Cashco 5300P Instruction manual

MODELS 5300P

AIR FILTER REGULATOR

SECTION I

These regulators are designed for air service only. Maximum allowable inlet pressure is 290 psi. Operating

temperatures are -20° to 180° F. The 5300P has low capacity internal relief which provides very limited down

stream over pressure protection. Note: Non-relieving version does not provide internal relief. To avoid exceeding

outlet pressure limits in service, a pressure-relieving or pressure-limiting device should be provided.

I. DESCRIPTION AND SCOPE

II. INSTALLATION

SECTION II

INSTALLATION, OPERATION & MAINTENANCE MANUAL (IOM) IOM-5300P

04-16

Install the regulator as close as possible to the instrument or tool it is to service. Clean all pipelines to remove dirt

and scale prior to installation. The words "IN" and "OUT" are cast into the body to indicate the direction of flow. For

best filter drainage, orient the drain valve so that it is at the lowest point on the drip well housing. The exhaust port

should be kept free and unplugged. Position the regulator so the vent is at the lowest point possible, or provide

additional protection to prevent contaminants from entering the regulator. Rotating the bonnet relative to the body may

change the vent hole orientation. Exhaust may be remotely vented by installing tubing to the 1/8" NPT port. Apply pipe

compound or sealing tape to the male pipe threads prior to installing regulator. Use caution to prevent the sealant

from getting inside the regulator.

ISO Registered Company

III. PRINCIPLE OF OPERATION

SECTION III

Prior to turning on supply air, back off adjusting screw until there is no compression of the range spring. After turning

supply pressure on, turn the adjusting screw clockwise to increase outlet pressure. Tighten locknut to maintain

desired pressure setting.

IV. MAINTENANCE

SECTION IV

1. To remove condensate, slowly open drain valve and bleed accumulated liquid.

2. To clean filter element

a. Shut off supply air.

b. Drain condensate.

c. Remove four corner bolts from bottom of unit.

d. Remove drip well housing and filter.

e. Clean parts and reassemble in reverse order.

IOM-5300P

WARNING

These products are intended for use in industrial

compressed-air systems only. Do not use these products

where pressures and temperatures can exceed those

listed under specifications.

Before using these products with fluids other than air,

for non-industrial applications, life-support systems, or

other applications not within published specifications,

consult factory.

5300P Instrument Air Filter Regulator

The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not to be

construed as warranties or guarantees, express or implied, regarding the products or services described herein or their use or applicability. We reserve the right

to modify or improve the designs or specifications of such product at any time without notice.

Cashco, Inc. does not assume responsibility for the selection, use or maintenance of any product. Responsibility for proper selection, use and maintenance of any

Cashco, Inc. product remains solely with the purchaser.

Cashco, Inc.

P.O. Box 6

Ellsworth, KS 67439-0006

PH (785) 472-4461

Fax. # (785) 472-3539

www.cashco.com

email: [email protected]

Printed in U.S.A. IOM-31-N

Cashco GmbH

Handwerkerstrasse 15

15366 Hoppegarten, Germany

PH +49 3342 30968 0

Fax. No. +49 3342 30968 29

www.cashco.com

email: [email protected]

Cashco do Brasil, Ltda.

Al.Venus, 340

Indaiatuba - Sao Paulo, Brazil

PH +55 11 99677 7177

Fax. No.

www.cashco.com

email: [email protected]

Table of contents

Other cashco Controllers manuals

cashco

cashco D Instruction manual

cashco

cashco DA6 Instruction manual

cashco

cashco 4381 Instruction manual

cashco

cashco BQ Instruction manual

cashco

cashco DA1 Instruction manual

cashco

cashco 48 Series Instruction manual

cashco

cashco BQ Instruction manual

cashco

cashco 8310HP-1+8 Instruction manual

cashco

cashco HP Instruction manual

cashco

cashco 3381 Instruction manual

cashco

cashco 6987 Owner's manual

cashco

cashco DA8 Instruction manual

cashco

cashco 8310HP Instruction manual

cashco

cashco P5 Instruction manual

cashco

cashco ALR-1 Instruction manual

cashco

cashco 123-1+6+S Instruction manual

cashco

cashco PTR-1 Instruction manual

cashco

cashco D Instruction manual

cashco

cashco P7 Instruction manual

cashco

cashco POSR-1 Instruction manual

cashco

cashco SLR-2 Instruction manual

cashco

cashco POSR-2 Instruction manual

cashco

cashco C-PRV Instruction manual

cashco

cashco 8311LP Instruction manual

Popular Controllers manuals by other brands

Digiplex

Digiplex DGP-848 Programming guide

YASKAWA

YASKAWA SGM series user manual

Sinope

Sinope Calypso RM3500ZB installation guide

Isimet

Isimet DLA Series Style 2 Installation, Operations, Start-up and Maintenance Instructions

LSIS

LSIS sv-ip5a user manual

Rockwell Automation

Rockwell Automation 1769-L31 installation instructions

Airflow

Airflow Uno hab Installation and operating instructions

ABB

ABB ACS580-01 drives Hardware manual

Panasonic

Panasonic GM1 Series Reference manual

Emerson

Emerson SW93 owner's manual

AutoAqua

AutoAqua Smart ATO micro SATO-120P manual

Panasonic

Panasonic FP? Positioning Unit RTEX Technical manual

Samson

Samson Type 5824 Mounting and operating instructions

Alpha IP

Alpha IP MIOB 21001 manual

Siemens

Siemens OpenAir GMA 1 Series Mounting instructions

Surecom

Surecom SR-629 user manual

Fishman

Fishman TriplePlay installation guide

Regulus

Regulus SRS1 T Installation and operation manual

cashco 5300P Instruction manual

Popular Controllers manuals by other brands