Jacuzzi J - 270 User manual

Ozonator

TB1

230 VAC, 3-Wire Connection

USE COPPER CONDUCTORS ONLY. WIRE SIZE MUST

BE APPROPRIATE PER NEC AND/OR LOCAL CODES

Flow Switch

Hi-limit/Freeze Sensor

Temperature Sensor

20A

250V

SC-20

Circ.

Pump

Main

Pump

Spa

Light

Transformer

230 VAC

HILO

GRN

Logic Jumper Settings

All Export 50 Hz Models:

JP1 1-2 ON = 20A Logic*

JP1 1-2 OFF = 30A Logic

*Factory Jumper Setting

Temp. Jumper Settings (All Models):

JP1 7-8 ON = Celsius Temp Display

JP1 7-8 OFF = Fahrenheit Temp Display

BLU BRN

JP1

6 5

8 7

Heater Specifications

• Export 50 Hz Model:

2.7 kW @ 230 VAC

J20

J21

J12

J14

J16

J11

J15

J13

J17 J7 J8 J9 J10

Heater IN Heater OUT

K5 K7 K8

BLK

WHT

BRN

BLU

BRN

BLK BLU BRN BLU BRN

Control Panel

LED Series Hot Tub Owner’s Manual

J-270/J-280 Models

2530-277, Rev-A

Attention New Spa Owner!

Congratulations on the purchase of your new Jacuzzi® spa! The following

is a list of automated functions performed by your spa. These functions are

listed below in an attempt to alleviate any operational concerns you may



maintenance recommendations you should observe on a regular basis to

protect your new investment.

Automated Operations

-







for the duration of the cycle. Note: this function only occurs during the rst

ltration/heating cycle each day.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters



pH 7.4-7.6

Free Chlorine 3.0-4.0 ppm

Free Bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm





Required Filter Maintenance



provides unsurpassed water quality! To ensure maximum water quality at





instructions.

Required Water Replacement

You should replace the spa’s water every 3 months. The frequency de-

pends on a number of variables including frequency of use, number of us-

ers, and attention paid to water quality maintenance. You will know it is time

for a change when you cannot control sudsing and/or you can no longer get

the normal feel or sparkle to the water, even though the key water balance



additional information.

Table of Contents

1.0 Important Spa Owner Information .............................................. 1

2.0 FCC Notice .................................................................................... 1

3.0 Important Safety Instructions...................................................... 2

 ......................... 

3.2 Hyperthermia .................................................................................. 5

3.3 Cautions.......................................................................................... 6

 ............................................. 6

4.0 Choosing A Location.................................................................... 7

  ............................................................................ 7

 ............................................................................... 8

5.0 Power Requirements.................................................................... 9

6.0 Electrical Wiring Instructions.................................................... 10

7.0 Spa Fill Up Procedure ................................................................ 12

8.0 Control Functions....................................................................... 17

 ................................................................................ 17

  ............................................ 18

9.0 Operating Instructions ............................................................... 19

 .......................................................... 19

 ....................................................................... 19

  ............................................................. 19

 ................... 20

  ........................................................ 21

 ............................................... 21

9.7 Air Controls................................................................................... 21

10.0 Automatic Filtration Cycles ....................................................... 21

 s without

 ............................................................... 22

 with .................... 22

............................................................... 22

  .......................... 22

 .................................................. 22

  ......................................... 22

without ......... 23

 with.............. 2

11.0 Spa Maintenance ........................................................................ 25

  .....................................................................25

  ...................................................................27

11.3 ....................................................................................28

 .............................................................28

 ...................................................................28

 ...............................................28

  ....................................................................................28

11.8 ...........................................29

12.0 Water Quality Maintenance........................................................30

12.1 pH Control.....................................................................................30

  ......................................................................................30

  .........................31

13.0 Error Conditions/Error Messages .............................................31

with ...................31

 ......................................................................31

 .......................................................................31

 ......................................................................32

 ......................................................................32

 without Circulation

 ................................................................................32

 with Circulation

  ................................................................................32

  .......................................................................33

 ......................................................................33

14.0 Troubleshooting Procedures.....................................................33

  ................33

  .....................................33

  .............................................................................3

  ...........................................................................3

 .........................................................................................3

15.0 Circuit Diagram For Models without Circulation Pump

Option ..........................................................................................35

16.0 Circuit Diagram For Models with Circulation Pump

Option ..........................................................................................36

17.0 Optional Stereo Receiver Functions.........................................37

page 1

1.0 Important Spa Owner Information

Your Jacuzzi®J-200 series spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for effi-

cient operation, an uncovered spa surface directly exposed to sunlight

and high temperatures for an extended period is subject to permanent





full of water when it is exposed to direct sunlight and that you keep the

Jacuzzi premium insulating cover in place at all times when the spa is

not in use. Read and carefully follow the requirements for your spa’s



Jacuzzi constantly strives to offer the finest spas available, there-

fore modifications and enhancements may be made which affect

the specifications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for



limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to



1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

 

Changes or modifications not expressly approved by the party



operate this equipment.

page 2

3.0 Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY

-



1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

2-

tor between this unit and any metal equipment, metal enclosures

of electrical equipment, metal water pipe, or conduit within 5 feet



3. DANGER: Risk of Accidental Drowning

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

 DANGER: Risk of Injury. The suction fittings in this spa are sized to



arise to replace the suction fittings or the pump, be sure that the

-



rated less than the flow rate marked on the original suction fitting.

5. DANGER: Risk of Electric Shock.

all metal surfaces. As an alternative, a spa may be installed within

5 feet of metal surfaces if each metal surface is permanently con-

2

conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

6. DANGER: Risk of Electric Shock.-

ance, such as a light, telephone, radio, television, etc. within 5 feet

-

turer.

