Trillium Panther 306 Operating manual

The PANTHER 306 Key Telephone System is a PANTHER 612

System which has been slightly downsized to better

accommodate smaller business. For your convenience, the table

below highlights major differences between the two systems.

Refer to the reverse of this Update Sheet

for Technical

Specifications.

ITEM

Lines

Stations

Attendants (BLF Sets)

6max

’

6 max

Key Service Unit Types Tone/Rot Only

Tone or Tone/Rot

Set Types 3 Line/6 DSS- NHF 6 Line/l 2 DSS

NHF

3 Line/6 DSS- HF/BLF 6 Line/l 2 DSS- HF/BLF

FEATURES

External Page No Yes

Loud Bell No Yes

OPTIONS

SMDR No Yes

NOTE: ICM = intercom, NHF = Non-Handsfree, BLF = Busy Lamp Field, HF = Handsfree

Tone/Rot = Tone/Rotary

System Capabilities

Outside Lines

PANTHER Sets

Intercom Speech Paths

Attendant Sets

Door Modules

Power Fail Transfer

3 (2 with Door Answer)

6 max

Unit transfers 3 outside lines

to 3 standard phones

Power

AC Power Req.uirements

Station Loop Limit

110 Volts 2 10% (SO/60 Hz)

1 Amp max load

240 ohms max

(Equivalent to 2000 feet 24 AWG)

Environmental

Operating Temperature

Relative Humidity

Signaling

Number Plan

32°F to 104°F (0°Cto 40°C)

9Oohor less,non-condensing

Rotary Dial and/or Tone Dial

Station Numbers

Connectors

10 to 15

KSU Line Connectors

KSUSet Connector

KSU External Battery Connectors

KSU Door Answer Unit Connector

KSU Power Fail Transfer Connector

KSU Music Input

Set Connector

Lines 1 and 2, and 3 -4-conductor

modular

Sets 10 to 15 - 50-pin connector

Clips

6-conductor modular

4-conductor modular

Mono l/8 inch Mini Jack

6-conductor modular

- pins 2,3,4,5 interface to the Voice

and Data Pairs;

- pins 1and 6 provide an interface for

connecting an external amplifier to

the speaker terminals

Specificabcms and features are sub;ect to change without notice.

U.S. Marketing HeadquarterstU.S.O$berations International Sales

Trillium TekpMne Systems Corporation Trillium Telephone Systems kc

1675 MacArthur Blvd., 603 March Road, P.O. BOX 1330, Kanaz, Ontara K2K 1X3

Costa Mesa, C&forma 92626, Tel.: (714) 557-3300 Telex: 0534524. Tel.: (613) 592-2550. Fax: (613) 592-2555

Canadian Sales

Trillium Tetephone Sales Inc.

155 Gordon Baker Road, Suite 206, WIllowdale,

@ Copyrght 1987 TRILLIUM Telephone Systems MC.

TMTrademark of TRILLIUM T&phone Systems II-C.

Station Select/Speed Call - dual-

function keys used to make intercom paging

announcements and to dial private speed call

numbers.

Redial - used to redial the last number

manually dialed from your Set.

Line

- used

to select any of the outside

lines (unless programmed otherwise).

Hold - places outside calls on hold and

exclusive hold.

Conference - for setting up three-party

add-on conference calls.

Flash/Cancel - programmable as a

calibrated hookswitch flash or cancel, but not

both:

Flash

provides a calibrated on-hook signal

which is required to access most PBX,

Centrex and network features.

Cancel is used to cancel external calls and

return dial tone without hanging up the

handset.

Speed - used to enter pnvate and common

speed call numbers into the system’s memory;

also for dialing speed call numbers.

Speaker

turns the Set’s speaker on and

off; also used to end a handsfree call.

Mic On/Off - turns the Set’s microphone

on and off for handsfree calls.

Intercom

used to perform internal call

transfers, activate paging, background music

and various other features.

Ringer Volume Control - controls the

volume of the tone ringing.

Speaker Volume Control

controls the

volume of the speaker audio.

Station Indicator Lamps

(Panther 306

Attendant Set only) - turn on when the

corresponding Set is busy on a call.

