Symbol PTC-960X User manual

PTC-960X

User's Guide

On December 1, 2000 Symbol Technologies, Inc. completed the purchase

of Telxon Corporation. References made throughout this document to

"Telxon" or "Telxon Corporation" are be replaced with "Symbol" or

"Symbol Technologies, Inc.", respectively. Any questions, contact your

Symbol representative.

No part of this publication may be reproduced or used in any form, or by any electrical or

mechanical means, without permission in writing from Symbol. This includes electronic or

mechanical means, such as photocopying, recording, or information storage and retrieval

systems. The material in this manual is subject to change without notice.

Symbol reserves the right to make changes to any software or product to improve reliability,

function, or design.

Symbol does not assume any product liability arising out of, or in connection with, the

application or use of any product, circuit, or application described herein.

No license is granted, either expressly or by implication, estoppel, or otherwise under any

Symbol Technologies, Inc., intellectual property rights. An implied license only exists for

equipment, circuits, and subsystems contained in Symbol products.

Symbol is a registered trademark of Symbol Technologies, Inc. Other product names

mentioned in this manual may be trademarks or registered trademarks of their respective

companies and are hereby acknowledged.

Symbol Technologies, Inc.

One Symbol Plaza

Holtsville, New York 11742-1300

http://www.symbol.com

Symbol Support Center: 1-800-653-5350

GUIDE TO THE

PTC-960X

Guidetothe

PTC-960X

Part Number: 16670-701-01

Release Date: 9/17/93

Telxon, TCAL (Telxon Common Application Lan-

guage), and RAMSaver are registered trade-

marks of Telxon Corporation.

MS-DOS is a registered trademark of Microsoft

Corporation.

The information contained in this manual is

subject to change without notice.

Telxon Corporation shall not be liable for

technical or editorial omissions or mistakes in

this manual nor shall it be liable for incidental

or consequential damages resulting from your

use of the information contained in this manual.

This manual is copyrighted. All rights are

reserved. No part of this manual may be

photocopied or reproduced in any form without

the prior written consent of Telxon.

Contents

FCC statement . .. .. .. .. .. .. .. .. .. .8

Safety information . .. .. .. .. .. .. .. .. .9

PTC equipped with a short-range laser scanner9

PTC equipped with a long-range laser scanner10

Disposing of nickel-cadmium batteries . .. .10

Scope . .. .. .. .. .. .. .. .. .. .. .. .11

Overview of the PTC-960X . .. .. .. .. .. .. 12

Entering data . . . . . . . . . . . . . . . . . 13

Communicating data . . . . . . . . . . . . . 13

Flash programming . .. .. .. .. .. .. .13

Getting started . .. .. .. .. .. .. .. .. .. 14

Unpacking the PTC-960X . . . . . . . . . . . 14

Installing the battery pack . . . . . . . . . . 15

Charging the battery pack . . . . . . . . . . 15

Checking the PTC-960X . . . . . . . . . . . 16

Parts . .. .. .. .. .. .. .. .. .. .. .. .17

Accessory connector . . . . . . . . . . . . . . 17

Bar-code scanner .. .. .. .. .. .. .. .17

Bar-code scanner trigger .. .. .. .. .. .17

Battery charger . .. .. .. .. .. .. .. .19

Battery compartment . . . . . . . . . . . . . 19

Communication contacts. .. .. .. .. .. 19

Display . . . . . . . . . . . . . . . . . . . . . 19

End cap/battery pack assembly . .. .. .. .20

FlashEPROM. .. .. .. .. .. .. .. .. 20

Handle. .. .. .. .. .. .. .. .. .. .. 21

Keyboard . . . . . . . . . . . . . . . . . . . 21

ENTER/YES key . . . . . . . . . . . . . 22

ON/OFF key . . . . . . . . . . . . . . . . 22

SHIFT key . . . . . . . . . . . . . . . . . 22

ÄÄ

Keyboardoverlay . . . . . . . . . . . . . . . 22

RJ-41-to-RS-232 adapter cable (optional) . . 23

Status indicators . . . . . . . . . . . . . . . 23

Charging . .. .. .. .. .. .. .. .. .23

Good Scan . . . . . . . . . . . . . . . . . 23

Low Bat . . . . . . . . . . . . . . . . . . 24

Scan . .. .. .. .. .. .. .. .. .. .24

Wrist strap . .. .. .. .. .. .. .. .. .24

Features . .. .. .. .. .. .. .. .. .. .. .25

Autodiscrimination between bar codes . .. .25

Automatic off. . . . . . . . . . . . . . . . . 25

Automatic return aton . . . . . . . . . . . . 25

Backlight . .. .. .. .. .. .. .. .. .. 25

Battery backup . . . . . . . . . . . . . . . . 26

Beeper. .. .. .. .. .. .. .. .. .. .. 26

Clock . .. .. .. .. .. .. .. .. .. .. 27

Communication . .. .. .. .. .. .. .. .27

Display contrast . . . . . . . . . . . . . . . . 27

Memory . .. .. .. .. .. .. .. .. .. .28

Communication and connections . .. .. .. .. .. 29

Connecting cables . .. .. .. .. .. .. .. 29

Disconnecting cables . . . . . . . . . . . . . 32

Connecting tothe optional

communication cradle . . . . . . . . . . . 33

Scanning bar-code labels . .. .. .. .. .. .. .34

Maintaining the PTC-960X . .. .. .. .. .. .. 36

Operating conditions . . . . . . . . . . . . . 36

Handling the PTC-960X . . . . . . . . . . . 36

Storing the PTC-960X . .. .. .. .. .. .37

Cleaning the PTC-960X . .. .. .. .. .. .38

Servicing the PTC-960X . . . . . . . . . . . 38

Replacing the battery pack . .. .. .. .. .. .. 39

Removing the battery pack . . . . . . . . . . 39

Installing a new battery pack . .. .. .. .40

Programming the flash EPROM . .. .. .. .. .. 41

Before you begin . . . . . . . . . . . . . . . . 41

Procedure. .. .. .. .. .. .. .. .. .. 43

Troubleshooting . .. .. .. .. .. .. .. .. .. 49

If the PTC does not turn on . . . . . . . . . . 49

If the bar-code scanner does not read a label 49

If you experience any other problems with

your PTC-960X . .. .. .. .. .. .. .50

Appendix A . .. .. .. .. .. .. .. .. .. .. 51

Specifications . . . . . . . . . . . . . . . . . 51

Physical . .. .. .. .. .. .. .. .. .51

Electrical . .. .. .. .. .. .. .. .. 51

Bar codetypessupported . . . . . . . . . 52

Communication . .. .. .. .. .. .. .53

Appendix B . .. .. .. .. .. .. .. .. .. .. 54

Accessory part numbers . . . . . . . . . . . 54

Appendix C . .. .. .. .. .. .. .. .. .. .. 56

Communication connections . . . . . . . . . 56

Appendix D . .. .. .. .. .. .. .. .. .. .. 64

LED status indicators . . . . . . . . . . . . . 64

Glossary. .. .. .. .. .. .. .. .. .. .. .65

Index . .. .. .. .. .. .. .. .. .. .. .. .69

Figures

1.Parts of the PTC-960X . .. .. .. .. .18

2.Connecting a cable . .. .. .. .. .. .31

3.Scanning a bar-code . .. .. .. .. .. .35

4.Removing the battery pack . . . . . . . . 39

5.RJ-41-to-RS-232 25-pin adapter cable . .56

6.RJ-41-to-RS-232 9-pin adapter cable .. .57

7.PTC-to-1/2 duplex modem cable . . . . . 58

8.PTC-to-fullduplex modemcable. . . . . 59

9.PTC-to-host(DTE)cable . .. .. .. .. 60

10.Cloning cable, RJ-41-to-RJ-41 . .. .. .61

11.PTC-to-IBM PC/AT download cable . . . 62

12.PTC-to-IBM PC/XT download cable . . . 63

Tables

1.Accessory partnumbers . . . . . . . . . 54

2.LED status indicators . . . . . . . . . . . 64

FCC

statement

This equipment has been tested and found to

comply with the limits for a Class Adigital de-

vice, pursuant to Part 15 of the Federal

Communication Commission (FCC) rules. These

limits are designed to provide reasonable protec-

tion against harmful interference when the

equipment is operated in a commercial environ-

ment. This equipment generates, uses, and can

radiate radio frequency energy and, if not in-

stalled and used in accordance with this

instruction manual, may cause harmful interfer-

ence to radio communications. Operation of this

equipment in a residential area is likely to cause

harmful interference, in which case users will be

required to correct the interference at their own

expense.

ÄÄ

Table of contents

Other Symbol Handheld manuals

Symbol

Symbol QRG 68XX series User manual

Symbol

Symbol SPT 1500 User manual

Symbol

Symbol PPT 2800 Series User manual

Symbol

Symbol ORG SPT 1550 User manual

Symbol

Symbol MC909X User manual

Symbol

Symbol MC9000-G Installation and operation manual

Symbol

Symbol PDT 8100 Series Installation and operation manual

Symbol

Symbol QRG PDT 8100 User manual

Symbol

Symbol MC909X Assembly Instructions

Symbol

Symbol SPT 1800 Series User manual

Symbol

Symbol MC9000-G Installation and operation manual

Symbol

Symbol WT4000 - Wearable Terminal - Win CE 5.0 Professional 520... User manual

Symbol

Symbol PTC-960XRF User manual

Symbol

Symbol PPT 2700 Series Installation and operation manual

Symbol

Symbol Series 6800 Installation and operation manual

Symbol

Symbol PDT 8100 Series Installation and operation manual

Symbol

Symbol PPT 2800 Series Installation and operation manual

Symbol

Symbol PPT 2800 Series Installation and operation manual

Symbol

Symbol MC9090-G RFID Owner's manual

Symbol

Symbol Series 3300 Instruction Manual

Symbol

Symbol PDT 8000 Series User manual

Symbol

Symbol MC18 Installation and operation manual

Symbol

Symbol PDT 8000 Series User manual

Symbol

Symbol MC909X User manual

Popular Handheld manuals by other brands

Honeywell

Honeywell Dolphin 9900 user guide

Honeywell

Honeywell CN75 user guide

MiTAC

MiTAC Mio 168 user manual

Wasp

Wasp WDT92 user manual

Texas Instruments

Texas Instruments TI-Nspire user guide

AXEM Technology

AXEM Technology MBS user guide

Armstrong

Armstrong Brain Wave Hardware & software installation

Unitech

Unitech TB128 user manual

Unitech

Unitech HT1 1D Batch user manual

Ingenico

Ingenico IWL220 GPRS Quick reference guide

Intermec

Intermec CK61 user manual

Acer

Acer n20 manual

Intermec

Intermec CK61 quick start guide

Docomo

Docomo F-04H instruction manual

Toshiba

Toshiba e350 Series user manual

Palm

Palm Tungsten E2 supplementary guide

Alien

Alien ALR-H460 user guide

ViewSonic

ViewSonic Pocket PC V36 user guide