Lightolier CALCULITE EVOLUTION TRIMS User manual

READ AND UNDERSTAND THESE INSTRUCTIONS BEFORE INSTALLING LUMINAIRE

This luminaire is intended for installation in accordance with the National Electrical Code and local regulations.

To assure full compliance with local codes and regulations, check with your local electrical inspector before

installation. To prevent electric shock, turn off electricity at fuse box before proceeding.

Retain these instructions for maintenance reference.

INSTALLATION PROCEDURE FOR CALCULITE®EVOLUTION TRIMS

WARNING: USE ONLY REFLECTOR TRIMS PROVIDED BY LIGHTOLIER. USE OF OTHER MANUFACTURER’S

REFLECTOR TRIMS MAY VOID THE UNDERWRITERS LABORATORIES LISTING AND COULD CONSTITUTE A FIRE HAZARD.

INSTRUCTION SHEET NO.

IS: C3MR

B0206 Page 1 of 2

A COMPANY

631 Airport Road, Fall River, MA 02720

1. MAKE SURE THAT POWER TO THE LUMINAIRE IS OFF.

2. Select proper LAMP for application.

3. Remove TRIM FACEPLATE from TRIM BODY by

compressing TORSION SPRING. Fig. 1

4. Insert LAMP between LAMP SPRINGS of LAMP HOLDER

ASSEMBLY until face of LAMP sits firmly on GLASS LAMP

GUARD. Fig. 2

CAUTION! RISK OF FIRE. GLASS LAMP GUARD MUST BE

INSTALLED. Lamp manufacturers require the glass

lampguard be in place before energizing lamp, and that

great care must be taken that lamp is fully cooled before re-

lamping. Avoid finger marks on the inside of the lamp, as it

may shorten lamp life or cause breakage.

5. Insert LAMP HOLDER ASSEMBLY into TRIM BODY until

LAMP SPRINGS snap into place. Fig. 3

6. Bring TRIM BODY to FRAME and attach SOCKET to bi-pin

prongs on LAMP ensuring LAMPHOLDER ASSEMBLY remains

in place. Fig. 3

Prior to installing your LIGHTOLIER TRIM, the horizontal rotation

can be preset within the luminaire. Note the BEAM CENTERING

NOTCH Fig.4 allows the installer to predetermine the direction

the lamp will point to illuminate a wall or object of interest (not

applicable to downlight trims). Once the notch is aligned with the

object of interest, simply tighten the ROTATIONAL BRAKE

SCREW until the spring is fully compressed Fig. 5.

7. Ensure the two SECURING CLIPS are in the disengaged

position.Fig.1 on pg. 2. Align the two THICK CEILING READY

BRACKETS with the SECURING CLIPS and insert TRIM BODY

up until the bottom of TRIM BODY is flush or slightly recessed

from bottom of ceiling plane. Properly engage SECURING

CLIPS by pushing them into THICK CEILING READY

BRACKETS. Fig’s 2 & 3 on pg. 2

Fig. 1

Trim Body

Trim Faceplate

Torsion Spring

Fig. 2

Fig. 3

Fig. 4

Fig. 5

Lamp

Lamp Springs

Lamp Holder

Assembly

Socket

Beam

Centering

Notch

Rotational

Brake Screw

Thick Ceiling

Ready Brackets

Lamp Removal

Spring

READ AND UNDERSTAND THESE INSTRUCTIONS BEFORE INSTALLING LUMINAIRE

This luminaire is intended for installation in accordance with the National Electrical Code and local regulations.

To assure full compliance with local codes and regulations, check with your local electrical inspector before

installation. To prevent electric shock, turn off electricity at fuse box before proceeding.

Retain these instructions for maintenance reference.

INSTRUCTION SHEET NO.

IS: C3MR

B0206 Page 2 of 2

A COMPANY

631 Air

ort Road, Fall River, MA 02720

INSTALLATION PROCEDURE FOR CALCULITE®EVOLUTION TRIMS

8. Install TRIM FACEPLATE by compressing TORSION SPRING

into corresponding detail of TRIM BODY then pushing TRIM

FACEPLATE up flush to ceiling. Fig’s 4 & 5

TRIM MAINTENANCE

RELAMPING - Make sure that power to luminaire is OFF.

To relamp, simply swing TRIM FACEPLATE down allowing

TORSION SPRING to hold in place. Pull down on LAMP

REMOVAL SPRING. Disconnect LAMP from LAMP

SPRINGS and SOCKET. Install new LAMP following steps

4, 5, and 6 above.

CARE OF ALZAK REFLECTOR- Wipe with a soft, clean,

dry, lint-free cloth, or wipe with a soft clean cloth

dampened in mild detergent solution, then rinse and

dry with a lint-free soft cloth.

Fig. 1

Fig. 2

Securing Clips in

the disengaged

position

Fig. 3

Insert Trim Body

Engage Clip

Trim Body Flush or

slightly recessed

Fig. 4 Fig. 5

Table of contents

Other Lightolier Lighting Equipment manuals

Lightolier

Lightolier Lytespan 8672WH User manual

Lightolier

Lightolier Prismalyte PNB SERIES User manual

Lightolier

Lightolier 240 User manual

Lightolier

Lightolier QVH2GPFOS4FT User manual

Lightolier

Lightolier ProSpec 28B20E User manual

Lightolier

Lightolier Lytecaster 2090 User manual

Lightolier

Lightolier LSB-5 User manual

Lightolier

Lightolier Calculite C6ALV User manual

Lightolier

Lightolier Lighting Systems F7000-12 User manual

Lightolier

Lightolier Lytespan 8727M16 User manual

Lightolier

Lightolier Mini-Beam Mini-Beam Luminaires User manual

Lightolier

Lightolier Lighting Systems LFK1 User manual

Lightolier

Lightolier Calculite C7CS-P38MH User manual

Lightolier

Lightolier CD7-5 User manual

Lightolier

Lightolier Lytespan 6275B User manual

Lightolier

Lightolier AGK User manual

Lightolier

Lightolier CTS3-8 User manual

Lightolier

Lightolier ProSpec DRP35 User manual

Lightolier

Lightolier Calculite 7794QD User manual

Lightolier

Lightolier RT6-2 User manual

Lightolier

Lightolier Lytespan 83CY39E User manual

Lightolier

Lightolier Calculite ProSpec PB1P3810 User manual

Lightolier

Lightolier Uniframe 1101FR User manual

Lightolier

Lightolier ProSpec 37122 User manual

Popular Lighting Equipment manuals by other brands

Brizo

Brizo 8SP-MU-4 manual

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 installation instructions

IKEA

IKEA BJÖRKSPIREA manual

Laserworld

Laserworld Evolution Series ES-400RGB manual

Alien

Alien RG STAR user manual

EuroLite

EuroLite LED B-40 user manual

Qazqa

Qazqa Suplux SL 3 Black 103062 instruction manual

Commercial Electric

Commercial Electric 54568141 Use and care guide

CREE LIGHTING

CREE LIGHTING 304 Series installation instructions

Goobay

Goobay 49867 user manual

ECOMAN ITALIA

ECOMAN ITALIA LED T8 instruction manual

Alkalite

Alkalite Krypton KT-81 user manual

Clas Ohlson

Clas Ohlson GU10 manual

DTS

DTS DELTA 10 F user manual

ring

ring Solar Steplight manual

One Stop Gardens

One Stop Gardens 57696 Owner's manual & safety instructions

Chauvet DJ

Chauvet DJ COREpar UV120 ILS user manual

SIREM

SIREM Swimeo A2 instructions