Brinkmann Portable Tabletop Grill User manual

OWNER’S MANUAL / MANUAL DEL PROPIETARIO

WARNING/ADVERTENCIA

HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS

ARE IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS

MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE.

SE PUEDE PRODUCIR UNA EXPLOSIÓN PELIGROSA SI SE HACE CASO OMISO A

ESTAS ADVERTENCIAS E INSTRUCCIONES. LEA Y SIGA TODAS LAS ADVERTENCIAS

E INSTRUCCIONES EN ESTE MANUAL PARA EVITAR LESIONES PERSONALES,

INCLUSO LA MUERTE, O LOS DAÑOS MATERIALES.

ASSEMBLY AND OPERATING INSTRUCTIONS

INSTRUCCIONES DE ARMADO Y OPERACIÓN

KEEP THIS MANUAL FOR FUTURE REFERENCE

GUARDE ESTE MANUAL PARA REFERENCIA FUTURA

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS

WITH THE GRILL OWNER FOR

FUTURE REFERENCE.

AVISO PARA EL

INSTALADOR:

ENTREGUE ESTAS

INSTRUCCIONES AL

PROPIETARIO DE LA PARRILLA

PARA REFERENCIA FUTURA.

Portable Tabletop Grill

Parrilla Portátil de Mesa

Model Number: 810-1100-S

THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR

ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL.

THIS INSTRUCTION MANUAL CONTAINS IMPORTANT INFORMATION NECESSARY

FOR THE PROPER ASSEMBLY AND SAFE USE OF THE APPLIANCE.

READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS

BEFORE ASSEMBLING AND USING THE APPLIANCE.

FOLLOW ALL WARNINGS AND INSTRUCTIONS WHEN USING THE APPLIANCE.

IMPORTANT SAFETY

WARNINGS

IF YOU SMELL GAS:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, keep away from the appliance and immediately call your gas

supplier or your fire department.

Failure to follow these instructions could result in fire or explosion which could

cause property damage, personal injury or death.

1. Never leave this appliance unattended while in use.

2. Never operate this appliance within 10 ft (3.0 m) of any structure, combustible

material or other gas cylinder.

3. Never operate this appliance within 25 ft (7.5 m) of any flammable liquid.

4. Heated liquids remain at scalding temperatures long after the cooking process.

Never touch cooking appliance until liquids have cooled to 115 ºF (45 ºC) or less.

5. If a fire should occur, keep away from the appliance and immediately call your fire

department. Do not attempt to extinguish an oil or grease fire with water.

Failure to follow these instructions could result in fire or explosion which could

cause property damage, personal injury or death.

DANGER

General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Installation and LP Cylinder Specifications and Safe Use. . . . . . . . . . . . . . . . 4

Leak Testing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Pre-start Check List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Lighting Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7

Operating Grill and Helpful Hints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8

Proper Care and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10

Transporting and Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-11

Trouble Shooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Frequently Asked Questions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-13

Parts List and Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-16

Warranty Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Cover

TABLE OF CONTENTS

DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING: Be alert to the possibility of serious bodily injury if the instructions are not followed. Be sure to read and

carefully follow all of the messages.

CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

FOR COVERS & ACCESSORIES AND OTHER PRODUCTS, PLEASE VISIT US ONLINE AT:

WARNING

This product contains chemicals, including lead in the brass of certain component parts, that are

known to the State of California to cause cancer, and birth defects or other reproductive harm.

Wash hands after handling. When used, this product emits fuel combustion chemicals that are

known to the State of California to cause cancer, and birth defects or other reproductive harm.

Follow all instructions in this manual and use only in well ventilated, outdoor area.

WARNING

• Never use natural gas in a unit designed for liquid propane gas.

• Never use charcoal or wood briquets in a gas grill. Flavoring chips must be contained in a metal

smoking box to contain ash and prevent fires.

• Leak test all connections before first use, even if grill was purchased fully assembled and after

each tank refill.

• Never check for leaks using a match or open flame.

CAUTION: Strong odors, colds, sinus congestion, etc. may prevent the detection of propane.

Use caution and common sense when testing for leaks.

• Always keep your gas grill free and clear of gasoline, lighter fluid, paint thinner, or other

flammable vapors and liquids or combustible materials.

• Always check the grill prior to each use as indicated in the "Pre-Start Check List" section of this

manual.

• DO NOT obstruct the flow of combustion or ventilation air.

• Keep children and pets away from hot grill. DO NOT allow children to use or play near this grill.

• DO NOT leave the grill unattended while in use.

• Keep any electrical supply cords away from water or heated surfaces.

• Keep a type BC or ABC fire extinguisher on hand acceptable for use with gas products. Refer to

your local authority to determine proper size and type.

• In the event of an oil or grease fire do not attempt to extinguish with water.

• For household use only. DO NOT use this grill for anything other than its intended purpose.

• DO NOT use while under the influence of drugs or alcohol.

• This appliance is not intended for and should never be used as a heater.

• DO NOT use any other regulator assembly other than the one supplied with your grill. Replacement

regulator assembly must be part No 155-1100-0, which can be obtained by contacting customer

service at 800-527-0717.

• This appliance is not intended for commercial use.

• Grill is hot when in use. To avoid burns:

• DO NOT attempt to move the grill.

• Wear protective gloves or oven mitts.

• DO NOT touch any hot grill surfaces.

• DO NOT wear loose clothing or allow hair to come in contact with grill.

USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GAS GRILL.

FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL

COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

GENERAL WARNINGS

WARNING

INSTALLATION INFORMATION:

The installation of this appliance must be in accordance with:

All applicable local codes, or in the absence of local codes, either:

• National Fuel Gas Code ANSI Z223.1 NFPA 54

• Natural Gas and Propane Installation Code: CAN/CGA B149.1

• Natural Gas Installation Code: CAN/CGA B149.1 (Canada)

• Propane Installation Code: CAN/CGA B149.2 (Canada)

To check your local codes, see your local LP gas dealer or natural gas company. This grill was not

intended to be connected to a natural gas supply line. If an external electrical source is utilized, it

must be electrically grounded in accordance with local codes, or in the absence of local codes, with

the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical Code, CSA 22.1.

The LP-gas supply cylinder to be used must be constructed and marked in accordance with the

specifications for LP-gas cylinders, U.S. Department of Transportation (DOT) or the Standard for

Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA-B339.

• FOR OUTDOOR USE ONLY. DO NOT operate indoors or in an enclosed area such as a garage, shed

or breezeway.

• Use your grill OUTDOORS in a well ventilated space away from dwellings or other buildings to

prevent dangers associated with gas accumulation and toxic vapors. Although minimum clearance is

36 inches (91 cm), we strongly recommend that you do not operate this appliance within 10 ft. (3.0 m)

of any structure, combustible material or extra LP gas cylinders not attached to the appliance. Not

adhering to these clearances will prevent proper ventilation and may increase the risk of a fire and/or

property damage, which could also result in personal injury.

• Maintain a minimum clearance of 36 inches (91 cm) between all sides of grill, deck railings, walls or

other combustible material. DO NOT use grill under overhead unprotected combustible construction.

• DO NOT use or install this grill in or on a recreational vehicle and/or boat.

INSTALLING THE LP GAS CYLINDER ONTO THE GRILL:

NOTE: Your grill is designed to operate with a 16.4 oz (DOT 39 cylinder) that is about 7 3/8” high.

1. Check that the regulator control valve is off.

2. Hand tighten propane cylinder to regulator control valve.

3. Attach regulator to grill. Hand tighten securely.

a) DO NOT store a spare LP gas cylinder under or near this appliance.

b) Never fill the cylinder beyond 80% full.

c) If the information in (a) and (b) are not followed exactly, a fire causing death or

serious injury may occur.

DANGER

Step 1

Assemble grill per "Assembly

Instructions" on page 14 of this

manual. Make sure regulator control

knob is in "OFF" position. Attach the

propane canister to the regulator.

