Xtreme METRO EXPRESS User manual

X-Treme™ Electric Scooters

METRO EXPRESS

Owner’s Manual

PLEASE BE SAFE WHEN RIDING

ALWAYS WEAR A HELMET AND OBEY ALL LAWS!

BATTERY MAINTENANCE and CHARGING

INSTRUCTIONS

1. You MUST charge completely prior to initial use. (Follow charging

instructions in your Product Handbook)

2. Charge immediately after each use.

3. Charge before storage. You must charge every 30 days if not in use.

4. Charge the unit for 12 hours or until the light on the charger turns red &

green.

5. DO NOT allow this unit to deep discharge the battery.

6. For safety purposes, DO NOT charge for over 24 hours.

7. Turn the unit OFF when not in use.

This PRODUCT IS NOT INTENDED FOR EXTREME or

OFF-ROAD Use! Please take care of your X-600!

DO NOT JUMP or ABUSE THIS PRODUCT!

DO NOT RIDE IN WET/ICY CONDITIONS!

Failure to follow these instructions will

VOID YOUR WARRANTY!

IMPORTANT

Failure to follow these INSTRUCTIONS will

VOID YOUR WARRANTY!

WARNING

This product does not conform to Federal Motor Vehicle Standards and is not

intended for operation on public streets, roads or highways. Serious injury can

result from the unsafe operations of this product. Operator can minimize these

risks by using certain safety equipment such as: safety helmet, goggles,

gloves, elbow and kneepads and appropriate footwear.

DO NOT operate this product in traffic, on wet, frozen, oily or unpaved

surfaces or under the influence of drugs and/or alcohol. Avoid uneven

surfaces, potholes, surface cracks and obstacles.

DO NOT use a water hose to clean this product. See Product Handbook for

more information.

This product is recommended for riders 14 YEARS OF AGE and older.

SAFETY

Persons without excellent vision, balance, coordination, reflex, muscle and

bone strength and good decision-making capabilities should not use this

product.

Minors without adult supervision should not use this product.

Persons unwilling or unable to take responsibility for their own actions

should not use this product.

The user of this product assumes ALL risks associated with its use. To

minimize these RISKS, the user must wear safety helmet, goggles,

gloves, elbow and kneepads and appropriate footwear.

This product is ELECTRIC! DO NOT ride this product in wet conditions,

puddles or rainy weather.

IMPORTANT

PLEASE READ THIS BEFORE USING THIS PRODUCT

READ THIS FIRST!

SAFETY GUIDE

The recommended minimum age for riding this scooter is 14 years old.

To avoid damage to the motor and footplate, do not overload the scooter.

Never ride with more than one person.

Inspect your scooter thoroughly before each use for loose or missing parts.

Avoid unintentional starts by turning the scooter off while not in use.

To avoid the risk of a short circuit in the electrical parts, do not use your X-

Treme Electric scooter in the rain and never spray or wash off your scooter

with water.

Do not place the battery near fire or heat.

To avoid damage to the battery, do not use the charger if it has been

damaged in any way.

Keep hands, face, feet and hair away from all moving parts.

Do not touch the motor or wheels while they are rotating.

Brakes are designed to control speed as well as stop the scooter. Practice

braking for proper slowing down and smooth stops.

Maintain your X-Treme Metro Express A-Blaze Signature Series Scooter as

recommended in this Product Handbook.

Use only quality replacement parts as recommended by the manufacturer.

Inspect the entire scooter prior to each use. Replace any part that is cracked,

chipped or damaged before use.

*NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT

SUPERVISION.

*NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE

INFLUENCE OF ALCOHOL.

If a situation arises that is not covered in the manual,

proceed with caution and use good judgment.

Contact your dealer or X-Treme (http://support.x-tremescooters.com/)

if you need further assistance

QUICK REFERENCE

SAFETY GUIDE

Table of Contents

Important Information……………………………………………………… 2-3

Quick Reference Safety Guide…………………………………………… 4

Table of Contents………………………………………………………….. 5

Getting To Know Your Metro Express…………………………………… 6

Package Contents………………………………………………………….. 7

Getting Started……………………………………………………………… 7-9

Assembly………………………………………………………………7-8

Charging the Battery……………………………………………….. 8-9

Riding…………………………………………………………………………9

Stopping & Braking………………………………………………………….9-10

Frame, Fork & Handlebars…………………………………………………10

Tires…………………………………………………………………………. 10

Safety Gear…………………………………………………………………. 10-11

Battery……………………………………………………………………….. 11

Folding & Storage………………………………………………………….. 11

Maintenance Schedule.....………………………………………………… 11-12

Troubleshooting Guide……………………………………………………. 12-14

GETTING TO KNOW YOUR METRO EXPRESS

1. Throttle

2. Brake Lever

3. Handlebar Stem

4. Rear Fender

5. Rear Hub Motor 800 Watt

6. Kick Stand

7. Charging Port

8. Folding Mechanism

PACKAGE CONTENTS

Your X-Treme™ Metro Express A-Blaze Signature Series Electric Scooter

comes with the following items in the box. Please locate each item.