Asterisk (Jt)

when the * is dialed as ‘4%

first digit in a telephone number sequence the

last outside line used at your Set is

automatically selected. (The handset must be

in the cradle).

Pound (#)

when the # is dialed, the

internal intercom line will be automaticalty

selected, provided the handset is in the cradle

and all speech paths are not in use.

Handset

used to place call5 in the

conventional handset manner. Provides more

privacy man the handsfree method.

To use most of the PANTHER 306 system features, follow

the PANTHER 612 operating instructions given in the

PANTHER User Guide and the PANTHER Quick Reference

Guide. PANTHER 306 system features which operate

differently are described below.

Private Speed Call - Dialing

speed call one of your first 5 Private numbers -

Lift the handset.

Press the Line key of an outside line.

Handsfree -

Turn the MIC. on/off indicator on.

Handsfree -

Press the Line key of an outside line or press *

Dial tone is heard; line indicator winks.

Press desired Speed Call key_(DSS

keys 11-15).

The number is automatically speed dialed.

To speed call one of your last 6 Private Speed numbers

Lift the handset. Press the Line key of an outside line.

Handsfree -

Turn the Mic. on/off indicator on.

Handsfree -

Press the Line key of an outside line or press Jt.

Dial tone is heard; line indicator winks.

Press the Speed key.

Dial the desired Speed Call Code

(from 05 to 10).

The number is automatically speed dialed.

Private Speed Call - Storing

To store your first 5 Private Speed Call entries -

Press

the Speed key.

Dial the entry to be stored including any pauses, halts, flashes.

Continuous tone is heard; intercom indicator winks.

Press the desired Speed Call key (11-15).

Maximum 26 digits.

Intercom indicator flashes.

Contmuous tone stops; indicator continues to flash.

Write the entry on

the designation card.

Repeat above procedure for each entry to be stored.

To store your last 6 Private Speed Call entries

Press the Speed key.

Continuous tone is heard; intercom indicator winks.

Dial the desired speed call code (05 to 10).

Intercom indicator flashes.

Dial the entry to be stored including any pauses, halts, flashes.

Maximum 26 digits.

Continuous tone stops; indicator continues to flash.

Write the entry on the designation card.

Repeat above procedure for each entry to be stored.

Door Answering

Line key 3 is used to access the Door Module.

To answer a door

call

(from either Module)

Distinctive tone ringing is heard. Line 3 indicator flashes.

Lift the handset; press Line key 3.

Handsfree -

Turn the Mic. onloff indicator on; press Line key 3.

tine 3 indicator winks.

The visitor

at the door need only speak in the direction of

the Door Module.

To place an intercom call to Door Module One -

Lift the handset; press Line key 3.

Handsfree -

Turn the Mic. on off indicator on; press Line key 3.

One ringing burst is heard; line 3 indicator wrnks.

. F 1

Make your announcement.

The called

party

answers by speaking in the direction of

the Door Module.

end

a Door

Module conversation -

Hang up the handset.

Handsfree -

Press the Speaker key.

Line 3 indicator turns off.

Features that do not apply to the PANTHER 306 System:

Music through external paging

SyStetII

Cell the attendant by dialing 0

Non-appearing line access Message waiting from the attendant

Call Data Recording operations Loudspeaker Paging

Specrficaf/ons and features are subject lo change without notice.

U.S. Marketing Headquarters/U.S.Operations

Trlllwm T&phone Systems Corporation

1675

MacArthur Blvd.,

Costa Mead. California 92626, Tel.: (714) 557-3300

Canadian Sales

TrGum Telephone Sales Inc.

I 55 Gordon

Baker Road. Suite 206. Wlllowdale.

Ontano, M2H 3N5 Tel.:

(416)

494-0522

International Sales

Tnllwm Telephone Systems Inc.

603 March Road, P.O. Box 13030, Kanata, Onlano. K2K 1X3

Telex 053-4524, Tel.: (613) 592-2550, Fax: (613) 592-2555

@Copynght 1987 TRILLIUM Telephohe Systems Ix.

TMTrademark of TRILLIUM Telephone Systems Inc

91-0363-2A

March 1987

Pnnted in Japan

F-301 4-l

bNcY. When following this update-refer to

Due to the similarity between the

PANTHER 306 and PANTHER 612 systems,

the PANTHER 612 Electronic Key System

MOST of the installation and programming

instructrons found on the PANTHER 612

Installation Guide

included with your

Electronic Key System installation Guide

will apply to both systems. This Update

system.

