Pentair Raychem PMKG-LE User manual

1 / 2

PMKG-LE

Low-ProfiLe end SeaL Kit inStaLLation inStructionS

THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

DESCRIPTION

The PMKG-LE is a NEMA Type 4X rated end seal kit designed for

use with Raychem BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, and

KHP-CR parallel heating cables. It is designed to be placed on the

pipe under the insulation and cladding.

For additional information contact your Pentair Thermal

Management representative or call (800)545-6258.

TOOLS REQUIRED

• Screwdriver • Wirecutters

• Utilityknife

ADDITIONAL MATERIALS REQUIRED

• Onegrommet:(1)

PMK-GK-10 P/N 222724-000 (Package of ten grommets)

• Glassclothtape

– GT-66 Installation temperature above 40°F (4°C)

 –GS-54 Installationtemperatureabove–40°F(–40°C)

(1) Required for LBTV2 (see step 1)

This component is an electrical device that must be installed

correctly to ensure proper operation and to prevent shock or fire.

Read these important warnings and carefully follow all of the

installation instructions.

• Tominimizethedangeroffirefromsustainedelectricalarcing

if the heating cable is damaged or improperly installed, and to

comply with the requirements of Pentair Thermal Management,

agency certifications, and National Electrical Codes, ground-

fault equipment protection must be used. Arcing may not be

stopped by conventional circuit breakers.

• Componentapprovalsandperformancearebasedontheuseof

Pentair Thermal Management-specified parts only. Do not use

substitute parts or vinyl electrical tape.

• Theblackheatingcablecoreisconductiveandcanshort.It

must be properly insulated and kept dry.

• Damagedbuswirescanoverheatorshort.Donotbreakbuswire

strands when scoring the jacket or core.

• Keepcomponentsandheatingcableendsdrybeforeandduring

installation.

• Buswireswillshortiftheycontacteachother.Keepbuswires

separated.

• Useonlyfire-resistantinsulationmaterials,suchasfiberglass

wrap or flame-retardant foam.

WARNING:

KIT CONTENTS

Item Qty Description

A 1 Pressure plate

B 1 End seal body with stainless steel screws

C 1 Red grommet (not for use with LBTV2)

D 1 End seal label

APPROVALS

-W

Class I, Div. 2, Groups A, B, C, D

Class II, Div. 2, Groups F, G

Class III

KHP-CR heating cables only

Hazardous Locations

Nonhazardous Locations

BTV-CR, BTV-CT, QTVR-CT and LBTV2-CT heating cables only

2 / 2THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

WWW.THERMAL.PENTAIR.COM

NORTH AMERICA

Tel: +1.800.545.6258

Fax: +1.800.527.5703

Tel: +1.650.216.1526

Fax: +1.650.474.7711

thermal.info@pentair.com

EuROPE, MIddLE EAsT, AfRICA

Tel: +32.16.213.511

Fax: +32.16.213.603

thermal.info@pentair.com

AsIA PACIfIC

Tel: +86.21.2412.1688

Fax: +86.21.5426.2917

cn.thermal.info@pentair.com

LATIN AMERICA

Tel: +55.11.2588.1400

Fax: +55.11.2588.1410

thermal.info@pentair.com

Pentair, BTV, QTVR, LBTV2 and KHP are owned by Pentair or its global affiliates. All other trademarks are the property of their respective owners. Pentair

reserves the right to change specifications without prior notice.

BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, KHP-CR

Bus wire

Conductive core

Inner jacket

Braid

Outer

jacket

3/4 in

(20 mm)

• Slidepartsontoheatingcable.

• Removeexposedbraid.

• Secureendsealtopipeusingcorrect

tape(GT-66orGS-54).

• Applyinsulationandcladding.

• Installlabelonoutsideofcladding.

• Leavetheseinstructionswiththeend

user for future reference.

• Lightlyscoreouterjacket.

• Bendheatingcabletobreakjacket

at score, then peel off jacket.

• Pushheatingcable

completely into end

seal body.

• Seatgrommetand

tighten screws.

WARNING: Use of the

wrong grommet can

result in leaks, cracked

components, shock or

dielectric failure, and

will invalidate

approvals and

certifications

• Identifyheatingcabletype.

• Selectcorrectgrommetfromtablebelow.

Heating Cable Type Grommet

BTV, QTVR -CR or -CT RED

LBTV2 -CT K *

KHP -CR RED

*Orderseparately

Identify Heating Cable Type

Other Pentair Control Unit manuals

Pentair

Pentair Goyen Mecair FFA User manual

Pentair

Pentair AUTOTROL 604 User guide

Pentair

Pentair Keystone Figure 952 NPS 2 Installation instructions

Pentair

Pentair DSD50 Series User manual

Pentair

Pentair Fleck 2850 NXT User guide

Pentair

Pentair AUTOTROL 360 User manual

Pentair

Pentair AUTOTROL LOGIX 742 User manual

Pentair

Pentair SIATA V132 SFE-EV VIRIDION User manual

Pentair

Pentair LINCOLN 84976 Owner's manual

Pentair

Pentair 2750 User manual

Pentair

Pentair JUNG PUMPEN BASICLOGO BD User manual

Pentair

Pentair SPEEDEO SB-PF-SPO-003C User manual

Pentair

Pentair FLECK3150 DOWNFLOW User manual

Pentair

Pentair Fleck 9000-SXT User manual

Pentair

Pentair AURORA CBV-S/A User manual

Pentair

Pentair FLECK 2750 Downflow User manual

Pentair

Pentair EVERPURE MRS-350BL User manual

Pentair

Pentair Anderson Greenwood 93 Series User manual

Pentair

Pentair PENTEK INTELLIDRIVE PID2000-1123 User manual

Pentair

Pentair AUTOTROL 368 User manual

Pentair

Pentair FLECK 3900 User manual

Pentair

Pentair FLECK 3150 NXT User guide

Pentair

Pentair AURORA 1040 Series Operating instructions

Pentair

Pentair SUDMO P740 User manual

Popular Control Unit manuals by other brands

Festo

Festo Compact Performance CP-FB6-E Brief description

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Quick installation guide

JS Automation

JS Automation MPC3034A user manual

JAUDT

JAUDT SW GII 6406 Series Translation of the original operating instructions

Spektrum

Spektrum Air Module System manual

BOC Edwards

BOC Edwards Q Series instruction manual

KHADAS

KHADAS BT Magic quick start

Etherma

Etherma eNEXHO-IL Assembly and operating instructions

PMFoundations

PMFoundations Attenuverter Assembly guide

GEA

GEA VARIVENT Operating instruction

Walther Systemtechnik

Walther Systemtechnik VMS-05 Assembly instructions

Altronix

Altronix LINQ8PD Installation and programming manual

Eaton

Eaton Powerware Series user guide

WAGO

WAGO 750-407/040-000 manual

Sony

Sony CCU-590 Operation manual

Graco

Graco 25D614 instructions

Task Force Tips

Task Force Tips YE-RF-900 Instructions for installation, safe operation and maintenance

Shini

Shini SPV-U Series manual