SolarEdge 330kW User manual

Version 1.0, December 2023

SolarEdge 330kW inverter internal fan for short bracket replacement - Support kit manual

1

SolarEdge 330kW inverter internal fan for short

bracket replacement – Support kit manual

This manual describes the procedure for replacing the SolarEdge 330kW Inverter Internal Fan

for Short Bracket.

Revision history

Version 1.0, December 2023 – Initial release

Kit contents

SolarEdge 330kW Inverter Internal Fan for Short Bracket PN FLD-3PH-OR-IN-01.

Required tools

Torque screwdriver

5mm hex bit

Flat screwdriver

Voltmeter

Before you begin

1. Set the P/1/0 switch to “0” (OFF).

2. Turn the DC ON/OFF Switch to the OFF position.

3. To lock the DC Switch, pull the white tab out away from the blue handle and insert a

padlock through one of the holes.

4. Lock the padlock.

Version 1.0, December 2023

SolarEdge 330kW inverter internal fan for short bracket replacement - Support kit manual

2

DC ON/OFF switch safety padlock

5. Disconnect AC power to the inverter by turning OFF the circuit breaker in the power

distribution panel.

6. Wait at least five minutes for the DC Voltage inside the inverter to drop to a safe level.

7. As an additional safety precaution, lock the power distribution panel.

Remove the cover

NOTE

The inverter cover assembly is too big for one person to handle safely. SolarEdge recommends that

two people remove and handle the cover assembly.

To remove the inverter cover, use a screwdriver with a 5mm hex bit to release the screws

holding the cover in place.

Inverter Cover Assembly

WARNING!

Before doing any maintenance work on the inverter, test for safe AC and DC voltages.

Version 1.0, December 2023

SolarEdge 330kW inverter internal fan for short bracket replacement - Support kit manual

3

Remove the damaged fan

1. Using a flat screwdriver, loosen the two screws holding the fan.

2. Pull the fan and bracket out of the inverter.

Remove the fan and bracket

3. Disconnect the fan’s power cable.

Install the replacement fan

1. Reconnect the fan’s power cable. Pull gently on the connector to make sure it is properly

connected.

2. Insert the fan into position.

Insert the fan

3. Ensure that the holes at the bottom of the bracket engage with the two guide pins.

NOTE

When installing the fan and bracket, the bracket must not touch the bus bar.

4. Using a flat screwdriver, tighten the fan assembly clamping screws to a torque of 2.4N·m

(21.2lbf·in).

Version 1.0, December 2023

SolarEdge 330kW inverter internal fan for short bracket replacement - Support kit manual

4

5. Place the cover assembly in position and, using a torque wrench with a 5mm hex bit,

tighten the screws to a torque of 3.9N·m (34.5lbf·in).

6. Tighten the screws in the following sequence:

Screw tightening sequence

Turn on the power

1. Unlock the power distribution panel and turn ON the AC circuit breaker/s.

1. Remove the padlock and turn the DC Switch ON.

2. Set the P/1/0 switch to “1” (ON).

Table of contents

Other SolarEdge Inverter manuals

SolarEdge

SolarEdge Solar Inverter User manual

SolarEdge

SolarEdge StorEdge SE7600A-USS User manual

SolarEdge

SolarEdge SE3680H User manual

SolarEdge

SolarEdge SE3K-RWB User manual

SolarEdge

SolarEdge SE15K User manual

SolarEdge

SolarEdge SE2500H User manual

SolarEdge

SolarEdge StorEdge SE10K-RWS User manual

SolarEdge

SolarEdge SE3000 User manual

SolarEdge

SolarEdge storedge User manual

SolarEdge

SolarEdge SE5000H-US User manual

SolarEdge

SolarEdge storedge User manual

SolarEdge

SolarEdge storedge User manual

SolarEdge

SolarEdge Energy Bank User manual

SolarEdge

SolarEdge SE8000H-AU User manual

SolarEdge

SolarEdge SE8k User manual

SolarEdge

SolarEdge StorEdge SE5K User manual

SolarEdge

SolarEdge EV Series User manual

SolarEdge

SolarEdge StorEdge SE7600A-US1 User manual

SolarEdge

SolarEdge Home Hub Inverter Three Phase User manual

SolarEdge

SolarEdge Home Battery 48V User manual

SolarEdge

SolarEdge SE K Series User manual

SolarEdge

SolarEdge SE K Series User manual

SolarEdge

SolarEdge Inline Energy Meter User manual

SolarEdge

SolarEdge StorEdge Solution with Backup User manual

Popular Inverter manuals by other brands

Fourgroup

Fourgroup Easy use and Programming Handbook

Velleman

Velleman PI300M user manual

Sungrow

Sungrow SG350HX-US user manual

WilTec

WilTec 61897 Operation manual

SMA

SMA SUNNY BOY STORAGE 2.5 Quick reference guide

Simplicity

Simplicity LANDLORD 316 product manual

Santak

Santak SMAX 3000 user manual

ATON

ATON RA.Store-3 user manual

ZIEHL-ABEGG

ZIEHL-ABEGG FXET4AMQ operating instructions

Tektronix

Tektronix CFG250 Operator's manual

Champion

Champion 200989 Operator's manual

Vanner

Vanner 20-500 Series owner's manual

GE

GE GEP user manual

Astrel Group

Astrel Group Power Reducer Installation and instruction manual

MULTIQUIP

MULTIQUIP GDP-5H Operation and parts manual

GoWISE

GoWISE PS1007 user manual

Promate

Promate PM13500D ES Operator's manual

Mastervolt

Mastervolt WHISPER 3.5M3000 RPM user manual