KitchenAid KSOX 9020 User manual

Instructions for use

Outdoor grill safety 4

EC Declaration of conformity 4

Important safety instructions 5

Installation requirements 6

Installation instructions 9

Gas connection 11

Injector table 13

Installation of the regulator 14

Change the main grill burner valves injectors 15

Check and adjust the burners 17

Outdoor grill use 18

Using your rotisserie (optional accessory) 21

Tips for outdoor grilling 24

Cleaning and maintenance 26

Troubleshooting guide 28

After-sales service 29

Your safety and the safety of others are very important.

We have provided many important safety message in this manual and on your appliance. Always read and

obey all safety messages.

This is the safety alert symbol.

This symbol alerts you to potential hazards that can kill or hurt you and others.

All safety messages will follow the safety alert symbol and either the word "DANGER" or "WARNING".

These words mean:

You can be killed or seriously injured if you don't immediately follow instructions.

You can be killed or seriously injured if you don't follow instructions.

All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury,

and tell you what can happen if the instructions are not followed.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire

department.

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other

appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

IMPORTANT: This grill is manufactured for outdoor use only. For grills that are to be used at altitudes

above 2000 ft (609.6 m) injector conversion is required. See "Gas Supply Requirements" section. It is the

responsibility of the installer to comply with the minimum installation clearances. The model/serial rating

plate for freestanding models can be found on the right-hand inside cabinet wall.

IMPORTANT: This appliance does not have flame supervision device.

SAVE THESE INSTRUCTIONS

WARNING

DANGER

Outdoor grill safety

This appliance has been designed, constructed and marketed in compliance with:

- safety requirements of "GAS" Directive 2009/142/EC (ex-90/396/EEC);

- safety objectives of "Low Voltage" Directive 2006/95/EC (which replaces 73/23/EEC and subsequent

amendments);

- protection requirements of "EMC" Directive 2004/108/EC.

This appliance is suitable for contact with foodstuffs and complies with EC Regulation no. 1935/2004.

EC Declaration of conformity

WARNING: To reduce the risk of fire, electrical shock, injury to persons, or damage when using the

outdoor cooking gas appliance, follow basic precautions, including the following:

• Do not install portable or built-in outdoor cooking gas appliances in or on a recreational vehicle,

portable trailer, boat or in any other moving installation.

• Always maintain minimum clearances from combustible construction, see "Location Requirements"

section.

• The outdoor cooking gas appliance shall not be located under overhead unprotected combustible

construction.

• This outdoor cooking gas appliance shall be used only outdoors and shall not be used in a building,

garage, or any other enclosed area.

• Keep any electrical supply cord and fuel supply hose away from any heated surfaces.

• Keep the outdoor cooking gas appliance area clear and free from combustible materials, gasoline and

other flammable vapors and liquids.

• Do not obstruct the flow of combustion and ventilation air. Keep the ventilation openings of the

cylinder enclosure free and clear from dirt.

• Inspect the gas cylinder supply hose before each use of the outdoor cooking gas appliance. If the hose

shows excessive abrasion or wear, or is cut, it MUST be replaced before using the outdoor cooking gas

appliance. Contact your dealer and use only replacement hoses specified for use with the outdoor

cooking gas appliance.

• Visually check the burner flames. They should be blue. Slight yellow tipping is normal for LPG gas.

• Check and clean burner/venturi tube for insects and insect nest. A clogged tube can lead to fire under

the outdoor cooking gas appliance.

• Always check connections for leaks each time you connect and disconnect the LP gas supply cylinder.

See "Installation Instructions" section.

• When the outdoor cooking gas appliance is not in use, the gas must be turned off at the supply cylinder.

• Storage of an outdoor cooking gas appliance indoors is permissible only if the cylinder is disconnected

and removed from the outdoor cooking gas appliance.

• Cylinders must be stored outdoors and out of the reach of children and must not be stored in a

building, garage, or any other enclosed area.

• Gas cylinder must include a collar to protect the cylinder valve.

• The appliance is not inteded for use by persons (including children) with any phisical, sensory or mental

impairment, or without experience and knowledge of the appliance, unless supervised or previously

instructed in its use by those responsible for their safety.

If the following information is not followed exactly, a fire causing death or serious injury may occur.

• Do not store a spare LP gas cylinder under or near this outdoor cooking gas appliance.

• Use protective gloves when handling hot components.

• Read the instruction before using the appliance.

• Accessible parts may be very hot, keep young children away.

• Any modification of the appliance may be dangerous.

• The parts sealed by the manufacturer must not be altered by the user.

Important safety instructions

DISPOSAL FOR PACKING MATERIAL

The packing material is 100% recyclable and is marked with the recycle symbol . The various parts

of the packing must therefore be disposed of responsibly and in full compliance with local authority

regulations governing waste disposal.

Scrapping the product

• This appliance is marked in compliance with European Directive 2002/96/EC, Waste Electrical and

Electronic Equipment (WEEE).

• By ensuring this product is disposed of correctly, you will help prevent potential negative consequences

for the environment and human health, which could otherwise be caused by inappropriate waste

handling of this product.

• The symbol on the product or on the accompanying documentation indicates that it should not be

treated as domestic waste but must be taken to an appropriate collection centre for the recycling of

electrical and electronic equipment.

THE RATING PLATE, WITH THE TECHNICAL DATA, THE SERIAL NUMBER AND THE MARKINGS IS

POSITIONED WHERE YOU CAN SEE IT ON THE BACK OF THE APPLIANCE. NEVER REMOVE THE

PLATE.

Important safety instructions

Installation requirements

Tools and Parts

Freestanding Outdoor Grills

Gather the required tools and parts before starting installation.

Read and follow the instructions provided with any tools listed here.

Tools Needed

• Tape measure

• Small, flat-head screwdriver

• Flat-head screwdriver

• Phillips screwdriver

• Level

• Wrench or pliers

• Pipe wrench

• Scissors or cutting pliers (to remove tiedowns)

• Noncorrosive leakdetection solution

Location requirements

Parts Needed

• 10 kg (cylinder not more than 50 cm) LP gas fuel tank.

Do not move the appliance during use.

Explosion Hazard

Do not store fuel tank in a garage or indoors.

Do not store grill with fuel tank in a garage or indoors.

Failure to follow these instructions can result in explosion, or fire.

WARNING

Fire Hazard

Do not use grill near combustible materials.

Do not store combustible materials near grill.

Doing so can result in fire.

Select a location that provides minimum exposure to wind. The location should be away from strong draft

areas.

Do not obstruct flow of combustion and ventilation air. Clearance to combustible construction for

freestanding outdoor grills:

• A minimum of 60 cm must be maintained between the front of the grill hood, sides and back of the grill

and any combustible construction.

• Position the barbecue in an area where complete stability can be assured. Ensure that the wheel brakes

are in place as shown on page 11 ("Freestanding gas barbecue with wheels") and that the barbecue is

used on a flat level surface. Always ensure that the appliance is in a perfectly still and stable position

during cooking.

Rotisserie (accessory)* OPTIONAL

If you equip your grill with a rotisserie, a 15 cm minimum clearence is needed for the rotisserie motor.

*See "After sales services" section to order.

Product Dimension

WARNING

Installation requirements

179 cm

43.8 cm

91.4 cm

43.8 cm

158.8 cm

127.0 cm

72.4 cm

front of handle

to back of grill

Electrical requirements

Electrical shock hazard

Do not use an adapter.

Do not use an extension cord.

Failure to follow these instructions can result in fire, or electrical shock.

It is recommended that a separate circuit servicing only this grill be provided.

The rating plate, with the technical data, the serial number and the marking is positioned where you can

see it on the back of the appliance. Never remove the plate.

Gas supply requirements

Explosion hazard

Securely tighten all gas connections.

If connected to LP, have a qualified person make sure the gas pressure does not exceed value indicated by

local regulation.

Examples of a qualified person include:

licensed heating personnel, authorized gas company personnel and authorized service personnel.

Failure to do so can result in explosion or fire.

IMPORTANT: Grill must be connected to a regulated gas supply. Refer to the model/serial rating plate for

information on the type of gas that can be used. If this information does not agree with the type of gas

available, check with your local gas supplier.

Gas Conversion (only for some countries - see rating plate):

No attempt shall be made to convert the grill from the gas specified on the model/serial rating plate for

use with a different gas type without consulting the serving gas supplier. The conversion kit supplied with

grill must be used.

WARNING

Installation requirements

Freestanding Outdoor Grill Installation

Excessive Weight Hazard

Use two or more people to move and install the grill.

Failure to do so can result in back or other injury.

BEFORE INSTALLING AND USING THE BARBECUE YOU SHOULD CLEAN ITS INNER PARTS TO

REMOVE ANY MANUFACTURING RESIDUES. FOR MORE INFORMATION ON CLEANING REFER TO

THE "CLEANING AND MAINTENANCE" CHAPTER.

1. Unpack grill. Remove all packaging materials.

2. Move grill into desired outdoor location.

3. Open the hood.

Attach Side Shelf (on some models)

4. Open doors below grill and remove carton. Unpack

side shelf.

5. Locate 4 screws. Install 2 screws in the top 2 holes

on each side of the grill. Leave screws away from

the side of the grill about 0.64 cm.

6. Install side shelf on left side of the grill. Position the

side shelf so that the large end of the keyhole slots

are over the screws.

Place shelf onto the 2 mounting screws. Let the shelf

slide down so the screws are in the narrow neck of

the slots.

ATop of side shelf

BKeyhole slot

CFront of side shelf

DSide of grill

7. Install the bottom 2 screws and tighten.

8. Tighten the top 2 screws.

Attach Cabinet Doors (on some models)

1. Remove foam wrapping from both cabinet doors.

2. Position hinge pins on the door with the hinge

brackets on the cabinet. Gently push down to slide

the pins into place.

ADoor hinge pin

BHinge bracket

WARNING

Installation instructions

Remove Packaging Material Inside the Grill

1. Cut the tiedowns holding the grates together.

2. Remove condiment shelf, warming shelf and grill

grates from inside the grill and remove packaging

material.

3. Remove foam block and wrap from inside the grill.

AFoam block

BFoam wrap

4. Replace the grill grates.

5. Place warming shelf on brackets as shown.

AWarming shelf brackets

BWarming shelf

6. Attach condiment shelf to the inside of the left

cabinet door.

AAttachment holes

BAttachment holes

7. Dispose of/recycle all packaging material.

Tank tray installation instruction

Unpack the carton and take out accessories with plastic bag, remove bag.

1. Fix tank tray to the cart base with 4-5/32"*10 screws, Torque spec: 25kgf.cm

2. Mount the tank metal loop to th cart base with 3-1/4"*12, torque spec: 54kgf.cm.

Note: do not fix the hook to the other end of the loop until the tank is positioned into the tray. Step 3

3. Fix the hook to the end of the loop.

Step 2 Step 3Step 1

Installation instructions

Table of contents

Other KitchenAid Grill manuals

KitchenAid

KitchenAid Architect KBGS274SSS0 Manual

KitchenAid

KitchenAid 1500299 Product information sheet

KitchenAid

KitchenAid FREESTANDING OUTDOOR GRILL Product information sheet

KitchenAid

KitchenAid 720-0733 (LP) Product information sheet

KitchenAid

KitchenAid 720-0954 Product information sheet

KitchenAid

KitchenAid KFRS271TSS Product information sheet

KitchenAid

KitchenAid 720-0891CD Product information sheet

KitchenAid

KitchenAid 720-0893G (LP) Product information sheet

KitchenAid

KitchenAid 720-0891B Product information sheet

KitchenAid

KitchenAid KFRU271VSS User manual

KitchenAid

KitchenAid 720-0856V Product information sheet

KitchenAid

KitchenAid 860-0028 (LP) Product information sheet

KitchenAid

KitchenAid 720-0893D Product information sheet

KitchenAid

KitchenAid 720-0336D Product information sheet

KitchenAid

KitchenAid 720-0891CA (LP) Product information sheet

KitchenAid

KitchenAid KFRS361TSS00 User manual

KitchenAid

KitchenAid 720-0745A (LP) Product information sheet

KitchenAid

KitchenAid 720-0954GA (LP) Product information sheet

KitchenAid

KitchenAid 720-0893A KA Product information sheet

KitchenAid

KitchenAid 860-0003C Product information sheet

KitchenAid

KitchenAid 1900630 Product information sheet

KitchenAid

KitchenAid 740-0780 Product information sheet

KitchenAid

KitchenAid KBZU242TSS Manual

KitchenAid

KitchenAid 730-0819G Product information sheet

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide