Pro-Line Boats 33 Express User manual

Table of Contents

I. Introduction………. Page 5

Dealer/Customer responsibilities

II. Safety……….Page 5

Regulations

Equipment

Passenger safety

Rules of the road

Hazardous conditions

Alcohol

Carbon monoxide

Fire

Flooding

III. Controls……….Page 7

Ignition

Shift/Throttle

Steering

Instruments

Switches

Trim Tabs

IV. Systems……….Page 12

FreshWater

SeaWater

Head/ Waste

AC/Heat

Fuel/Oil

Electrical

Eco-Sound Exhaust System

After Market Accessories

V. Operation and Performance……….Page 30

Fueling

Starting

Service and Care

Winterization, Storage, Mooring

Propeller

VI. Service and Care……….Page 31

Fiberglass/Gelcoat

Marine Growth

Plexiglass

Stainless steel/Aluminum

Canvas

Upholstery: Vinyl, Fabric

Corrosion Protection – Zinc Anodes

Winterization, Storage, Mooring

VII. Miscellaneous

Trouble Shooting Chart……….Page 35

Important Data For Identifying Your Boat……….Page 36

Specifications……….Page 38

Nautical Terms……….Page 40 through Page 49

Basic Seamanship……….Page 50

Accident Form……….Page 55 & Page 56

Rules of Seamanship……….Page 58

Navigational and Lateral Aids……….Page 62 & Page 63

Maintenance Log

Float Plan

Waterline Dimensions

Electrical Drawings

ILLUSTRATIONS

1. Helm Station……….Page 8

2. Warning Placard……….Page 10

3. Trim Tab Operation……….Page 11

4. Marine Sanitation Installation……….Page 13

5. Seacock & Raw Water Strainer……….Page 14

6. Water Systems……….Page 15

7. Battery Switch Drawing……….Page 18

8. Battery Switch Panel Drawing……….Page 19

9. Battery Switch Panel Photograph……….Page 21

10. Helm Constant Power Photograph……….Page 21

11. Eco Sound Exhaust Auto Cad Drawings……….Page 22

12. Eco Sound No Load Warnings……….Page 23

13. Eco Sound Sling Locations……….Page 24

14. Eco Sound Photographs……….Page 25

15. Steering Installation, Lower Station……….Page 27

16. Steering Installation, Upper Station……….Page 28

17. Plastic & Trash Warning Placard……….Page 52

18. Oil Discharge Warning Placard……….Page 53

19. Warning Placards……….Page 54

20. Accident Report Form……….Page 55 & 56

21. Waterline Dimensions……….Page 57

22. Navigational Aids Chart……….Page 62

23. Lateral Aids As See Entering From Seaward……….Page 63

24. Fuel Log……….Page 54 & Page 65

25. Maintenance Log……….Page 66 & Page 67

26. Float Plan Format……….Page 68

27. Main Wiring Harness……….(Pull-out rear pages)

Introduction

Congratulations! You are now the proud owner of a new Pro-Line 33 Express fishing boat.

Welcome to the proud family of satisfied Pro-Line owners. Every expedition lets you enjoy the

outstanding features designed into every boat we construct. Your new Pro-Line is more than just

a boat; it's a lifestyle.

Pro-Line’s commitment to the needs and wishes of the professional sport fisherman has resulted

in a superior fishing craft, providing you with comfort, performance, security and fish-ability.

All of our boats comply with U.S. Coast Guard (USCG) safety regulations. They are designed

and crafted in accordance with the National Marine Manufacturers Association (NMMA),

American Boat and Yacht Council (ABYC) standards, and the optional Common European

directive (CE),

This manual (to be kept onboard your Pro-Line) is designed to provide you with information

necessary for safe, efficient operation and care of your new Pro-Line. To maximize your

enjoyment and safety, take the time now to carefully review the documentation in your owner’s

pack and this manual, and really get to know your boat.

Dealer’s Duties

Your dealer's responsibilities include but are not limited to:

* Pre-delivery verification of proper rigging and operation.

* Providing adequate orientation in general operation of your Pro-Line. This includes an explanation of

specific safety considerations regarding the use of systems and components.

An explanation of owner’s packet literature and warranty registration cards for all separately

warranted equipment and accessories.

* Explaining local and out of area service procedures during and out of warranty periods.

Customer Responsibilities

*Be proficient in boat handling and safety. - THIS MANUAL IS NOT INTENDED TO PROVIDE

COMPLETE TRAINING ON ALL ASPECTS OF GENERAL BOAT OPERATION.

* Read and understand the limited warranty.

* Read all literature and instructions and use and maintain all equipment as directed.

* Examine the boat at time of delivery to ensure that all systems function normally.

* Learn about and operate boat in accordance with local, state and federal laws, regulations and

registration forms.

* The owner is legally responsible for all liabilities of operation – secure insurance protection.

Safety

Your Pro-Line boat has been constructed with safety in mind, however the ultimate safety of you and your

passengers is in your hands. Plan your trips carefully. Insure ample fuel supply and reserve. Tell someone where

you are going and when you expect to return. Keep current charts onboard. Read and observe USCG

boating safety circulars.

Regulations

The USCG is the authority of all the waterways. State local authorities enforce boating regulations. You are

subject to marine traffic laws and "Rules of the Road" on federal and state waterways, and must submit to

boarding if requested by proper authority. There are many publications available from the Coast Guard

concerning regulations and more. For additional information call the boating safety hot line at 1(800) 368-5647.

Equipment

USCG regulations require the following equipment while operating your boat:

* Fire extinguisher

* Personal Flotation Device (PFD) for each occupant

* One throw-able PFD

* Sound signal device

* Navigational lights if operated at night

* Sight signal (flare- night, orange flag- day) when in coastal waters or Great Lakes.

* Anchor and sufficient line

In addition, here is a list of suggested equipment you should have aboard your Pro-Line:

* First aid kit and blankets * Sea anchor with line

* Mooring lines and fenders * Bailing device

* Combination oar / boat hook * Tool kit and lubricant

* Spare prop, nut & washer * Spare fasteners, hose clamps, plugs

* Spare fuses and bulbs * Binoculars or telescope

* Local charts and compass * Water proof flashlight

* 2 way radio (with proper license) * EPIRB (emergency beacon)

* Floating key chain & spare keys * Navigation device

* Emergency food and water * Waterproof matches or lighter.

Passenger Safety

You are responsible for the safety and conduct of your passengers, make sure that:

* You instruct passengers on proper use and location of PFD’s. Children and non-swimmers should

wear one at all times.

* When underway each passenger is in a safe location, and knows to keep the boat balanced.

* At least one other person knows how to operate the boat in case of emergency.

* They are aware of dangers of the prop, and the possibility of sudden maneuvers and jolts.

* To turn the engine off and remove key when swimmers are near the propellers or when using the

dive platform.

* All keep away from lines under stress should they break and recoil.

Rules of the Road

Know and use the rules of the road, the information here is only a brief overview. For detailed information contact

the USCG.

Audible warning signals:

* One short horn blast: starboard course change.

* Two short horn blasts: port course change.

* Three short horn blasts: astern operation.

* Five horn blasts: doubt about previous signal, or danger.

* A single five-second blast every minute for fog operation

When overtaking give-way vessel announces intention with horn blast(s) and waits for same response then

completes maneuver.

When approaching head-on, both boats give way after giving appropriate horn blast (Preferably starboard).

When crossing, a vessel converging from the starboard has right of way, the port vessel gives way (both

acknowledge with one short horn blast).

Know and observe navigational buoys and markers.

Give way to craft under sail.

Hazardous Conditions

Keep track of weather developments and avoid hazardous conditions, when forced to operate your Pro-line in

storm conditions:

* Wear Pfd’s

* Stow loose gear and equipment.

* Place heavy items as low as possible.

* Head for the easiest to reach safe location.

* Reduce speed. If the boat leaves the water, you're moving too fast.

* If power fails, rig a sea anchor off the bow (an empty ice chest in a pinch).

* Stay with boat if it capsizes, unless it is burning out of control.

Alcohol

Never operate a boat while under the influence of drugs or alcohol. Doing so is a Federal

offense.Don't drink and drive. If you have been drinking have someone drive who has not been drinking.

Carbon Monoxide

Be aware of and avoid conditions that can cause carbon monoxide poisoning (see USCG boating safety circular

77). Sources of carbon monoxide include any gas or diesel engine, any flame such as a charcoal grill, stove or

heater. Carbon monoxide can accumulate to deadly levels in enclosed spaces. Always ventilate occupied areas of

vessel with fresh clean air.

