ML Accessories BL5BK Instruction Manual

INSTALLATION & MAINTENANCE MANUAL

BL5BK / BL5G / BL5BLBK / BL5BLG

BLKITBK / BLKITG

These instructions should be read carefully and retained after installation by the

end user for future reference and maintenance.

These instructions should be used to aid installation of the following products:

BL5BK / BL5G / BL5BLBK / BL5BLG / BLKITBK / BLKITG

GENERAL INSTRUCTIONS

SAFETY

• This product must be installed in accordance with the latest edition of the IEE Wiring

Regulations (BS7671) and current Building Regulations. If in any doubt, consult a

qualiﬁed electrician

• Please isolate mains prior to installation or maintenance

• Check the total load on the circuit (including when this luminaire is ﬁtted) does not exceed

the rating of the circuit cable, fuse or circuit breaker

• Please note the IP (Ingress Protection) rating of this product when deciding the location

for installation

• This product is Class II double insulated

• This product is IP65 rated

INSTALLATION

Note - If this product is being used in conjunction with an external PIR or sensor, please

conﬁrm with the manufacturer of the sensors that they are compatible with LED luminaires.

• Provide power to the required point of installation (refer to BS7671 for correct cabling

methods). Suitable IP rated junction boxes should be used where required

• Round cable should be used for the mains supply. The use of ﬂat cable may cause water

ingress to the ﬁtting

• Remove the outer frame and the LED gear tray from the luminaire housing (see Fig. 1)

Fig. 1

BL5xx INSTRUCTIONS_SPREADS.indd 5-8BL5xx INSTRUCTIONS_SPREADS.indd 5-8 20/01/2021 16:02:4120/01/2021 16:02:41

SURFACE MOUNTING

• Secure the ﬁtting to the surface with the wall plugs, screws, and rubber washers provided

• Drill two ﬁxing holes in the rear of the luminaire housing, mark the location of the ﬁxing

holes and drill ensuring not to infringe with any gas/water pipes or electrical cables

• Feed the mains cable through the grommet on either the rear or the side of the luminaire

housing (see Fig. 2) ensuring a good seal is made to retain the IP rating. The luminaire

can be ﬁtted horizontally or vertically, enabling cable entry on either side

BL5xx INSTRUCTIONS_SPREADS.indd 5-8BL5xx INSTRUCTIONS_SPREADS.indd 5-8 20/01/2021 16:02:4120/01/2021 16:02:41

Fig. 2

BL5xx INSTRUCTIONS_SPREADS.indd 5-8BL5xx INSTRUCTIONS_SPREADS.indd 5-8 20/01/2021 16:02:4120/01/2021 16:02:41

RECESSED MOUNTING

• For recessed mounting using the BLKITxx, cut a suitable hole in the mounting surface

ensuring not to infringe with any gas/water pipes or electrical cables

• Remove a knockout from the backbox (see Fig. 3)

• Feed the mains cable into the backbox (at this stage there is no requirement for

maintaining the IP rating)

• Fix the backbox securely into the wall ﬂush with the wall surface. Mortar around the

backbox if necessary and allow to set before continuing

• Drill two ﬁxing holes on the rear of the luminaire housing to align with the screw pillars in

the backbox

• Feed the mains cable through one of the cable entry grommets in the luminaire housing

(see Fig. 2) ensuring a good seal is made to retain the IP rating

• Secure the luminaire to the backbox using the M4 screws and rubber washers provided

(see Fig. 4)

Fig. 3

BL5xx INSTRUCTIONS_SPREADS.indd 1-4BL5xx INSTRUCTIONS_SPREADS.indd 1-4 20/01/2021 16:02:4120/01/2021 16:02:41

TERMINATION AND ACCESSORIES

• Connect the luminaire to the mains supply ensuring the correct polarity is observed:

L - Live (brown), N - Neutral (blue)

• Select the desired colour temperature by means of the sliding switch on the LED gear tray

(where applicable)

• Reﬁt the LED gear tray onto the luminaire housing ensuring the cable does not press

against the terminal block which may cause it to open, and secure it with all four screws

ensuring a tight seal is made

• Select a decorative accessory if required, and hold it in place while ﬁtting the appropriate

outer frame – the deep frame should be used if surface mounting; the shallow frame if

recess mounting

• Switch on and check for correct operation

Fig. 4

GENERAL

WARNING

This product contains a light source of energy efﬁciency class D to Regulation (EU)

No. 2019/2015. (Not applicable to BL5BLxx).