1. Metro Express A-Blaze Signature Series Electric Scooter

2. 48 Volt Charger

3. Seat

4. Seat Post & Clamp

5. User Manual

GETTING STARTED

Please read and understand this manual prior to riding your

Metro Express

ASSEMBLY

Figure 1 Figure 2 Figure 3 Figure 4

Figure 5

4. Attach the handlebar to the handlebar stem (Figure 4).

1. Extend the scooter kickstand (Figure 1).

2. Open the scooter by lifting the handlebar

stem at the folding mechanism (Figure 2).

3. Tighten the knob on the folding mechanism

to lock the handlebar stem in place (Figure 3).

5. Tighten the knob on the handlebar to lock the handlebar to the handlebar

stem (Figure 5).

CHARGING THE BATTERY

Your Metro Express may not have a fully charged battery, therefore, you will

need to charge the battery prior to use.

Warning: Do not allow your batteries to go into deep discharge as this

may damage the battery

Figure 6 Figure 7 Figure 8

1. Make sure to turn the scooter off prior to charging. Once you’ve ensured the

scooter is off, plug the charger (Figure 6) into the charger port (Figure 7) on the

your Metro Express.

2. Plug the charger into the wall outlet. The charger will illuminate with a red

light to show charging has begun. If the charger does not light up check the

power to the outlet. If necessary try a different outlet.

3. Your initial charge time should be 12 hours. Once scooter is fully charged a

green light will illuminate. Unplug charger from the wall outlet and then remove

charger port from scooter.

WARNING! Always disconnect your charger from the scooter before

cleaning with liquid.

NOTE: If your charger does not look like the one illustrated, your unit has been

supplied with an alternative charger. The specifications and charging procedure

remain the same.

The charger has a small window with one LED or two LEDs to indicate the

charge status.

Chargers have built-in over-charge protection to prevent the battery from being

over-charged.

Charger will get warm during use. This is normal for some chargers and is no

cause for concern. If your charger does not get warm during use it does not

mean that your charger is not working properly.

WARNING! Failure to recharge your battery at least once a month may

result in a battery that will no longer accept a charge.

RIDING

1. Make sure all exposed bolts and screws are tightened.

2. Raise the kickstand to the upright position.

3. Push the on/off switch to the ON position.

4. Put one foot on the deck of the Metro Express while pushing off with the

other and gently rotate the Throttle Grip on the right side of the handlebar. The

scooter will begin to move.

**Your Metro Express scooter has variable speed control. You can control the

speed of your scooter by the amount of pressure you use when rotating the

throttle control. The more you rotate the throttle, the faster your scooter will go.

STOPPING & BRAKING

To brake, release the Throttle Grip and depress the Brake Levers on the right &

left side of the handlebars. Depressing the brake will disengage the power to

the motor. When the unit feels like it is losing speed or not accelerating the unit

is ready to be recharged.

NOTE: If the on/off switch is left in the ON position for more than 10-15 minutes

without moving the Smart Power will shut itself off. To reset, turn the power to

OFF, wait a few seconds and then turn the power back to ON.

Check the brakes for proper function before each ride. When you squeeze the

lever the brake should provide positive braking action. When you apply the

brake with the speed control on the brake cut-off switch should stop the motor.

Make sure that the brakes are not rubbing.

Squeezing the hand brake on the left side of the handlebar activates the rear

brake. Squeezing the hand brake on right side will activate the front brake.

Practice braking on a smooth, dry surface to get used to the feel of the braking

system. Braking distance is affected by wet conditions and loose and uneven

riding surfaces.

FRAME, FORK & HANDLEBARS

Periodically check for cracks or broken connections. Although broken frames

are rare, it is possible for an aggressive rider to run into a curb or wall and

wreck and bend or break a frame. Get in the habit of inspecting your Metro

Express on a regular basis.

TIRES

Periodically inspect the tires for excess wear. Regularly check the tire pressure

and re-inflate as necessary. The Metro Express uses a tubeless tire.

SAFETY GEAR

Always wear proper protection gear such as an approved safety helmet. Elbow

pads and kneepads are recommended. Always wear athletic shoes (lace-up

Table of contents

Popular Scooter manuals by other brands

TEKTRO

TEKTRO CHEETAH owner's manual

Douglas

Douglas Vespa Sprint Operation and maintenance

PLAYTIVE

PLAYTIVE AS-2448 Instructions for use

Ebinger

Ebinger DONKEY XL User instructions

Flyer

Flyer Mountain Original instruction manual

BackCountry eBikes

BackCountry eBikes Storm owner's manual

equipmed

equipmed FreeRoam II user manual

Yoto

Yoto Lion owner's manual

WESTHILL BIKES

WESTHILL BIKES LINK user manual

BAnff

BAnff eProdigy series Assembly manual

Winther

Winther 475 Assembly instruction

Jetson

Jetson JBZL17 user manual

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 user manual

Carrera

Carrera impel manual

Afikim

Afikim Superlight SL-3 user manual

CareCo

CareCo ZOOM owner's manual

Douglas

Douglas Vespa G.S. Service manual

Gazelle

Gazelle with BOSCH System user manual