Whispbar K905W User manual
K905W
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 8 x 1 x 8 x 8
x 1 x 16 x 8 x 16
x 8 x 8
Revision No: 3C 1
Fitting Kit K905W
MAX kgs (lbs)
W/P WHD
LDV
V80 Maxus, 5dr Van 11-+ EU 100 kgs (220 lbs) 100 kgs (220 lbs)
V80 Maxus, 5dr Van 11-+ CN 100 kgs (220 lbs) 100 kgs (220 lbs)
V80 SWB Low Roof, 5dr Van 11-+ NZ 100 kgs (220 lbs) 100 kgs (220 lbs)
V80 SWB Low Roof, 5dr Van 14-+ AU 100 kgs (220 lbs) 100 kgs (220 lbs)
2
Fitting Kit K905W
V80 Maxus, 5dr Van 11-+ (EU)
V80 Maxus, 5dr Van 11-+ (CN)
V80 SWB Low Roof, 5dr Van 11-+ (NZ)
V80 SWB Low Roof, 5dr Van 14-+ (AU)
3
A B C 1 2 3
150mm 890mm 1630mm 1290mm 1290mm 1290mm
5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"
150mm 890mm 1630mm 1290mm 1290mm 1290mm
5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"
150mm 890mm 1630mm 1290mm 1290mm 1290mm
5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"
150mm 890mm 1630mm 1290mm 1290mm 1290mm
5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"
4
1290mm
50 13/16ths"
1290mm
50 13/16ths"
1290mm
50 13/16ths"
1290mm
50 13/16ths"
D
2370mm
93 2/8ths"
2370mm
93 2/8ths"
2370mm
93 2/8ths"
2370mm
93 2/8ths"
X
Fitting Kit EN
K905W
Items you will require:
●Tape measure
Pen
Hammer
Cordless drill
Depth stop
Vacuum cleaner
Rust inhibitor
Small paint brush
Neutral cure silicon sealant
Rivet gun
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
4
Fitting Kit EN
K905W
●Use keys to remove covers.
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
5
Fitting Kit EN
K905W
●Select plastic internal block (from fitting kit)
and insert into foot.
●Repeat for all legs.
●Permanent Mount Fitment
●Apply masking tape to vehicle roof in all
positions.
6
Fitting Kit EN
K905W
●Place mounting block into position as
shown.
●Repeat for all positions.
●Fit rubber pads (supplied with fitting kit) to
foot. Pad may vary in shape to that shown.
●Make sure the pad fits into the holes
underneath the foot.
●Place crossbar on vehicle.
●Adjust crossbar in or out to suit vehicle.
Refer to the crossbar instructions for
crossbar adjustment.
●Make sure there is no interference between
what you intend to carry with aerials,
sunroof or tailgate.
●Mark as shown.
●Lightly mark position of outside holes of the
mounting block in the roof channel.
7
Fitting Kit EN
K905W
●CAUTION: Maximum depth 7mm.
Use 7mm drillstop over supplied 4.9mm
drill bit.
Drill two outside holes at marked positions.
●Take care not to drill too deep.
●Remove tape.
●Vacuum and clean swarf from channel.
●Treat holes to prevent corrosion.
8
Fitting Kit EN
K905W
●Apply neutral cure silicon sealant in and
around drilled holes.
●Install rivets through permanent mount
blocks.
●Rivet into place.
WARNING: Do not use countersunk screws as an
alternative fixing method to the rivets supplied with
this kit.
9
Fitting Kit EN
K905W
●Assemble as shown.
Fitment
●Select grubscrews and screw into the
vehicle's fixed points.
●Do not over tighten.
●Repeat for all positions.
●Fit nut to grubscrew.
10
Table of contents
Other Whispbar Automobile Accessories manuals
Whispbar
Whispbar K854W User manual
Whispbar
Whispbar K838W User manual
Whispbar
Whispbar K085W User manual
Whispbar
Whispbar K522W User manual
Whispbar
Whispbar K508W User manual
Whispbar
Whispbar K863W User manual
Whispbar
Whispbar K388W User manual
Whispbar
Whispbar K327W Operation and installation manual
Whispbar
Whispbar K602W User manual
Whispbar
Whispbar K719 User manual
Whispbar
Whispbar K774W User manual
Whispbar
Whispbar K595W User manual
Whispbar
Whispbar K409W User manual
Whispbar
Whispbar K309W User manual
Whispbar
Whispbar K527W User manual
Whispbar
Whispbar K089W User manual
Whispbar
Whispbar K161W User manual
Whispbar
Whispbar K451W User manual
Whispbar
Whispbar K368 User manual
Whispbar
Whispbar K489W User manual
