Zanussi ZWD 71663 NW User manual

GETTING

STARTED?

EASY.

User Manual

ZWD 71663 NW

EN User Manual

Washer Dryer

SAFETY INFORMATION

Before the installation and use of the appliance, carefully read the

supplied instructions. The manufacturer is not responsible for any

injuries or damages that are the result of incorrect installation or

usage. Always keep the instructions in a safe and accessible

location for future reference.

CHILDREN AND VULNERABLE PEOPLE SAFETY

WARNING!

Risk of suffocation, injury or permanent disability.

•This appliance can be used by children aged 8 years and

above and by persons with reduced capabilities provided that

they have been given instruction and/or supervision regarding

the safe use of the appliance and understand the potential

hazards involved.

•Do not let children play with the appliance.

•Children under 3 years of age should be kept away from the

appliance unless continuously supervised.

•Keep all packaging away from children and dispose of it

appropriately.

•Keep detergents away from children.

•Keep children and pets away from the appliance door when it is

open.

•If the appliance has a child safety device, this should be

activated.

•Children shall not carry out cleaning and user maintenance of

the appliance without supervision.

GENERAL SAFETY

•Do not change the specification of this appliance.

•The appliance shall be installed as a freestanding product or

below the kitchen worktop if space margins permit.

•Do not install the appliance behind a lockable door, a sliding

door or a door with a hinge on the opposite side, that would

prevent the appliance door from being fully opened.

•Connect the mains plug to the mains socket only at the end of

the installation process. Make sure that the mains plug is

accessible after installation..

•The ventilation opening in the base (if applicable) must not be

covered by a carpet, mat, or any floor covering.

•Ensure good air ventilation in the located room to avoid the

back flow of gases into the room from appliances burning gas

or other fuels, including open fires.

•Exhaust air must not be discharged into a flue which is used for

exhausting fumes from any appliances burning gas or other

fuels.

•The operating water pressure at the water entry point from the

outlet connection must be between 0.5 bar (0.05 MPa) and 8

bar (0.8 MPa).

•Do not exceed the maximum load of 7 kg (refer to the

"Programme chart" chapter).

•The appliance must be connected to the water mains using the

new supplied hose sets, or other new hose sets supplied by

the Authorised Service Centre.

•Old hose sets must not be reused.

•If the mains power supply cable is damaged, it must be

replaced by the manufacturer, its Authorised Service Centre or

similarly qualified persons to avoid an electrical hazard.

•Wipe away lint or packaging debris that has accumulated

around the appliance.

•Items that have been soiled with substances such as vegetable

or mineral oil, acetone, alcohol, petrol, kerosene, spot removers,

turpentine, waxes and wax removers should be washed

separately with an extra amount of detergent before being dried

in the washer dryer.

•Do not use the appliance if items have been soiled with

industrial chemicals.

•Do not dry unwashed items in the wash dryer.

•Items such as foam rubber (latex foam), shower caps,

waterproof textiles, and rubber backed articles and clothes, or

pillows fitted with foam rubber pads should not be dried in the

washer dryer.

•Fabric softeners, or similar products, should only be used as

specified by the product manufacturer’s instructions.

•Remove all objects from items that could be a source of fire

ignition such as lighters or matches.

•Never stop the washer dryer before the end of the drying cycle

unless all items are quickly removed and separated so that

residual heat can dissipate.

•The final part of the washer dryer cycle takes place without heat

(cool down cycle) to ensure that items reach a temperature that

will not cause damage to them.

•Do not use high pressure water sprays and/or steam to clean

the appliance.

•Clean the appliance with a moist cloth. Use only neutral,

detergents. Do not use abrasive products, abrasive cleaning

pads, solvents or metal objects.

•Before any maintenance operation, deactivate the appliance

and disconnect the mains plug from the socket.

SAFETY INSTRUCTIONS

INSTALLATION

• Follow the installation instruction supplied with

the appliance.

• Do not install or use the appliance where the

temperature can be less than 0°C or where it is

exposed to the weather.

• Always keep the appliance vertical when being

moved.

• Make sure that there is air circulation between

the appliance and the floor.

• Remove all the packaging and the transit bolts.

• The floor area where the appliance is to be

installed must be flat, stable, heat resistant and

clean.