Sheet outlines all differences which must be

taken into considerarron when installing and

proaramminq the PANTHER 306 System

Side One of the PANTHER 612

Sheet. for changes to installar’on and

Electronic Key System installation Guide

provides a detailed illustration olus step-

programming.

by-step instructions for mount,ng and

connecting PANTHER 612 components.

Some of these components V/I not be used

when connecting only the PANTHER 306

System. Component differences are shown

below. Refer to the reverse o’ this Update

Incoming,C.O.iPBX/~entrex Lines

Door

Answer

Unit

PAW

f v

Line 1 R G

Line 3 R G Line 2 B Y

&conductor cable supplied

MUSIC SOURCE e

See the Power Fail Installation Diagram

on reverse for connection details.

Standard Set

or Attendant Set

Main

Distribution

Frame

DOOR

MUSIC

PANTHER 306

POWEF =IIL

Key Service Unit

STATUS WW

. ;)R(-JG= 1’.’

1 DROG=“.’

j .

13*n::.

RESET

STATIC’.5 10 to 15

50-pin ribbon plug

INSTALLATION PROCEDURE CHANGES -

(Refer to the PANTHER 612 Electron/c Key System

lnsta//arron G&e, S/de One)

STEP 2 - Telephone Line Connection

Do not COI!~HX! :clephone Irr~e 3 when Ihe Door AnswcrrnG Oo\ron

IS bcrny rrxi&x

STEP 3 - KSU to 66-Block Connections

The KSU ;wr :.z.1or IS labelled “SLattons 10-15”.

STEP 5 - Statron Wiring Connections

Ignore SIZ:,G~! Vi,irnbers 16 IO 21 and DRY CONTACTS LA:“1’~ or,

the StaIror Wjr,c~g CharI

STEP 6 - Door Answering

The Door ir!swerrrlg Option uszs C.O. lrne 3. Ewurc [ha:

lelephoric ..:ii’ 3 s no! connecreo to Ihe KSU.

STEP 7 - Call Data Recording Interface - Not Equlppes

Ignore 1t11s s!e:

STEP 9 - Power Fail Transfer

Only on’c P’T .:;II IS connecwc !o the PANTHER 306 SYS:~T.

Correct rns:a!‘a! 3n IS shown w:ow.

STEP 11 - External Pagrng Amplifier - NOI Eourpped ..?ore

lhrs sleo.

Side Two ;! the PANTHER 612 Electronic

Key System Installation Guide contains the

necessary infer-nation for selecting and

programmlng s,stem features. as well as tnformation

on :roubleshoz:,ng. The followrng changes apply

wFen progran-ung the PANTHER 306 System:

Whet :‘j,,ra~nm\. ; Coce 0000, qncri 81Line 3 LED

and III .f’~or’: LE3 INo LOUD BELL ‘?diure CXISIS )

l Whe.

:-;yra:‘lnw_: Coci: 3YYl (ZONE PAGING).

alsregz: 3;I zone 10’3rn-~a:lon a!ler Zorw 6

Wher ;~x4rawrnrr:j Coae 5Xx0. lgruri: all LOUD

BELL P ‘.GING rr::owat1on.

Whe!’ r’~yramnwy. Ignore all of Cooe 0061. (CDR

Srarl Dz.2 Reczrdq does not apply.)

Wher I-sgra’wirrq RINGING ASSIGNMENT. qnore

111Inter:: -. LE3 ior CoUe 2YY0 (No Ltw 1). arid lynore

all of c:a:< 2YYl

Wher- r-~yrammrng LINE GROUPING qoore 111

interco-. -ED ror C;de 6220 iNo Lrne 11, and Ignore all

of Coaf 6221

-0 KSU

.I Line 1,2 I

POWER FAIL TRANSFER

INSTALLATION DIAGRAM

FOR PANTHER 306 SYSTEM

ONLY

C01.2 CC: 2 TK’ 2 TK3.4 C’.: CNK

TRILLIUM

teltphsmsystefns

Spef2rfrc.c :.‘i and fea:,‘es zre subject 10 crsnge WI:-:.A nor :f

U.S. Marketing HeadquartersU.S.0peration.s Internationa’ Sales

Trlllrurn T+ ?I’ xe Sys[e,- s ‘Czrporatrorl Tr ..m Tele: :rle S;srerl:s Inc.

1675 Ma::,:*.-’ Blvd., 62: h,farch =:.;j, P 0 Bsl 13030, li3nala r?:wo. K2K 1X3

Costa M51.2 C-;lrforn~a 92625 Tel.: (714) 55i-3300 Tee; 0%::::. Te; (613) 592-2555. F& .5’3) 592-2555

Canadian Sales

Trrllrunl T< $;’ xe Sales “,c

155 Gore: . s.t=:er Roac 3~ ._ 206, Wrllowda:e

Ontarro. *,‘.I- :‘J5 Tel ‘1: 494-0522

‘C ,-

tizoyrryh: -37 TalLLI’JM Telephone .Sys:?:,js Inc

Tk’ Tradema.. :I TR’LLIUM Telephor:? Sys!e’--j lnc

3: -:364-l; ‘.larc’, 196: Prlnred I:, Cana-:

Technical Service Manual

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .,... . . . . . .._ . . . . . _. . . .., . . .

:::::::::::;::::“‘.......‘........................:~:::::~:~:;::::::::::::::::::::::::::: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . * . . . . . ** . . . . . . . *a . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..--.............................................................

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . *

-Panther 306/Panther 612

Electronic Key Telephone Systems

NOTE

Whentheorganizationfor thismanualwasfirst conceived,mostchapterswere

designedtoincludemorethanonesystem- sincealargenumberof functions,

features,andcharacteristicsarecommontoTFULLIUM’stelephonesystems.

Forexample,thePanther306and612ElectronicKeyTelephoneSystemsare

very similar;coverageof thesetwo systemswastohavebeencombinedinto a

singlechapter- asevidencedbythesinglePanther306/612tab.

However,interruptingthe

flow

of textandgraphicstoidentifyandexplainthe

differencesbetweenthesesystemsprovedtobetoodisruptive- andthepoten-

tialfor readerconfusionbegantooutweighthebenefitsof sharedcoverage.

In the

end,givingeachseparatesystemitsownchapterwasjudgedtobemuch

moreusefulto fieldinstallersandtechnicians(thismanual’sprimaryaudience)

in theirnormalworkenvironment,undertheirnormaloperatingcircumstances.

Therefore,thePanther306system- andonly thePanther306system- is

thesubjectof thefirst chapterunderthistab(startingatthefirst redpage),fok

lowedbytheseparatePanther612chapter(startingatthesecondredpage).

:::::::::::::::::::::=::::::::::::::::::::::::::::::::::::~:::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::~~:::~::~::::::::::=::::::::::::::~:::::::~:::::::::::,

TRILLIUM Telephone Systems

..................... .~..

Technical

Service

Manual

Table of

Contents

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ........... -- ....... - .............................................................................................................................,

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .e.. . . . . . . . . . . . . . . . . - . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “.. . . . . . . . . . . . . -..* . . . . . . ......................................... ... .......................... * ........... . ........................................

Topic Page

Chapter Introduction

PREFACE ....................................................................................................................................................

Intro-l

ABOUTTHIS CHAPTER.. .............................................................................................................................. Intro-l

QUICK-REFERENCE CHART .......................................................................................................................... Intro-2

SectionA - FCC Requirements

RADIO AND TELEVISION INTEW;ERENCE ...................................................................................................... A-l

HEARING AID COMPATIBILITY ....................................................................................................................... A-l

RESPONSIBILITIES ......................................................................................................................................... A-2

User Responsibiliti es..................................................................................................................................... A-2

Telco Responsibilities ..................................................................................................................................... A-2

SectionB - SystemComponents

STANDARDCoh4.Po~ ..............................................................................................................................

B-l

One Key Service Unit (KSU) ........................................................................................................................... B-l

to Six Telephone Sets.. ............................................................................................................................. B-l

OPTIONAL COMPONENTS ................................................................................................................................ B-2

One Door Answer Unit .................................................................................................................................. B-2

One Power Fail Transfer Unit ......................................................................................................................... B-2

Up to Five Off Premises Extension/Data Interface (OPX) units.............................................................................. B-2

Set Stands/Wall-Mounts.. ............................................................................................................................... B-2

Designation Cards. ........................................................................................................................................ B-3

Face Plates................................................................................................................................................... B-3

SectionC - Technical Specifications

CONNECTORS ................................................................................................................................................. C-l

ENvIRONMENTALREQUIREMENTS ................................................................................................................ C-l

POWERREQUIREMENTS .................................................................................................................................. C-l

STATION NUMBERING PL.AN........................................................................................................................... C-l

SYSTEM CAPABILITIES ................................................................................................................................... C-l

:::::::::::::::::: ..“.::z :::::::: ::::::::::::::: 1 ::::: “. ::::::: ~~::::y~:::::::: ::::............... - . . . . . . . . . . . . . I-.. . . . . . . . . . . . . . . . .

. . . . . . . . . . . . I.......... . . . . . . . . . . . - . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . - . . . . . . . . .

. . . . . - . . . . . . . . . - . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..-.-..........................................

. . . . . ..- ,,..............” . . . . . . . . . . . . - . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “......I

TRILLIUM

Telephone

’Panther.306

Systems

Page i

................................. ......... .

Table of

’Technical

Service

Contents

Manual .

.............._................................................................

:::::::::::::::::::::::::::::........................,............ ............................................................................-......-............-...................- ........................................

..................................a.......

.....................................................”................................”............................- .......................................

c ”

Topic Page

SectionD - Connection Procedures

STEP 1: INSTALLING THE KSU................................................................................................................... D-l

Site Preparation. ........................................................................................................................................... D-l

Backboard Installation .................................................................................................................. :............... D-l

System Uncrating ......................................................................................................................................... D-l

KSlJ

Instalhtion

........................................................................................................................................... D-l

STEP2 CONNECTING INCOMING TELEPHONE LINES ................................................................................ D-2

sTEP3: INSTALLING STATION WIRING ..................................................................................................... D-2

Station Wiring Table..................................................................................................................................... D-3

< STEP 4: CONDUCTING THE INITIAL SYSTEM AND STATION TESTS.. ......................................................... D-4

STEP 5: CONNECI’ING THE BACKUP BA’ITERY .......................................................................................... D-4

STEP 6: CONNECTING DOOR ANSWER UNIT AND DOOR MODULES.. ......................................................... D-4

Door Answer Unit Installation ........................................................................................................................ D4

Door Module Installation ............................................................................................................................... D-5

Door

Answer

Unit Test., ................................................................................................................................. D-5

STEP 7: CONNECI’ING THE MUSIC SOURCE ................................................................................................ D-6

Music Connection ........................................................................................................................................ D-6

Music

Test .................................................................................................................................................. D-6

STEP 8: CONNFLTING THE OPX UNIT ........................................................................................................ D-7 /

OPX Unit Connection ...................................................................................................................................

OPX Unit Test .............................................................................................................................................

STEP 9: CONNECTINGTHEPOWERFAILTRANSFERUNIT. ........................................................................ D-8

Power Fail Transfer Unit Installation ............................................................................................................... D-8

Power Fail Transfer Unit Test ......................................................................................................................... D-8

STEP lo: INSTALLING AN EXTERNAL AMPLIFIER/SPEAKER ...................................................................... D-9

SectionE - Systemand SetLayout

TYPICAL SYSTEM LAYOUT DIAGRAM (Standard Components only). .................................................................... E-l

TYPICAL SYSTEM LAYOUT DIAGRAM (Optional and External Components only). .................................................. E-2

TYPICAL POWER FAIL, TRANSFER UNIT LAYOUT DIAGRAM.. ........................................................................ E-3

SET LAYOUT DIAGRAM .................................................................................................................................. E-4

SETLAYOUT.. .................................................................................................................................................. E-5

” :::::. ‘:‘=-,‘*~:~.:~:~::::::::::::“‘......... * ..*.... . ..~..............::: :7”‘“‘:.;: ye: y::““‘::“““” :::. 2:: ::::::::::: :::::::::::::::::::::. z :::::::::::::::::::: :” ::::::::: :“:::z :::::::::::: “< :::::::::: ::“: