Nokia 1508I User manual

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Nokia Customer Care

1508i (RM-430)

Mobile Terminal

RF Description and Troubleshooting

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Contents

1508i RF troubleshooting

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Component Layout

Figure 1 and Figure 2 show the main components of the 1508i mobile terminal.

Figure 1: Component layout (Top)

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Figure 2: Component layout (Bottom)

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Tx Troubleshooting

Tx System Block Diagram

Figure 3: Tx system block diagram

Tx Introduction

The SA9562 is highly integrated direct conversions transmit IC for use in multi-band

(800MHz, 1700MHz and 1900MHz) mobile phones. It can be used in CDMA modes

conforming to the CDMA2000 1xRTT release A in three frequency bands. Fabricated in

QUBiC4 BiCMOS technology, it integrates an IQ modulator, dual Σ∆ Fractional-N

synthesizers, a semi-integrated crystal oscillator, a fully integrated Transmitter VCO, an RF

VGA for CEL and PCS, one PA driver for the US Cellular band (824 to 849MHz) and two PA

drivers for PCS bands (1750MHz to 1780MHz or 1850MHz to 1910MHz). Figure 3 shows the

RF Tx system block diagram

Main Tx Component

cou

ler

Duplexer

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Figure 4: Tx main components

AMS Setup for Tx Troubleshooting

Put PWB on the module jig. Use the following steps to configure AMS for RF troubleshooting.

1. Connect RF connector to a CMU200 or 8960.

2. Connect the PWB to a PC via the Module Jig, and connect a power supply.

3. Open AMS Tools software and select RF Tool.

4. Choose CP Enable, Enable“off”, then send.

5. Choose DSPM AFC Config. Set Pdm Val “0x0200”, then send

6. Choose CP PLL Channel Config. Set Band “PCS”, Channel “600”, then send..

7. Choose CP TX CDMA Test send.

8. Choose DSPM TX AGC Config. Set Hyst State “High gain”, Power (dBm) “24dBm” then send.

9. Choose CP AUX ADC Get. Set TX PCG Sync “off” then send to get Power detector ADC value.

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Figure 5: FTM dialog box (Picture will be updated )

Tx DC Test Points

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Figure 6: Tx DC test point

Table 1 shows the Tx DC test points shown in Figure 6.

Test Point Description Value

1 PA_R1 2.16V for high gain mode,1.6V for low gain mode

2 PA_ON 3.08V for PA turning on, 0V for turning off

3 Tx_on 2.0 V

4 Tx_pll 3.0V

5 Tx_VccIQmod 3.0V

6 TX_AGC 1.92V for 5dBm, 2.16V for 15dBm, 2.4V for 25dBm.

7 Tx IQ in 0.8 V With oscilloscope: 500 mV p-p

8 Tx_vccRFVGA 3.0V

Table 1: Tx DC Test Points

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Tx RF Test Points

Figure 7: Tx RF Test Points

Table 2 shows the test points shown in Figure 7.

Test Point Description Value

1 LO in About 0dBm

2 RFout About 2dBm

3 PA input About 0dBm

4 PA output About 28dBm

5 Coupler output About 26dBm

6 Connector About 24dBm

Table 2: Tx RF Test Points

1508i(RM-430)

RF Description and Troubleshooting

NokiaCustomerCare

Issue 1

Tx Path Troubleshooting

No No No

yes

No No

yes

Notes:

• CBP5.6 is underfilled and can not be replaced.

• The shield case can not be reused after removal.

• After using the heatgun, the domesheet needs to be replaced

• U109 is PA, it is need special tool to reheat it.

Tx path faults

Measure DC test points

at table 1,is it OK?

Measure Tx RF test point

2 at table 2, is it OK?

Measure Tx RF test point

3 at table 2, is it OK?

Measure Tx RF test point

4 at table 2, is it OK?

Measure Tx RF test point

5 at table 2, is it OK?

If RF antenna feed point pad

obstructed, clean the pad,

connect system simulator to the

MS antenna, is it OK?

Tx troubleshootin

finished

Check ACT5805,

CBP5.6

Reheat solder joints of

ACT5805

Measure Tx RF test point

1 at table 2, is it OK? Rehear solder joints of c244

Reheat L205 and reheat SA9562

Reheat the solder joints of C101,D201

Reheat the solder joints of U109 Chan

e U109

Reheat the solder

oints of C113, U101

Measure Tx RF test point

6 at table 2, is it OK? Reheat the solder

oints of R107, U107

Reheat the solder joints of L123, C120

Check antenna module

Other manuals for 1508I

This manual suits for next models

Table of contents

Other Nokia Cell Phone manuals

Nokia

Nokia 6288 - Cell Phone - WCDMA User manual

Nokia

Nokia 1661 User manual

Nokia

Nokia E51 - Smartphone 130 MB User manual

Nokia

Nokia SUPERNOVA 7100 User manual

Nokia

Nokia 7270 - Cell Phone 21 MB User manual

Nokia

Nokia 7390 - Cell Phone - WCDMA Quick start guide

Nokia

Nokia E55 User manual

Nokia

Nokia 6305i - Cell Phone 128 MB User manual

Nokia

Nokia Asha 311 User manual

Nokia

Nokia E72 User manual

Nokia

Nokia 6233 - Cell Phone 6 MB User manual

Nokia

Nokia C3-01m User manual

Nokia

Nokia 6300 - Cell Phone 7.8 MB User manual

Nokia

Nokia N-3100 User manual

Nokia

Nokia 150 User manual

Nokia

Nokia 6110 - Navigator Smartphone 40 MB User manual

Nokia

Nokia 5220 XpressMusic User manual

Nokia

Nokia C3 User manual

Nokia

Nokia Music User manual

Nokia

Nokia RH-53 Service manual

Nokia

Nokia 1600 User manual

Nokia

Nokia 7280 - Cell Phone - GSM User manual

Nokia

Nokia E75 User manual

Nokia

Nokia 650 User manual

Popular Cell Phone manuals by other brands

Zte

Zte BLADE A520 quick start guide

Blackbe;rry

Blackbe;rry KEYone Safety and product information

Bea-fon

Bea-fon X5 Premium quick guide

Blackbe;rry

Blackbe;rry 8707 Series user guide

Blackbe;rry

Blackbe;rry Storm Troubleshooting

LG LM-X420QN user guide

LifeWatch

LifeWatch V user guide

Bea-fon

Bea-fon SILVER LINE SL860 user guide

IKI Mobile

IKI Mobile KF4.5i user manual

Hitech

Hitech HT-850 user guide

Yezz

Yezz Fashion F10 user manual

Point Mobile

Point Mobile PM60 user manual

Blackbe;rry

Blackbe;rry Q10 user guide

Blackbe;rry

Blackbe;rry Bold 9900 user guide

Blackbe;rry

Blackbe;rry STORM 9500 - VERSION 5.0 user guide

LG LM-K420EMW user guide

ISAFE MOBILE

ISAFE MOBILE IS655.2 operating manual

LG Thrive user manual