance

Play/Pause

Preset 6

Preset 5

Preset 4

Preset3/Intro

Preset2/Random

Preset1/Repeat

AutoStore/PresetScan

Band

TunerScan

Mute

Tune/TrackDown

Power

1820 17 16 15 14 13 12 11

124 5 67

19 9 8

2122

Power On/Off

Mode

Auxiliary Input

Volume

Programmable

Turn-On Volume

Mute

Preset EQ Curves

Display

Set the Clock

12/24-hour Clock

General Operation

XD230M OPERATION

Press POWERoranyotherbutton(excepteject)toturnthe

uniton.Insertingadiscwillturntheunitonautomatically.

Press POWERtoturntheunitoff.

Press MODEtoselectbetweenTuner,CDplayerand

auxiliaryinput.Modesofoperationareindicatedinthe

display.

Note:CDmodewillnotappearunlessaCDisinserted.

Insert3.5mmplugtoconnecttheheadphoneorlineoutput

fromyourportableaudiodevice.

Adjustvolumeusingrotaryencoder(00-46).

Tosettheturn-onvolumelevel,pressandholdPOWER

for3secondstostorethecurrentlyselectedvolumelevel

inmemory."P-VOL"andthecurrentvolumelevelwill

momentarilyappearinthedisplay.Ifnovolumelevelis

programmed,theunitwillrememberthelastvolumelevel.

Press MUTEtosilencetheaudio.“MUTE”willflashinthe

display.PressMUTEagaintocancel.

Press EQ toselectbetweenPOP,JAZZ,CLASSIC,BEAT,

ROCKandOFF(default)equalizationcurves.Anyadjustment

totheBassorTreblesettingsautomaticallycancelsthe

currentEQcurve(ifoneisselected).

Press DISPtoselectbetweenclockanddifferenttypesof

information,suchasradiofrequencyortheCDtrack/elapsed

time information.

FromTunerorCDmode,pressandholdDISPuntiltheclock

beginstoflash,thenrelease.PressTUNE

toadjust

thehoursandTUNE

toadjusttheminutes.PressDISP

momentarilytosavetheselectedtime.

Theclockwilldisplay12-hourtimeinUSAfrequencyspacing

mode(10:00).InEuropeanfrequencyspacingmode,theclock

willdisplay24-hourtime(22:00).

PressvolumeknobmomentarilytoselectbetweenVolume

(default),Bass,Treble&Balance.

PressvolumeknobuntilBASappearsthenrotateencoder

left/righttoadjust(-6minimum/+6maximum).

PressvolumeknobuntilTREappearsthenrotateencoder

left/righttoadjust(-6minimum/+6maximum).

PressvolumeknobuntilBALappearsthenrotateencoder

left/righttoadjust(BALL12-BAL00-BALR12).

BAL00representsequalbalance

IndividualBassandTreblesettingsareretainedinmemoryfor

Tuner,CDandAUXmodes.ThisallowsyoutosavetheBass

andTreblesettingsseparatelyforeachmode.

Note:

AnyadjustmenttotheBassorTreblesettingsautomatically

cancelsthecurrentEQcurve(ifoneisselected).

Pressandholdthevolumeknobformorethan3secondsto

accessthesetupmenu.Pressthevolumeknobmomentarilyto

selectbetweenthemenufunctionsandrotatethevolumeknob

left/righttoadjustoractivatethedesiredfunction.

Audio

Bass

Treble

Balance

Source Audio Memory

Setup Menu

XD230M OPERATION

General Operation

Setup Menu

Menu Function Options Action

Tuner Frequency

Spacing

FREQUSA ProgramstheunittoUSAtunerspacing.

(200kHzforFMand10kHzforAM)

FREQEUR ProgramstheunittoEuropeantunerspacing.

(50kHzforFMand9kHzforAM)

Beep

Confirmation

BEEPOFF Disablestheconfirmationbeep.

BEEPON Enablestheconfirmationbeep.

XD230M OPERATION

Press TUNE

or TUNE

momentarilytomoveradio

frequencyupordownonestepatatime.Pressandholdto

advancequickly.

Press TUNE

or TUNE

foronesecond,then

releasetoseekthenextstrongeststation.

Press SCANtopreviewstrongstationsonthecurrentband,

pausingforfivesecondsateach.PressSCANagainto

cancel.

Press BANDtoselectbetweenFM1,FM2,FM3,AM1and

AM2bands.

Upto18FMstationsand12AMstationscanbestored.To

storeastation,selectthedesiredbandandstation.Press

andholdthedesiredpresetbutton(1-6)formorethan

twoseconds.Whenstored,thepresetnumberwillappearin

thedisplay.Thestationcanberecalledanytimebypressing

thecorrespondingpresetbutton.

Press AS/PSformorethantwosecondstoautomatically

storethesixstrongeststationsinthecurrentband.

Automaticlocaltuningisactivatedduringtheinitialband

scan.

Press AS/PSforlessthantwosecondstoscanpresets1-6

onthecurrentband,pausingforfivesecondsateach.Press

AS/PSagaintocancel.

Thisunithasamanualtuning,seektuningandAS/PS

lockoutfeature.Seetroubleshootingsection.

Manual Tuning

Seek Tuning

Scan Tuning

Band

Storing and Recalling

Station Presets

Automatically Store

Stations

Preset Scan

NOTE:

AM/FM Tuner Operation

XD230M OPERATION

Insert CD

Eject CD

Track Select

Fast Forward and Reverse

Pause

Scan

Repeat

Random

CD-R/CD-RW Compatibility

Withthelabelfacingup,insertastandardsizeCDintothe

CDslot.TheCDwillautomaticallybeginplayback.

Press EJECTtoejecttheCD.Theunitwillchangetoprevious

modeofoperation(TunerorAUX).Ifthediscisnotremoved

within10seconds,theunitwillreloadthedisc.Theunitdoes

nothavetobeturnedontoejectCD.NOTE:Thisunithasan

EjectCDlockoutfeature.Seetroubleshootingsection.

Press TRACK

toskiptothebeginningofthenexttrack.

Press TRACK

toreturntothebeginningofthecurrent

track.PressingTRACK

againskipstothebeginningof

theprevioustrack.

PressandholdTRACK

or TRACK

tofastforward

orreverseatrack.

Press

totemporarilystopCDplayback.

Press

againtoresumeplayback.

Press INT toplaythefirst10secondsofeachtrack.

Press INTagaintocancel.

Press RPTtocontinuouslyrepeatselectedtrack.

Press RPTagaintocancel.

Press RDMtoplayalltracksinrandomorder.PressRDM

againtocancel.Randommodeisretainedinmemorywhen

selectingbetweenTuner,CDandAUXmodesandwhenthe

unitisturnedon/off.

SomeCD-RsandCD-RWsmaybeincompatiblewiththis

unit,dependingonmediatypeandrecordingmethod.In

addition,thefollowingCDsmaybeincompatiblewiththis

unit:

CDsexposedtoextremetemperaturesordirectsunlightfor

extendedperiodsoftime,CDsrecordedinwhicharecording

sessionfailedorare-recordingwasattemptedand,or

encryptedorcopy-protectedCDswhichdonotconformto

theaudioCD-DAredbookrecordingstandard.

CD Player Operation

XD230M OPERATION

FCC Compliance

ThisdevicecomplieswithPart15oftheFCCRules.Operationissubjecttothefollowing

twoconditions:

(1)thisdevicemaynotcauseharmfulinterference,and

(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethatmay

causeundesiredoperation.

Warning:Changesormodificationstothisunitnotexpresslyapprovedbytheparty

responsibleforcompliancecouldvoidtheuser’sauthoritytooperatetheequipment.

Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassB

digitaldevice,pursuanttoPart15oftheFCCRules.Theselimitsaredesignedtoprovide

reasonableprotectionagainstharmfulinterferenceinaresidentialinstallation.This

equipmentgenerates,usesandcanradiateradiofrequencyenergyand,ifnotinstalled

andusedinaccordancewiththeinstructions,maycauseharmfulinterferencetoradio

communications.However,thereisnoguaranteethatinterferencewillnotoccurina

particularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioor

televisionreception,whichcanbedeterminedbyturningtheequipmentoffandon,the

userisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing

measures:

• Reorientorrelocatethereceivingantenna.

• Increasetheseparationbetweentheequipmentandreceiver.

• Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthe

receiverisconnected.

• Consultthedealeroranexperiencedradio/TVtechnicianforhelp.

Problem Cause Action

Unit will not turn on

(no power)

Yellowwirenotconnectedorincorrectvoltage

Redwirenotconnectedorincorrectvoltage

Checkconnectionsforproper

voltage(11~16VDC)

Blackwirenotconnected Checkconnectiontoground

Fuseblown Replacefuse

Unit has power

(but no sound)

Speakerwiresnotconnected Checkconnectionsatspeakers

Oneormorespeakerwirestouchingeach

otherortouchingchassisground

Insulateallbarespeakerwiresfrom

eachotherandchassisground

Unit blows fuses

Yelloworredwiretouchingchassisground Checkforpinchedwire

Speakerwirestouchingchassisground Checkforpinchedwire

Incorrectfuserating Usefusewithcorrectrating

Unit will not tune, seek or

autostore (AS/PS) stations

UnithasManualTuningLockoutfeature

enabled

Seeyoursupervisorforthecode

Excessive skipping

Unitisnotmountedcorrectlyorbackstrapis

notsecure

Checkmountingsleeveand

backstrapsupport

Physicaldefectinmedia(CD,CD-RorCD-RW) Checkmediaforscratches

ERROR 1 appears

on display

Discreaderror Press EJECT

ERROR 2 appears

on display

Focuserrorordiscisinupsidedown Press EJECT

Unit will not accept

a disc

CDmechanismpositionoutofalignment PressandholdEJECT

for3seconds

toresetCDmechanismposition

CDtransitscrewsstillinplace Remove2transitscrewslocatedon

topoftheunit

Unit will not eject

a disc

UnithasEjectCDLockoutfeatureenabled Seeyoursupervisorforthecode

XD230M OPERATION

Troubleshooting

CEA-2006PowerStandardSpecifications

(reference:14.4VDC+/-0.2V,20Hz~20kHz)

PowerOutput:18WattsRMSx4channelsat4ohmsand<1%THD+N

SignaltoNoiseRatio:80dBA(reference:1wattinto4ohms)

Table of contents

Other Dual Car Receiver manuals

Dual

Dual XDVDN8190N Operating instructions

Dual

Dual DVM179 Operating instructions

Dual

Dual XDMAR6720 Operating instructions

Dual

Dual XDVDN8190 Operating instructions

Dual

Dual XDM270 Operating instructions

Dual

Dual DMCPA70BT Operating instructions

Dual

Dual XDMA6415 Operating instructions

Dual

Dual DC206BT Operating instructions

Dual

Dual DSA1035 User manual

Dual

Dual XDM290BT Operating instructions

Dual

Dual XDMA6415 Operating instructions

Dual

Dual XDMA6510 Operating instructions

Dual

Dual XDVD1170 Operating instructions

Dual

Dual XHD6425 Operating instructions

Dual

Dual SD XDMA6370 Operating instructions

Dual

Dual DCPA101 Operating instructions

Dual

Dual XDMA450 User manual

Dual

Dual XD5250 Operating instructions

Dual

Dual DXDM227BT Operating instructions

Dual

Dual MCD139BT Operating instructions

Dual

Dual XD1215 Operating instructions

Dual

Dual XHD7714 - V3 Operating instructions

Dual

Dual DV725BH Operating instructions

Dual

Dual XDMA6855 Operating instructions

Popular Car Receiver manuals by other brands

Motorola

Motorola VWA63 Service manual

Nextar

Nextar D3201 instruction manual

Alpine

Alpine CDE-163BT owner's manual

Pioneer

Pioneer DEH-P645R installation manual

Axxera

Axxera XDMA7600 Installation & owner's manual

XM OnyX quick start guide

Sound Storm

Sound Storm STM93R user manual

Soundstream

Soundstream VIR-5000 owner's manual

Avson

Avson MKT Platform user manual

Sony

Sony MEX-1HD - Audio Library System operating instructions

Pioneer

Pioneer DVH-P500UB Operation manual

JVC

JVC KD-AHD69 Specifications

Blaupunkt

Blaupunkt SANTIAGO CR 87 operating instructions

Sony

Sony CDX-4160 - Cd Receiver operating instructions

XFIRE AUDIO

XFIRE AUDIO BMW42S owner's manual

VDO

VDO CD 2253 datasheet

Volvo

Volvo 13 84 580 installation instructions

ZENEC

ZENEC ZE-160DVD instruction manual