Whispbar K448W User manual

K448W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 1 x 4 x 4 x 4

x 4 x 4 x 16 x 1

Revision No: 6D 1

Fitting Kit K448W

MAX kgs (lbs)

W/P WHD

Honda

CR-V , 5dr SUV 07-11 EU 75 kgs (165 lbs) 75 kgs (165 lbs)

CR-V , 5dr SUV 07-11 US 75 kgs (165 lbs) 75 kgs (165 lbs)

CR-V , 5dr SUV 07-12 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)

CR-V , 5dr SUV 07-12 AU 75 kgs (165 lbs) 75 kgs (165 lbs)

CR-V , 5dr SUV Feb 07-12 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K448W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K448W

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

●Adjust crossbar in or out to suit vehicle.

Refer to the crossbar instructions for

crossbar adjustment.

●Attaches to factory-fitted mounting points

●Please check the rear of this manual for

information relating specifically to your

vehicle.

Fitting Kit EN

K448W

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all four positions.

Fitting Kit EN

K448W

●Make sure the pad fits into the holes

underneath the foot.

●Repeat for all legs.

Fitment

●Open or remove fixed-point covers.

●The fixed point studs have a thick layer of

paint. Remove paint by using the M8 nut

supplied. Use a socket spanner and run the

nut down the centre stud only.

Fitting Kit EN

K448W

●Repeat for all four positions.

●Fit the adaptor to each stud.

●Select four grubscrews and assemble them

into the adaptor using 3 mm (1/8") Hex

Key.

●Do not over tighten.

●Repeat for all four positions.

Fitting Kit EN

K448W

●Apply protective strip as shown.

Trim if required.

●Fit the four coverplates as shown.

●Place crossbar foot over grubscrews.

Fitting Kit EN

K448W

●Tighten the plastic knob. The side with the

nut showing should be facing up.

●Ensure the plastic knob is in the position

shown when fully tightened.

●Repeat for all four positions.

●Check crossbar is securely attached to the

vehicle.

●Use keys to fit and lock covers

Fitting Kit EN

K448W

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Table of contents

Other Whispbar Automobile Accessories manuals

Whispbar

Whispbar K647W User manual

Whispbar

Whispbar K587 Operation and installation manual

Whispbar

Whispbar K539W User manual

Whispbar

Whispbar K556W User manual

Whispbar

Whispbar K566W Operation and installation manual

Whispbar

Whispbar K911W User manual

Whispbar

Whispbar K102W User manual

Whispbar

Whispbar S42W User manual

Whispbar

Whispbar K919W User manual

Whispbar

Whispbar K509 User manual

Whispbar

Whispbar K501W User manual

Whispbar

Whispbar K619 Operation and installation manual

Whispbar

Whispbar K726W User manual

Whispbar

Whispbar K584W User manual

Whispbar

Whispbar K938W User manual

Whispbar

Whispbar K385 Operation and installation manual

Whispbar

Whispbar K588W Operation and installation manual

Whispbar

Whispbar K707W User manual

Whispbar

Whispbar K733W User manual

Whispbar

Whispbar K1009W User manual

Whispbar

Whispbar K524W User manual

Whispbar

Whispbar K333W User manual

Whispbar

Whispbar K158W User manual

Whispbar

Whispbar K820W User manual

Popular Automobile Accessories manuals by other brands

James Baroud

James Baroud Odyssey user guide

Motorola

Motorola i50sx owner's manual

Yakima

Yakima 9MM STANDARD BIKE MOUNT instructions

Feniex

Feniex T3 instruction manual

Renault

Renault 77 11 423 180 Installation instruction

Kia

Kia E8300-4D000 manual

Brink

Brink 756843 installation instructions

v.link

v.link CI-VL2-PC-HSD manual

Viking

Viking Stack-Rack Assembly and use instructions

Aries

Aries 203015 installation manual

Choetech

Choetech AT0005 user manual

ZZ2

ZZ2 ZZAIR-PRO instruction manual

Holman

Holman 4A80L installation guide

Thule

Thule 2075 parts manual

Motorola

Motorola T325 quick start guide

TAUBENREUTHER

TAUBENREUTHER 16-3950 FITTING INSTRUCTION

DV8

DV8 FBJL-02 Product installation manual

Prorack

Prorack K1163 manual