• Keep the transit bolts in a safe place. If the

appliance is to be moved in future they must be

reattached to lock the drum to prevent internal

damage.

• Always take care when moving the appliance as

it is heavy. Always use safety gloves and

enclosed footwear.

• Do not install or use a damaged appliance.

• Do not install the appliance where the appliance

door cannot be fully opened.

• Adjust the feet to have the necessary space

between the appliance and the flooring.

• When the appliance is in its permanent position,

check that it is fully level with the aid of a spirit

level. If it is not, adjust the feet accordingly.

ELECTRICAL CONNECTION

WARNING! Risk of fire and electrical

shock.

• The appliance must be earthed.

• Always use a correctly installed shockproof

socket.

• Do not use multi-plug adapters and extension

cables.

• Do not pull the mains cable to disconnect the

appliance. Always pull the mains plug.

• Do not touch the mains cable or the mains plug

with wet hands.

• UK and Ireland only. This appliance is fitted with

a 13 A mains plug. If it is necessary to change

the mains plug fuse, use only a 13 A ASTA (BS

1362) fuse.

• This appliance complies with the E.E.C.

Directives.

WATER CONNECTION

• Do not cause damage to the water hoses.

• Before connection to new pipes, pipes not used

for a long time, where repair work has been

carried out or new devices fitted (water meters,

etc.), let the water flow until it is clean and clear.

• Ensure that there are no visible water leaks

during and after the first use of the appliance.

USE

WARNING! Risk of injury, electrical

shock, fire, burns or damage to the

appliance.

• This appliance is for household use only.

• Do not put flammable products or items that are

wet with flammable products in, near or on the

appliance.

• Do not touch the glass door while a programme

is in operation. The glass can get hot.

• Do not dry damaged (torn, frayed) items that

contain padding or fillings.

• If laundry has been washed with a stain

remover, carry out an additional rinse cycle

before starting a drying cycle.

• Make sure that all metal objects are removed

from the laundry.

• Only dry fabrics that are suitable to dry in the

washer dryer. Follow the cleaning instruction on

the item label.

• Plastic items are not heat resistant.

– If a detergent ball is used, remove it before

starting a drying programme.

– Do not use a detergent ball if setting a non-

stop programme.

WARNING! Risk of injury or damage

to the appliance.

• Do not sit or stand on the open door.

• Do not dry dripping wet clothes in the

appliance.

DISPOSAL

• Disconnect the appliance from the mains

electrical and water supplies.

• Cut off the mains electrical cable close to the

appliance and dispose of it.

• Remove the door catch to prevent children or

pets from becoming trapped in the drum.

• Dispose of the appliance in accordance with

local requirements for the disposal of Waste

Electrical and Electronic Equipment (WEEE).

PRODUCT DESCRIPTION

APPLIANCE OVERVIEW

1 2 3

1Worktop

2Detergent dispenser

3Control panel

4Door handle

5Rating plate

6Drain pump filter

7Feet for levelling the appliance

INSTALLATION ON SUSPENDED FLOORING

Suspended wooden floors are particularly

susceptible to vibration.

To limit vibration we recommend placing a

waterproof wooden panel, at least 15 mm thick,

under the appliance. It should be screwed to at

least 2 floor beams and should extend beyond the

front feet.

If possible, install the appliance where the floor is

more stable.

FIXING PLATE KIT (4055171146)

Available from your authorised dealer.

If you install the appliance on a plinth, secure the

appliance in the fixing plates.

Read carefully the instructions supplied with the

accessory.

HOW TO ACTIVATE THE CHILD SAFETY

DEVICE

This device prevents children or pets from being

closed in the drum.

Turn the device clockwise, until the groove is

horizontal.

You cannot close the door.

To close the door, turn the device anticlockwise

until the groove is vertical.

CONTROL PANEL

CONTROL PANEL DESCRIPTION

1 2 3 4

91011

1Programme knob

2Spin reduction (Spin)

3Temperature (Temp.)

4Display

5Drying time (Drying Time)

6Prewash phase (Prewash)

7Additional rinse (Extra Rinse)

8Automatic drying level (Auto Dry)

9Start/Pause (Start/Pause)

10 Delay start

11 Time save

DISPLAY

A B

E DFG

Time area : Programme duration

: Selected drying time

: Delay start

: Alarm codes

: Message of error

: The programme is completed.

Time programme indicators : Normal duration indicator

: Quick indicator

: Super quick indicator

BDelay start indicator

CChild safety lock indicator

DDoor locked indicator

E, , Indicators of dryness level

FDrying phase indicator

GWashing phase indicator

PROGRAMMES

PROGRAMME CHART

Programme

Temperature range

Maximum load

Maximum spin

speed

Programme description

(Type of load and soil level)

Washing programmes

Cotton

90°C - (Cold)

7 kg

1600 rpm White cotton and coloured cotton. Normal

soil and light soil.

Economy1)

60°C - 40°C

7 kg

1600 rpm White cotton and fast-coloured cotton.

Normal soil. The energy consumption decrea-

ses and the time of the washing programme is

extended.

Synthetics

60°C - (Cold)

3,5 kg

1200 rpm Synthetic items or mixed fabric items. Nor-

mal soil.

2) Wool

40°C - (Cold)

1,5 kg

1200 rpm Machine washable wool, hand washable

wool and delicate fabrics with «hand wash-

ing» care symbol.3)

Delicates

40°C - (Cold)

3,5 kg

1200 rpm Delicate fabrics such as acrylics, viscose,

polyester items. Normal soil.

Mix 20°

20°C

3 kg

1200 rpm Special programme for cotton, synthetic and

mixed fabrics lightly soiled. Select this pro-

gramme to reduce the energy consumption.

Make sure that the detergent is suitable for low

temperatures in order to have good washing re-

sults4).

Super Eco

Cold

3 kg

1200 rpm Mixed fabric (cotton and synthetic items)5).

Drain 7 kg To drain the water in the drum. All fabrics.

Spin 7 kg6)

1600 rpm7)

To spin the laundry and to drain the water in the

drum. All fabrics, except woollens and del-

icate fabrics.

Rinse 7 kg6)

1600 rpm7)

To rinse and spin the laundry. All fabrics, ex-

cept woollens and very delicate fabrics. Reduce

the spin speed accordingly to the type of laun-

dry.

8) Wool Dry 1 kg Drying programme for woollens.

Synthetics Dry 2 kg Drying programme for synthetic items.

Programme

Temperature range

Maximum load

Maximum spin

speed

Programme description

(Type of load and soil level)

Cotton Dry 4 kg Drying programme for cotton items.

Miniprogramme

30°C

1,5 kg

800 rpm A short cycle for synthetic and delicate

items with light soil level or for items to

freshen up.

1) The washing programme Economy at 60ºC with a load of 7 kg and the drying programme Cotton Dry

are the reference programmes for the data entered in the energy label, in compliance with EEC 92/75

standards.

The water temperature of the washing phase may differ from the temperature declared for the

selected programme.

2) Woolmark Apparel Care. The wool wash cycle of this machine has been approved by The Woolmark

Company for the washing of machine washable wool products provided that the products are washed ac-

cording to the instructions on the garment label and those issued by the manufacturer of this washing ma-

chine. M1380 In UK, Eire, Hong Kong and India the Woolmark symbol is a certification trademark.

3) During this cycle the drum rotates slowly to ensure a gentle wash. It can seem that the drum doesn't

rotate or doesn't rotate properly, but this is normal for this programme.

4) The appliance performs the short heating phase if the water temperature is below 20°C. The appliance

can show the temperature setting as “cold”.

5) This programme is for daily use and has the lowest energy and water consumption whilst maintaining a

good washing performance.

6) The maximum load refers to cottons items. Reduce the load accordingly in case of other type of laundry.

7) The maximum spin speed is related to cotton items. Set the spin speed. Make sure that it agrees with

the laundry.

8) Woolmark Apparel Care. The wool drying cycle of this machine has been approved by The Wool-

mark Company for the drying of machine washable wool products provided that the products are washed

and dried according to the instructions on the garment label and those issued by the manufacturer of this

machine. M1381 In UK, Eire, Hong Kong and India the Woolmark symbol is a certification trademark

Programme options compatibility

Programme

■ ■ ■ ■ ■ ■ ■

■ ■ ■ ■ ■ ■1) ■

■ ■ ■ ■ ■ ■ ■

■ ■ ■ ■

■ ■ ■ ■ ■ ■ ■

■ ■ ■■1) ■

Programme

■ ■ ■ ■■

■

■ ■ ■

■ ■ ■ ■■

■2) ■■

1) Only the QUICK option is available.

2) Available only if the last spin speed step is lower than 800 rpm.

PROGRAMMES FOR AUTOMATIC DRYING

Dryness Level Type of fabric Load

Extra Dry

For towelling materials

Cottons and Linen

(bathrobes, bath towels, etc) up to 4 kg

Cupboard Dry1)

For items to be stored

Cottons and Linen

(bathrobes, bath towels, etc) up to 4 kg

Synthetics and mixed fab-

rics

(jumpers, blouses, underwear,

household linen)

up to 2 kg

Iron Dry

Suitable for ironing

Cottons and Linen

(sheets, tablecloths, shirts, etc) up to 4 kg

1) Hints for test institute The test performance, in accordance with EN 50229, must be carried out with

a FIRST drying load of the maximum declared drying capacity (load composition according to EN61121)

by setting the AUTOMATIC CUPBOARD DRY programme for Cotton. The SECOND drying load with the

residual load must be tested by setting the AUTOMATIC CUPBOARD DRY programme for Cotton.

PROGRAMMES FOR TIMED DRYING

Dryness Level Type of fabric Load (kg) Spin

speed

(rpm)

Suggested

duration

(mins)

Extra Dry

For towelling materials Cottons and Linen

(bathrobes, bath towels, etc) 4 1600 165 - 180

2 1600 90 - 100

1 1600 60 - 70

Table of contents

Other Zanussi Washer Dryer manuals

Zanussi

Zanussi WDJ 1074 User manual

Zanussi

Zanussi WTJ 1074 H User manual

Zanussi

Zanussi ZWT 71401 WA User manual

Zanussi

Zanussi W902 User manual

Zanussi

Zanussi ZKG 7143 User manual

Zanussi

Zanussi WJD 1257 S User manual

Zanussi

Zanussi WD 1601 User manual

Zanussi

Zanussi Z716WT83BI User manual

Zanussi

Zanussi ZWD 14581 S User manual

Zanussi

Zanussi ZKH 2105 User manual

Zanussi

Zanussi WJD 1667 W User manual

Zanussi

Zanussi WD 2290 Assembly instructions

Zanussi

Zanussi ZWT71401WA User manual

Zanussi

Zanussi WD1010 User manual

Zanussi

Zanussi ZWD 1682 W User manual

Zanussi

Zanussi ZWD 1681 W User manual

Zanussi

Zanussi ZKG 2105 User manual

Zanussi

Zanussi WDJ 1013/A Assembly instructions

Zanussi

Zanussi W1002 User manual

Zanussi

Zanussi ZWD 12270 G1 User manual

Zanussi

Zanussi ZKN71246 User manual

Zanussi

Zanussi WD 9091 User manual

Zanussi

Zanussi ZKG7145 User manual

Zanussi

Zanussi WJS 1265 W User manual

Popular Washer Dryer manuals by other brands

Whirlpool

Whirlpool WFC8090GX Use and care guide and installation instructions

Whirlpool

Whirlpool LTE5243DQ6 User instructions

Bosch

Bosch XQG100-WDU285H00W User manual and installation instructions

montpellier

montpellier MWD7512S Installation and operating instructions

LG FHD0905 T Series owner's manual

Midea

Midea MF200D85B owner's manual

Maytag

Maytag MGT3800XW installation instructions

Siemens

Siemens WD15G440TR Instruction manual and installation instructions

Equator

Equator Clothes Processor EZ1500 owner's manual

Splendide

Splendide WDC7100XCP Specifications

John Lewis

John Lewis JLWD 1408 instruction manual

Ariston

Ariston A1200WD Instruction booklet

Whirlpool

Whirlpool YLTE5243DQ5 installation instructions

Whirlpool

Whirlpool WFCR 75230 Health & safety, use & care and installation guide

ATT

ATT Hammer Jet v1 operating manual

AEG

AEG LAVAMAT 63742 VI Instruction booklet

Electrolux

Electrolux EWW8024P5WB user manual

GE GTD42EASJWH owner's manual