Fire

Be aware of and avoid conditions that lead to accidental fire. Guard against and watch for fuel spills and leaks.

Inspect wiring for damage or exposure that could lead to short circuits or arcing. Make sure those who smoke are

vigilant. Smoking is an ignition source that can start a fire. Don't allow smoking while fueling. Keep a USCG

approved fire extinguisher aboard at all times. Inspect the fire extinguisher regularly. Learn how to properly use

it and instruct other how to use it. Use water to fight fire as a last resort and then only after making arrangements

to abandon the boat if a fire should get out of control.

If a fire is burning out of control and you must abandon the boat keep the following in mind:

* Abandon the boat into the wind to minimize burn risk from floating fuel.

* Wear a PFD unless you must swim under burning fuel.

* If swimming under burning fuel throw a PFD outside of the burning area and swim under it.

Flooding

Be aware of the conditions that can cause your boat to flood with water and avoid them.

Possible causes of flooding include damage to hull or thru-hull fitting, waves washing into the boat, and water-

entering cockpit due to improper loading. If you allow water to enter the boat faster than the bilge pump can

expel it, the boat will become flooded and may capsize or sink.

Controls

Ignition

The ignition switch has three positions; off, on, and start. To start the engine, attach the safety lanyard, turn the

key clockwise against the spring pressure to the start position. As soon as the engine starts release clockwise

pressure allowing the spring tension to return the switch to the on position. If the engine fails to start in 5 seconds

of cranking allow the starter to cool off for 10 seconds and then repeat this procedure. For detailed instructions

see the engine manual located in the Important Papers Pack.

Safety Shut Down

The Safety shut down switch shuts off the engine in case the operator is thrown from the boat or incapacitated. To

ensure proper functions always attach the lanyard securely to the operator.

Shift/Throttle

Your Pro-Line can be ordered with several different shift and throttle systems. Refer to the owner's packet to find

the manual pertaining to your particular installation. Separate throttles control the speed of each motor. Push the

levers ahead for full throttle; pull fully back for idle. Throttle back to idle before shifting into or out of gear.

Avoid over speeding the motors. The shift levers each have three positions, forward, neutral, and reverse. To

shift into forward push all shift levers fully ahead as one unit, pull all the way back for reverse. When starting the

engines, centralize the levers to the detent for neutral. The shift levers are equipped with a neutral safety switch to

prevent the motor from starting in gear. The shift levers can be operated independently for precise maneuvering

(do so at slow speed only). Refer to the engine manuals in your owner’s packet for more specific information.

Figure 1 - Helm Station

Steering

Your Pro-Line is equipped with a self-contained hydraulic steering system. The helm is a manually operated

hydraulic pump. When the steering wheel is turned the helm pumps fluid into one side of the cylinder and

evacuates fluid from the opposite side of the steering cylinder. This will extend or retract the steering rod, causing

the boat to turn. Periodically check the fluid level and fill if necessary. If the system needs fluid, refer to steering

manual in the important papers packet. After every 24 hours of operation check all nuts, caps, and hose fittings

for signs of leaking fluid and tighten if necessary. Check that the hoses are not chafing, or kinking on sharp

corners. Also check that hose ends are not damaged or distorted by the clamps. If your steering does not operate

properly, check the fluid level first, then look for leaking hoses or fittings and finally for air in the system. Read

STEERING INSTRUCTIONS located in the important papers packet. Notify your dealer immediately if any

problems occur with the steering system.

Instruments

Your Pro-Line instrumentation will vary according to the engine models that your boat has. Therefore the

following descriptions are general. For more specific questions that you may have, or for detailed information,

contact your dealer.

Fuel Gauge

Differences in temperature, humidity, speed and trim can affect fuel use and possibly the accuracy of this gauge. It

is important to verify the fuel flow in gallons per hour for your boat and make note of your gauge position with

respect to time for different RPM settings. No gauge can give 100% accuracy. If you notice unusually high or low

fuel consumption, investigate further to see if the engine is using more fuel than normal. Then check to see if

tank gauge has failed. Consult your dealer if there is any question about how much fuel is on board. You should

keep records of fuel you use on the pages marked “Fuel Log” in the back of this manual.

Water Temperature

The water temperature gauge indicates the internal water temperature of your engine. Your engine is equipped

with a thermostat to quickly bring the engine up to its optimum operating temperature range. Read the engine

manual for exact readings. Your engines are equipped with an audio alarm system indicating an over-heat

condition. If the gauge or alarm indicates an over heat condition, immediately shut the engine off. Then you

must close the seacock and open the water strainers to inspect for obstructions such as aquatic vegetation or mud.

After finding the source of the over heating, restart engine and confirm that the over heat problem has been solved

by monitoring the temperature gauges and listening for the audio alarm. The Eco Sound by pass tubes will allow

exhaust gases to escape by way of the 2” through hull fittings when the boat is not on plane. These fittings are

located above the water line and all the way aft on both of the hull sides. There will be no water flowing out of

these fittings, so it is important to monitor the gauge to determine if the cooling water is flowing freely through

the engine once again.

Oil Pressure

The oil pressure gauge should be checked immediately when starting the engine. The pressure range is available

in the engine manual. Your engines are equipped with an audio alarm system indicating a low oil pressure

condition. Follow the procedures recommended in the engine manual and if low oil pressure exists consult your

dealer.

Volt Meter

The voltmeter indicates battery voltage. A normal reading is between 12 to 15.5 volts.

Never leave port if the battery condition is not correct. You may not be able to restart your engines with batteries

that are not properly charged. Notify your dealer immediately if the gauge readings are not correct. Check battery

voltage prior to starting and again after the engine is running at idle to insure a properly working charging system.

Tachometer

The tachometer indicates the revolutions per minute (RPM) of your engine. Do not operate the engine beyond the

limits stated in your engine manual. Abnormally low tachometer readings (for a given throttle setting) indicate a

loss of engine performance. Check the prop first. A reading higher than normal indicates a ventilating or

cavitating propeller or propeller damage. Notify your dealer before operating your boat under these conditions.

Rudder Indicator

There is a sender installed on the starboard side aft that sends information to a gauge at the helm. This will

display the rudder position when the ignition is turned ON.

Speedometer

The speedometer indicates the speed of your boat in Miles per hour (MPH).

The gauge operates by sensing water impact pressure from the pitot tube mounted on the transom. If the gauge

fails to give a reading, check for a blocked or loose pickup.

Options

See your dealer for the options list for this model boat. Options installed at the factory will have operating and

maintenance instructions located in the important papers packet.

Switches

Windlass

Refer to the windlass manual for operation of the windlass. A 30 Amp breaker located next to the windlass switch

mounted on the console protects the Windlass.

Lights

For operation at night, your Pro-Line is equipped with navigation and anchor lights to indicate your position to

other boaters. While running after dark the navigation lights are required to be on and visible to other boaters.

Visually verify operation and lack of obstructions. Lights are also provided for the cockpit, bait-well, helm and

cabin.

BilgePump

Your Pro-Line is equipped with an automatic bilge pump system with a manual override. The pump is located at

the aft end of the bilge at the keel. The pump is mounted as low as possible. If the pump runs for a long time it

may mean that water is entering the bilge faster than the pump can expel it. Investigate and correct the cause

immediately. The automatic float switch is wired directly to the battery selector switch through a circuit breaker

located on the battery switch panel. Read page 17 for more information about the battery switch panel. Keep the

bilge area clean and free from debris that could block the bilge pump ports. The helm switch overrides normal

automatic operation on the primary pump. Circuit breakers are located at the helm. Keep the battery charged that

powers the bilge pumps. If the battery is discharged and flooding occurs, the boat could sink causing damage and

possible loss of life or property.

Blower

Operating the blowers prior to starting the engine is a procedure that must be followed. Always operate the

blower for a minimum of four minutes and check bilge for fumes before starting the engine. Operate the blower

whenever the engine is running, the boat is stopped or when you are running at low speeds. At planing speed air

will be forced into the bilge and will ventilate the engine compartment without running the blowers.

WARNING

Gasoline Vapors Can Explode

Before starting the engine check the

bilge and engine compartments for

gasoline or vapors. Operate blower

four minutes prior to starting engine.

Run blowers below cruising speeds.

Figure 2 - Fuel Warning Placard

Breaker Switches

Circuit breakers or fuses protect the wiring on your Pro-Line. Breakers are located next to the switches or on the

main breaker panel. If a device stops working immediately check to see if the circuit breaker is tripped or the fuse

is blown. A tripped breaker will protrude from its set position, indicating that the circuit has been overloaded.

Turn off the device(s) on the circuit then reset the breaker by pushing in once. If the breaker does not reset or if it

resets and then pops out again after the device is turned back on, then a short circuit exists or your device may be

damaged, overloaded or faulty. Correct the problem and then reset the breaker. If the breaker continues to pop

and you are certain the device, switch and wiring are in good repair; either the breaker is too small for the load or

it is faulty. Reduce the load or replace the breaker. Have this work done by your dealer or a certified marine

electrician.

Shaft Alignment

Aligning the engine with the propeller shaft is critical for smooth operation of your Pro-Line. The shafts are

properly aligned at the factory, but may change slightly after the boat is in use. Have your dealer heck the

alignment after delivery or after an extended lay-up. A slight misalignment can result in a loss of power, a

vibration or wear in the bearings. Your dealer should check the alignment occasionally, particularly if there is a

vibration, drumming sound or a loss of RPM.

Table of contents

Other Pro-Line Boats Boat manuals

Pro-Line Boats

Pro-Line Boats 2009 26 XP Pilot User manual

Pro-Line Boats

Pro-Line Boats 2007 24 Walk User manual

Pro-Line Boats

Pro-Line Boats 2009 Grand Sport 29 User manual

Pro-Line Boats

Pro-Line Boats 2004 30 Express User manual

Pro-Line Boats

Pro-Line Boats 2010 26 Express User manual

Pro-Line Boats

Pro-Line Boats 2010 23 XP User manual

Pro-Line Boats

Pro-Line Boats 35 Express User manual

Pro-Line Boats

Pro-Line Boats 17 Sport User manual

Pro-Line Boats

Pro-Line Boats 2012 23 Express User manual

Pro-Line Boats

Pro-Line Boats 17 Sport 2006 User manual

Pro-Line Boats

Pro-Line Boats 2005 34 Walk User manual

Pro-Line Boats

Pro-Line Boats 2950 Walkaround User manual

Pro-Line Boats

Pro-Line Boats 29 Super Sport User manual

Pro-Line Boats

Pro-Line Boats 2007 25 Walk User manual

Pro-Line Boats

Pro-Line Boats 2000 30 Sport User manual

Pro-Line Boats

Pro-Line Boats 2700 Sport User manual

Pro-Line Boats

Pro-Line Boats 23 Walk User manual

Pro-Line Boats

Pro-Line Boats 2006 29 super sport User manual

Pro-Line Boats

Pro-Line Boats 28 Express 2006 User manual

Pro-Line Boats

Pro-Line Boats 26 Super Sport User manual

Pro-Line Boats

Pro-Line Boats 2010 29 Express User manual

Pro-Line Boats

Pro-Line Boats 32 Express 2006 User manual

Pro-Line Boats

Pro-Line Boats Pro Line 19 Sport User manual

Pro-Line Boats

Pro-Line Boats 35 Express 2006 User manual

Popular Boat manuals by other brands

Raymarine

Raymarine ST70 Instrument User reference handbook

Jeanneau

Jeanneau CAP CAMARAT 8.5 CC owner's manual

Tiara Yachts

Tiara Yachts C49 2024 owner's manual

Monterey Boats

Monterey Boats Sport Yacht 330 owner's manual

J 105 owner's manual

PURSUIT

PURSUIT OS 335 owner's manual

Boston Whaler

Boston Whaler CONQUEST 345 owner's manual

Jeanneau

Jeanneau SUN ODYSSEY 41 DS owner's manual

Meridian

Meridian 490 Pilothouse owner's manual

Advanced Elements

Advanced Elements AdvancedFrame Expedition AE1009 owner's manual

Robo Marine Indonesia

Robo Marine Indonesia GEOMAR user manual

Swallow Boats

Swallow Boats BayRaider owner's manual

Intex

Intex Excursion 5 Set manual

X SHORE

X SHORE EELEX 8000 owner's manual

ISLAND PACKET

ISLAND PACKET 370 owner's manual

Sea Ray

Sea Ray 175 Sport owner's manual

Regal

Regal 2300 owner's manual

Grand

Grand Silver Line S250 owner's manual