Step 2

Prepare a soapy water solution (one

part dishwashing liquid to three parts

water) to test for gas leaks in the

connections. Apply a generous

amount of the soapy mixture to the

regulator assembly at the propane

canister (located on the right side of

grill).

Step 3

With the regulator control knob in

the "OFF" position, check for

bubbles where propane canister

attaches to regulator assembly. If

soapy mixture starts bubbling, gas is

leaking through the connections.

Disconnect the propane canister.

Retighten the connection that is

leaking gas. Repeat procedure with

soapy mixture until gas no longer

leaks. NEVER USE A FLAME TO

CHECK FOR GAS LEAKS.

Step 4

Once all gas leaks have been

sealed, WAIT AT LEAST 5

MINUTES FOR GAS FUMES TO

DISSIPATE BEFORE LIGHTING

THE BURNERS.

Carefully follow "Operating

Instructions" to light the burner and

properly operate this unit.

GAS LEAK TESTING

• Gas leak testing must be performed outdoors in a well ventilated area every time cylinder is connected

to regulator and grill.

• Always keep unit away from open flames, sparks or lit cigarettes.

• Never use a flame to check for gas leaks.

• The regulator control knob is used when lighting the burner and to adjust the flame.

• Never use a unit that has a gas leak. Contact The Brinkmann Corporation’s Customer Service

Department for replacement parts or repairs at 800-527-0717.

• Propane cylinder should be positioned for vapor withdrawal as shown below.

WARNING

Watch For Bubbles

WARNING

PRE-START CHECK LIST:

Property damage, bodily harm, severe burns, and death could result from failure to follow these

safety steps. These steps should be performed after the grill has been assembled and prior to each

use. DO NOT operate this grill until you have read and understand ALL of the warnings and

instructions in this manual.

•Ensure that the grill is properly assembled.

•Leak check all gas connections. See section on "Leak Testing".

•Ensure that all electrical supply cords are properly grounded. Keep any electrical supply cord away

from any heated surfaces.

•Position your grill on level ground in a well ventilated location, a safe distance from combustible

materials, buildings and overhangs.

•Properly place the empty grease tray under the grease drain hole in the bottom of the grill to catch

grease during use.

• DO NOT obstruct the flow of combustion and ventilation air.

LIGHTING INSTRUCTIONS:

Follow the instructions exactly.

1. OPEN THE GRILL LID before attempting to light a burner so that fumes do not accumulate inside

the grill. An explosion could occur if grill lid is down.

2. Check that the regulator control knob is turned to the "OFF" position.

3. DO NOT stand with head, body, or arms over the grill when lighting.

Note: If burner does not light or flame is too low, you may have spider or other insect blockage in burner

See "Burner Assembly/Maintenance" under Proper Care and Maintenance under Connecting LP

Cylinder and Regulator to Grill.

LIGHTING THE GRILL:

1. Open lid before lighting burner.

2. Make sure the regulator control knob is in the "OFF"

position.

3. Insert lighted match through lighting hole within 1/2 in. from

burner and turn regulator control knob to High.

4. If ignition does NOT occur in 5 seconds, turn regulator

control knob to OFF, wait 5 minutes to allow gas to

dissipate and repeat lighting procedure.

5. To turn off, turn regulator control knob to "OFF".

WARNING

Read, understand and follow all warnings and instructions contained in this manual. DO NOT skip

any of the warnings and instructions contained in the preceding sections of this manual.

Lighting Hole

Matchlighter

OPERATING THE GRILL:

Never use Charcoal or Lighter Fluid inside your Gas Grill. Read and follow all warnings and

instructions contained in the preceding sections of this manual.

BREAKING IN YOUR GRILL:

•In manufacturing and preserving the components of your grill, oil residue may be present on the

burner and cooking surfaces of your grill.

•Before cooking on your grill for the first time you should preheat it for 15 minutes on "HIGH" to burn

off these residual oils.

PREHEATING THE GRILL:

•Prior to use, it is recommended that you preheat your grill. This ensures that the grilling surfaces are

at the desired temperatures to sear the food sugars when cooking. After lighting your grill, set the

main burner regulator control knob to the "HIGH" position for 10 to 15 minutes. Close the cover during

the preheat period.

CONTROLLING FLARE-UPS:

•Flare-ups are a part of cooking meats on a gas grill. This adds to the unique flavor of cooking on a

gas grill. Excessive flare-ups can over-cook your food and cause a dangerous situation for you and

your grill. Excessive flare-ups result from the build-up of grease in the bottom of your grill. If this

should occur, DO NOT pour water onto the flames. This can cause the grease to splatter and could

result in serious burns or bodily harm. If grease fire occurs close the lid and turn off the burner until

the grease burns out. Use caution when opening the lid as sudden flare-ups may occur.

• DO NOT leave your grill unattended while in use.

• DO NOT use water to extinguish flare-ups.

• Have fire extinguisher suitable for use with gas appliances readily accessible.

TO MINIMIZE FLARE-UPS:

•Trim excess fat from meats prior to cooking.

•Cook meats with high fat contents (chicken or pork) on Low settings or indirectly.

•Ensure that your grill is on level ground and the grease is allowed to evacuate the grill through the

drain hole in the bottom and into grease cup.

WARNING

TURNING OFF THE GRILL:

1. Turn off the regulator control knob.

Note: Remove propane bottle from regulator when grill is not in use.

Note: Observe flame height when lit: Flame

should be a Blue/Yellow color between

1"–2" when burner is on "HIGH".

GRILL COOKING TIPS

CLEANLINESS

• Always wash hands thoroughly with soap and hot water prior to handling food and after handling raw

meat, uncooked poultry or seafood.

• When using a platter to carry raw meat, uncooked poultry or seafood to the grill, make sure to wash the

platter thoroughly with soap and hot water before placing cooked foods back on the platter or use

different platters for raw and cooked foods.

• Never use the same utensils when handling raw meat, uncooked poultry or seafood unless you wash the

utensils thoroughly with soap and hot water.

• Never re-use marinade from raw meat or uncooked poultry on foods that have been cooked and are

ready to be served.

GRILLING TO PROPER TEMPERATURE

• Use a meat thermometer to be sure food has reached a safe internal temperature.

• The US Department of Agriculture recommends the minimum temperature be reached for the

following food items:

Chops . . . . . . . . . . . . . . . . . . . . .145 degrees F (62.8° C)

Ground Meat . . . . . . . . . . . . . . .160 degrees F (71° C)

Pork . . . . . . . . . . . . . . . . . . . . . . .160 degrees F (71° C)

Poultry . . . . . . . . . . . . . . . . . . . . .180 degrees F (82° C)

Roasts . . . . . . . . . . . . . . . . . . . . .145 degrees F (62.8° C)

Seafood . . . . . . . . . . . . . . . . . . . .140 degrees F (60° C)

Vegetables . . . . . . . . . . . . . . . . .145 degrees F (62.8° C)

HELPFUL HINTS

• If you pre-cook meat or poultry, do so immediately before grilling.

• Never defrost meat at room temperature or on a countertop.

• Refrigerate leftovers within 2 hours of taking food off the grill.

• For additional information, please phone the USDA’s toll free Meat & Poultry Hotline at 800-535-4555.

• To protect your grill from excessive rust, the unit must be kept clean and covered at all times when not

in use.

• Wash cooking grills and heat distribution plates with hot, soapy water, rinse well and dry. Lightly coat

cooking grill with vegetable oil or vegetable oil spray.

• Clean inside and outside of grill by wiping off with a damp cloth. Apply a light coat of vegetable oil or

vegetable oil spray to the interior surface to prevent rusting.

• The stainless steel exterior surface of your grill, can be cleaned with stainless steel cleaner.

• Never apply paint to the interior surface. Rust spots on the interior surface can be buffed, cleaned, then

lightly coated with vegetable oil or vegetable oil spray to minimize rusting.

PROPER CARE & MAINTENANCE

BURNER ASSEMBLY/MAINTENANCE

• Although your burners are constructed of stainless steel, they may corrode as a result of the extreme

heat and acids from cooking foods. Regularly inspect the burners for cracks, abnormal holes, and other

signs of corrosion damage. If found, replace the burner.

•DO NOT obstruct the flow of combustion and ventilation air. Burner tubes can become blocked by

spiders and other insects building their nests. Blocked burner tubes can prevent gas flow to the burners

and could result in a burner tube fire or fire beneath the grill. To clean the Burner Assembly follow these

instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill.

1. Turn gas off at control knob. Remove regulator from grill.

2. Remove cooking grill and heat distribution plate.

3. Remove bolt from burner foot.

4. Carefully lift burner up and away from valve opening.

5. Use a narrow bottle brush or a stiff wire bent into a small hook

to run through burner tube and flame ports several times.

Note: Wear eye protection when performing procedure 6.

6. Use compressed air to blow into burner tube and out the flame

ports. Check each port to make sure air comes out each hole.

7. Wire brush entire outer surface of burner to remove food

residue and dirt.

8. Check burner for damage, if any large cracks or holes are

found replace burner.

9. Replace bolt and nut to burner foot.

Debris

LOCK

CLEANING AND MAINTENANCE:

• Keep the appliance free and clear of combustible materials, gasoline and other flammable vapors

and liquids.

• Keep the ventilation openings of the cylinder enclosure free and clear of debris.

• Visually check burner flames for proper operation (see pictorial in "Burner Assembly/Maintenance" under

Proper Care and Maintenance). Spiders or other insects can nest in the burner causing gas blockage.

• For safe grilling and peak performance of your grill, perform these checks at least twice per year or

after extended periods of storage.

• Be sure to tighten up all hardware (nuts, bolts, screws, etc.) at least twice per year.

CAUTION: Some parts may contain sharp edges. Wear protective gloves if necessary.

• Remove the cooking grills, heat distribution plates, and burners from inside your grill. Use a brush with

hot water and detergent to remove excess residue. NEVER use a commercial oven cleaner. Rinse

completely with water. Towel dry and replace all components as described in the assembly instructions.

Regulator Connector

Burner Opening

Bolt Nut

This manual suits for next models

Table of contents

Languages:

Other Brinkmann Grill manuals

Brinkmann

Brinkmann Gourmet User manual

Brinkmann

Brinkmann Deluxe Professional User manual

Brinkmann

Brinkmann Pro Series 2610 User manual

Brinkmann

Brinkmann 2400 User manual

Brinkmann

Brinkmann 5-Burner Gas Grill User manual

Brinkmann

Brinkmann ProSeries 8445 User manual

Brinkmann

Brinkmann Grill King DeLuxe Heavy-Duty Outdoor Charcoal Grill &... User manual

Brinkmann

Brinkmann Smoke 'N Pit OUTDOOR BARBECUE GRILL & SMOKER User manual

Brinkmann

Brinkmann 3820 User manual

Brinkmann

Brinkmann Gas Outdoor Grill User manual

Brinkmann

Brinkmann ProSeries 2235 User manual

Brinkmann

Brinkmann ProSeries 4425 User manual

Brinkmann

Brinkmann 810-6340-S User manual

Brinkmann

Brinkmann Elite User manual

Brinkmann

Brinkmann 7741 User manual

Brinkmann

Brinkmann 810-1456-S User manual

Brinkmann

Brinkmann SMOKE'N GRILL Parts list manual

Brinkmann

Brinkmann 810-3810-S User manual

Brinkmann

Brinkmann 9400 User manual

Brinkmann

Brinkmann 2411 User manual

Brinkmann

Brinkmann Select 810-6680-S User manual

Brinkmann

Brinkmann 810-3245-0 User manual

Brinkmann

Brinkmann SOUTHFORK User manual

Brinkmann

Brinkmann Backyard kitchen User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide