Trek DOMANE SL 2023 User manual
2023 DOMANE SL/SLR
SERVICE MANUAL
Rev 1 December 2022
2023 Domane SL/SLR
1
Safety
WARNING
Properly tighten hardware
Always tighten hardware to the specied torque.
Over-tightening hardware could deform or break the
hardware or components. Under-tightening hardware
could cause hardware or components to become loose.
Either situation could damage the bicycle and result in
injury to the rider.
WARNING
Reapply threadlocker
All reused-fasteners with pre-applied threadlocker must
be cleaned with isopropyl alcohol and have new thread-
locker applied before re-assembly. If threadlocker is not
applied, the fasteners may loosen which could damage
the bicycle and result in injury to the rider.
Legend
Apply appropriate grease
Apply threadlocker
Nm Torque
Cable (zip) tie
Contents
Routing — mechanical Routing — mechanical:
instructions
Routing — Di2 Routing — Di2:
instructions
Routing — eTap
Routing — eTap:
instructions
Fork and headset Install the headset Fork and headset —
standard stem
Seatpost
IsoSpeed IsoSpeed: remove
partsand install
Chainkeeper Storage door Specications
Copyright 2022 Trek Bicycle Corporation All Rights Reserved
2023 Domane SL/SLR
2
Routing — mechanical
1
3
2
5
5
2
6
0.7Nm
8
3
1
10
96.5Nm 4
3Nm 11
12
5
7
10 611
7
1
Front derailleur cable
2Rear derailleur cable
3Rear brake hose
4Front brake hose
5Rear derailleur hanger — W524188
6Rear derailleur hanger bolts (M3x12mm) — W524884
7Cable housing grommet — W329119
8Housing grommets — W330578
9Front derailleur hanger — W531901
10 Front derailleur hanger bolt (M5x16mm) — W543903
11 Cable guide bolts (M4x9mm) — W546731
12 Cable guide — W588188
2023 Domane SL/SLR
3
Routing — mechanical: instructions
1. Route the brake hoses.
8
2. Route the shift housings.
78
3. Insert the shift housings and rear brake hose into the
cable guide.
12
2023 Domane SL/SLR
4
Routing — Di2
3
5
56
0.7Nm
8
3
10
96.5Nm 4
3Nm 11
12
5
7
2
1
13
7
611
10
1 Rear Di2 wire
EW-SD300-I
2Front Di2 wire
3Rear brake hose
4Front brake hose
5Rear derailleur hanger — W524188
6Rear derailleur hanger bolts (M3x12mm) — W524884
7Di2 wire grommet — W317292
8Housing grommets — W330578
9Front derailleur hanger — W531901
10 Front derailleur hanger bolt (M5x16mm) — W543903
11 Cable guide bolts (M4x9mm) — W546731
12 Cable guide — W588188
13 Di2 battery — BTDN300
2023 Domane SL/SLR
5
Routing — Di2: instructions
1. Route the brake hoses.
8
2. Route the Di2 wires through the frame and connect
them to the battery.
78
13
12
3. Install the battery assembly.
4. Insert the rear brake hose into the cable guide
10
2023 Domane SL/SLR
6
Routing — eTap
1
5
3
4
0.7Nm
1
8
76.5Nm 2
3Nm 9
10
5
5
85
49
6
1Rear brake hose
2Front brake hose
3Rear derailleur hanger — W524188
4Rear derailleur hanger bolts (M3x12mm) — W524884
5eTap hole plug — W547906
6Housing grommets — W330578
7Front derailleur hanger — W531901
8Front derailleur hanger bolt (M5x16mm) — W543903
9Cable guide bolts (M4x9mm) — W546731
10 Cable guide — W588188
2023 Domane SL/SLR
7
Routing — eTap: instructions
1. Route the brake hoses.
6
2. Insert the rear brake hose into the cable guide.
110
2023 Domane SL/SLR
8
Fork and headset
5
3
1
4Nm
2
7
5.2Nm
4
5
6
9
10
11
12
13
13
1.5Nm
9-10Nm
8 4
8
1Top cap bolt (M6x35mm)
W547432
2Compression plug
3Top cap — W5274966
4Stem bolts (M5x15mm)
5305331
5Washers (M5)
6Stem — 5274584
7Routing cover — W5274600
8Bolt (M4x25mm) — W5274963
9Spacers (5mm) — 5296906
10 Spacers (15mm) — 5296905
11 Bearing cover — W5274267
12 Split ring — W5274269
13 Headset bearings — W540243
-7° +7°
W5274602
W5274603
W5274600
W5274601
W5274599
60-80mm stem
90-110mm stem
120-140mm stem
60-70mm stem
80-100mm stem
7
2023 Domane SL/SLR
9
Fork and headset: max spacers
WARNING
Below the stem
Do not exceed 40mm of headset spacers below the
stem. If there are more than 40mm of spacers, the
steerer tube could become damaged and break, causing
a crash resulting in injury.
40mm max
3
WARNING
Above the stem
Do not exceed 40mm of headset spacers above the
stem. If there are more than 40mm of spacers, the
steerer tube could become damaged and break, causing
a crash resulting in injury.
NOTE: If you add spacers above the stem, you must use a
standard top cap (without the indent).
40mm max
Standard top cap
This manual suits for next models
1
Table of contents
Other Trek Bicycle manuals
Trek
Trek 2021 E-CALIBER Operating manual
Trek
Trek Domanee 2017 User manual
Trek
Trek Alloy Rail 5 Gen 3 User manual
Trek
Trek MY22 Top Fuel User manual
Trek
Trek DOMANE AL GEN 4 2024 User manual
Trek
Trek BOONE 2022 Operating manual
Trek
Trek Carbon Rail 9.8 Gen 3 2022 Operating manual
Trek
Trek Farley Carbon 9.6 2023 User manual
Trek
Trek SPEED CONCEPT SLR 2022 Operating manual
Trek
Trek DOMANE+AL 2023 User manual
Trek
Trek Powerfly FS Series User manual
Trek
Trek 2022 E-CALIBER Operating manual
Trek
Trek DOMANE+ AL 2023 User manual
Trek
Trek 300 User manual
Trek
Trek FX SPORT CARBON 2022 Operating manual
Trek
Trek Rail 9.5 Gen 4 User manual
Trek
Trek Lync Owner's manual
Trek
Trek Ride Plus User manual
Trek
Trek MARLIN 6 User manual
Trek
Trek Fetch+ 4 User manual
