Daikin FTE09MV2S User manual

REMOVAL

PROCEDURE

SERVICE MANUAL

Indoor Unit

Non-Inverter

Wall Mounted Type

9000/12000 Btu/h Class

Si041138

Service Manual

Removal Procedure

Indoor Unit

Applicable Models

zCooling Only

FTE09MV2S

FTE12MV2S

Si041138

Removal Procedure 1

Table of Contents

1. Removal of Air Filters..............................................................................2

2. Removal of Front Panel ..........................................................................4

3. Removal of Front Grille ...........................................................................5

4. Removal of Horizontal Blades / Vertical Blades......................................8

5. Removal of Electrical Box .....................................................................11

6. Removal of PCBs..................................................................................14

7. Removal of Drain Pan Unit / Swing Motor.............................................19

8. Removal of Fan Motor...........................................................................23

9. Removal of Indoor Heat Exchanger......................................................25

10.Removal of Fan Rotor ...........................................................................28

Note: The illustrations may be slightly different depending on the model.

Removal of Air Filters Si041138

2Removal Procedure

1. Removal of Air Filters

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Appearance features

Warning

Dangerous: High voltage

A high voltage is applied to all

the electric circuits of this

product including

thermistors.

When the signal receiver

catches a signal from the

remote controller, the

receiving tone sounds and

the operation lamp blinks

immediately to confirm the

signal reception.

When the [ON/OFF] button

is kept pressed for 5

seconds, the forced cooling

operation is performed for

about 15 minutes.

2. Remove the air filters.

Open the front panel to

the position where it

stops.

Slightly push up the

center knob of the air

filter and unfasten the

hooks.

Pull out the air filter

downward and remove

it.

The air filter is not marked

for difference between the

right and left sides.

Insert the air filter with the

"FRONT" mark faced up.

The air filter can be set

easily by inserting it along

the guides.

Be sure to insert the hooks

(at 2 lower positions) when

mounting the air filter.

(R12544)

(R15463)

[ON/OFF] button

Operation lamp

TIMER lamp

Signal receiver

Room temperature

thermistor

(R4846)

Front panel

(R4847)

Air filter

Si041138 Removal of Air Filters

Removal Procedure 3

3. Remove the Titanium

apatite photocatalytic air-

purifying filters.

1The Titanium apatite

photocatalytic air-

purifying filter ASSY is

attached to the back of

the air filter.

The right and left filters are

interchangeable.

Remove the Titanium

apatite photocatalytic

air-purifying filter ASSY

by bending the air filter

and releasing the

projections from the air

filter frame.

Remove the Titanium

apatite photocatalytic

air-purifying filter from

its frame (at 5 positions)

by bending it.

Step Procedure Points

Air filter

(R4309)

Titanium apatite

photocatalytic

air-purifying filter

ASSY

Projection

(R4310)

(R13174)

Removal of Front Panel Si041138

4Removal Procedure

2. Removal of Front Panel

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1Open the front panel

over the position where

it stops.

2Slide the left rotary

shaft to the right and

release it.

Slide the right rotary

shaft to the left and

release it.

Remove the front panel.

When reassembling the front

panel, fit the right and left

rotary shafts one by one into

the grooves and fully push

them in position.

(R4849)

Rotary shaft

(R4313)

(R4315)

Front panel

(R4850)

Si041138 Removal of Front Grille

Removal Procedure 5

3. Removal of Front Grille

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Remove the service

cover.

Preparation

Remove the front panel

according to the “Removal of

Front Panel.”

1Remove the screw of

the service cover.

Pull out the service

cover diagonally down

in the direction of the

arrow.

The figure shows the

inside.

You can remove the front

grille without detaching the

service cover.

2. Remove the front grille.

1Open the horizontal

blades.

(R4851)

Service cover

(R4852)

(R4853)

(R4854)

Horizontal blade

Removal of Front Grille Si041138

6Removal Procedure

Remove the screw

covers. (right and left)

Remove the 2 screws.

(right and left)

The front grille has 3

hooks at the top.

Unfasten the left hook.

When mounting the indoor

unit, drive the screws with

the horizontal blades open or

removed.

The convex marks (...) on

the front panel indicate the

position of the hooks.

Step Procedure Points

Hook

(R4321)

(R12769)

(R4324)

Screw cover

(R4855)

Front grille (R12715)

Si041138 Removal of Front Grille

Removal Procedure 7

Unfasten the center

hook.

Unfasten the right hook.

Pull the upper part of

the front grille out and

lift the lower part up,

and then remove the

front grille.

When reassembling the front

grille, make sure that the 3

hooks are fastened as they

were.

When reassembling the front

grille, be sure not to get it

stuck on the spacer of the

drain pan.

Step Procedure Points

(R4325)

(R4326)

(R12545)

Spacer

(R4856)

Front grille

Spacer

Section View

(R4590)

Removal of Horizontal Blades / Vertical Blades Si041138

8Removal Procedure

4. Removal of Horizontal Blades / Vertical Blades

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Remove the horizontal

blade (large).

Open the horizontal

blade (large).

Unfasten the center

shaft while bending the

horizontal blade (large)

slightly.

Unfasten the left shaft.

Unfasten the right shaft.

Mount the large horizontal

blade to the upper position

and the small horizontal

blade to the lower position.

Do not put them in the wrong

place.

There is a key alignment at

the right shaft. When

mounting, insert the right

shaft first while turning.

After inserting the right shaft,

mount the horizontal blade to

the center shaft and then to

the left shaft.

(R4857)

Horizontal blade (large)

Horizontal blade (small)

(R4329)

(R4330)

Key alignment

(R12734)

This manual suits for next models

Table of contents

Other Daikin Air Conditioner manuals

Daikin

Daikin FTXJ20A2V1BW User manual

Daikin

Daikin FXMQ07PVJU User manual

Daikin

Daikin RXP25N5V1B9 User manual

Daikin

Daikin ACQ71C/AZQS71BV1 Instruction manual

Daikin

Daikin FTXP35L5V1B User manual

Daikin

Daikin R25GV1G User manual

Daikin

Daikin FTXM09VVJU User manual

Daikin

Daikin RZR36PVJU User manual

Daikin

Daikin LREQ5B7Y1 User manual

Daikin

Daikin FCAG35BVEB User guide

Daikin

Daikin FXAA15AUV1B User guide

Daikin

Daikin SUPER MULTI NX CTXS07LVJU User manual

Daikin

Daikin RM13NV2S User manual

Daikin

Daikin ARXM25M3V1B9 User manual

Daikin

Daikin VRV FXCQ20M7V1B User manual

Daikin

Daikin RXL20J2V1B User manual

Daikin

Daikin FTX20JV FTX25JV FTX35JV Instruction manual

Daikin

Daikin FTXS-K Instruction manual

Daikin

Daikin Altherma 3 RW User manual

Daikin

Daikin ATXF25A5V1BB User manual

Daikin

Daikin GTKJ35TV16UZ User manual

Daikin

Daikin BRC7EA618 User manual

Daikin

Daikin Multi+ R32 Split Series How to use

Daikin

Daikin VRVIII Instruction manual

Popular Air Conditioner manuals by other brands

Spheros

Spheros CC 355 instructions

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE owner's manual

Panasonic

Panasonic CS-E12HKEW operating instructions

nedis

nedis ACMB1WT7 quick start guide

Samsung

Samsung AR KV Series User & installation manual

Fujitsu

Fujitsu Inverter ASBA30JFC operating manual

Toshiba

Toshiba RAS-M10SMUV-E installation manual

Hitachi

Hitachi RAS-E24CAK instruction manual

CIAT

CIAT Magister 2 Series Installation, Operation, Commissioning, Maintenance

Bestron

Bestron AAC6000 instruction manual

Hisense

Hisense 7K Use and Installation Instructions

Frigidaire

Frigidaire FFRE0533S1E0 Use & care guide

Samsung

Samsung AS09HM3N user manual

Frigidaire

Frigidaire CRA073PU11 use & care

Soleus Air

Soleus Air GB-PAC-08E4 operating instructions

McQuay

McQuay MCK020A Technical manual

Webasto

Webasto Frigo Top 25 DS Instructions for use

Frigidaire

Frigidaire FAZ12ES2A installation instructions