This product contains an LED light source and control gear which can be replaced by a

professional.

Clean the external surfaces with a damp cloth using a mild solution of detergent and warm

water only, do not use aggressive cleaning products or solvents which may damage the

product.

Do not use any source of high-pressure washers to maintain or clean this luminaire.

This product is non-dimmable.

This product should be dismantled for disposal when it reaches the end of its life. Please

see website for dismantling instructions.

This product should be recycled in the correct manner when it reaches the end of its life.

Check local authorities for where facilities exist.

This product must be disconnected from the circuit if subjected to any high voltage or

insulation resistance testing. Irreparable damage will occur if this instruction is not followed.

This product is not suitable for direct installation in the ground, nor in a retaining wall where

the ground may become saturated behind.

DCJUN21_V1

WARRANTY

This product has a warranty of 3 years (BL5xx) / 1 year (BLKITxx) from date of purchase.

Failure to install this product in accordance with the current edition of the IEE Wiring

Regulations (BS7671), improper use, or removal of the batch code will invalidate the

warranty. If this product should fail within its warranty period, it should be returned

to the place of purchase for a free of charge replacement. ML Accessories does not

accept responsibility for any installation costs associated with the replacement product.

Your statutory rights are not affected. ML Accessories reserve the right to alter product

speciﬁcation without prior notice.

ML Accessories Limited LU5 4LT

www.mlaccessories.co.uk

INTERNATIONAL

CONTACT DETAILS

INTERNATIONAL

CONTACT DETAILS

INTERNATIONAL

CONTACT DETAILS

This manual suits for next models

Table of contents

Other ML Accessories Lighting Equipment manuals

ML Accessories

ML Accessories EMPOWER2 Instruction Manual

ML Accessories

ML Accessories BATSCWST4 Instruction Manual

ML Accessories

ML Accessories Knightsbridge SFPL Series Instruction Manual

ML Accessories

ML Accessories LEDFRA6 Instruction Manual

ML Accessories

ML Accessories EA1 Series Instruction Manual

ML Accessories

ML Accessories Knightsbridge SPIKEW Manual

ML Accessories

ML Accessories SURF236HF Instruction Manual

ML Accessories

ML Accessories Knightsbridge LEDFS12WW Instruction Manual

ML Accessories

ML Accessories SUR5LED Instruction Manual

ML Accessories

ML Accessories FL8ABK Instruction Manual

ML Accessories

ML Accessories BL01BK Instruction Manual

ML Accessories

ML Accessories RDSHCBR Instruction Manual

ML Accessories

ML Accessories SPIKE4BL Instruction Manual

ML Accessories

ML Accessories TPR14LEDS Instruction Manual

ML Accessories

ML Accessories BF1430S Instruction Manual

ML Accessories

ML Accessories Knightsbridge BLED5BW Instruction Manual

ML Accessories

ML Accessories MLBA6045 Series Instruction Manual

ML Accessories

ML Accessories WALL1 Instruction Manual

ML Accessories

ML Accessories LED3 Series Instruction Manual

ML Accessories

ML Accessories BATS2 Instruction Manual

ML Accessories

ML Accessories RD1 Series Instruction Manual

ML Accessories

ML Accessories OSPCKIT Instruction Manual

ML Accessories

ML Accessories WAD12AA Instruction Manual

ML Accessories

ML Accessories Knightsbridge EMTWINPC Instruction Manual

Popular Lighting Equipment manuals by other brands

Brizo

Brizo 8SP-MU-4 manual

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 installation instructions

IKEA

IKEA BJÖRKSPIREA manual

Laserworld

Laserworld Evolution Series ES-400RGB manual

Alien

Alien RG STAR user manual

EuroLite

EuroLite LED B-40 user manual

Qazqa

Qazqa Suplux SL 3 Black 103062 instruction manual

Commercial Electric

Commercial Electric 54568141 Use and care guide

CREE LIGHTING

CREE LIGHTING 304 Series installation instructions

Goobay

Goobay 49867 user manual

ECOMAN ITALIA

ECOMAN ITALIA LED T8 instruction manual

Alkalite

Alkalite Krypton KT-81 user manual

Clas Ohlson

Clas Ohlson GU10 manual

DTS

DTS DELTA 10 F user manual

ring

ring Solar Steplight manual

One Stop Gardens

One Stop Gardens 57696 Owner's manual & safety instructions

Chauvet DJ

Chauvet DJ COREpar UV120 ILS user manual

SIREM

SIREM Swimeo A2 instructions