7. ELECTRICAL SUPPLY: The electrical supply for this product

must include a suitably rated switch or circuit breaker to open all





be readily accessible and visible to the spa occupant but installed at



page 3

8. WARNING: To Reduce the Risk of Injury:

 

-

-

mended for young children and when spa use may exceed 10 min-

utes.

-

ing fetal damage during the early months of pregnancy, pregnant or

possibly pregnant women should limit spa water temperatures to

 

using a spa.

 

temperature with an accurate thermometer since the tolerance of





12. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.



low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deficiency syndromes should consult

a physician before using a spa. If you experience breathing difficul-

ties in association with using or operating your spa, discontinue use

and consult your physician.



a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

15. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, dis-

continue use and seek medical attention.



3.1 Important CSA Safety Instructions (Canada Only)





1. READ AND FOLLOW ALL INSTRUCTIONS.

 

  symbol* is located inside the supply terminal

box or compartment. To reduce the risk of electric shock, this

terminal must be connected to the grounding means provided in the

electric supply service panel with a continuous copper wire equiva-

lent in size to the circuit conductors that supply this equipment

 

 -

nal surface or on the inside of the supply terminal box/compartment.

To reduce the risk of electric shock, connect the local common

bonding grid in the area of the spa to these terminals with an insu-



mm2

 



bonded to the equipment grounding buss with copper conductors

2

5. SAVE THESE INSTRUCTIONS.

WARNING: Children should not use spas without adult supervision.

WARNING:

prevent body and hair entrapment.

WARNING:

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING:

spa to avoid unconsciousness and possible drowning.

WARNING:

physician before using a spa.

WARNING:-

page 5

ous to your health.

WARNING:

with an accurate thermometer.

WARNING:

WARNING:

health.

WARNING: 

-

ances are built-in by the manufacturer.

CAUTION:

instructions.

WARNING: The use of alcohol or drugs can greatly increase the risk of

fatal hyperthermia in spas.

3.2 Hyperthermia

-

tion of the causes, symptoms, and effects of hyperthermia are as fol-



Hyperthermia occurs when the internal temperature of the body reaches





and an increase in the internal temperature of the body. The effects of



 

 

 

 

 

 

A warning sign is provided in your warranty packet. Please

install it at a location near your spa, where it is visible to the

user of the spa. For additional or replacement signs please

contact your local Jacuzzi spas dealer and reference item num-

ber #6530-082.

page 6

3.3 Cautions

 

pressure, and any condition requiring medical treatment, pregnant

women, the elderly, or infants should consult with a physician before

using a spa.

 





your health.

 -

sures at higher temperatures can cause high body temperature.



reduced awareness. These effects could possibly result in drown-

ing.

 

-

ous consequences.

5. Always test the spa water temperature before entering the spa.



 

operate any electrical appliances from inside the spa or when you

are wet unless such appliances are built-in by the manufacturer.

 

maintain safe water and prevent possible damage to spa compo-

nents.

 

use. This will help to discourage unsupervised children from enter-

ing the spa and keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

3.4 General Electrical Safety Instructions

Your new Jacuzzi®

system. It contains the most advanced safety and self-protective equip-





local building department should you have any questions regarding your

installation.



with a current collector system. A pressure wire connector is provided

on the surface of the control box, located outside the equipment door

 to permit connection of a bonding wire between

this point and any ground metal equipment, metal water pipe or conduit



This manual suits for next models

Table of contents

Other Jacuzzi Hot Tub manuals

Jacuzzi

Jacuzzi Premium J-315 Instruction manual

Jacuzzi

Jacuzzi Unique User manual

Jacuzzi

Jacuzzi PowerActive Swim SPA Series User manual

Jacuzzi

Jacuzzi Premium J-315 User manual

Jacuzzi

Jacuzzi Elara 6042 User manual

Jacuzzi

Jacuzzi J Series User manual

Jacuzzi

Jacuzzi THE SANTINA User manual

Jacuzzi

Jacuzzi Riva 5 User manual

Jacuzzi

Jacuzzi FUZION 7236 RH User manual

Jacuzzi

Jacuzzi Platinum 2001 User manual

Jacuzzi

Jacuzzi MAXI-PREMIUM J-315 User manual

Jacuzzi

Jacuzzi SIGNA 5 User manual

Jacuzzi

Jacuzzi FINESTRA F4N6036WRL User manual

Jacuzzi

Jacuzzi nova 636 User manual

Jacuzzi

Jacuzzi Riva 5 User manual

Jacuzzi

Jacuzzi experience Virginia User manual

Jacuzzi

Jacuzzi Platinum Series User manual

Jacuzzi

Jacuzzi S198 User manual

Jacuzzi

Jacuzzi J-300 Series User manual

Jacuzzi

Jacuzzi fresco BM85 User manual

Jacuzzi

Jacuzzi SALON User manual

Jacuzzi

Jacuzzi SWIMSPA Power Actve J16 User manual

Jacuzzi

Jacuzzi Allusion 6636 User manual

Jacuzzi

Jacuzzi LCD Series User manual

Popular Hot Tub manuals by other brands

Bestway

Bestway Lay-Z-Spa 54189 manual

Morphy Richards

Morphy Richards Essentials PC4006 user manual

Softub

Softub PRESTIGE Owners Manual Water Treatment Guide

JNJ SPAS

JNJ SPAS SPA-318 Programming instructions

KIRAMI

KIRAMI Comfort Family Instructions for use

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) owner's manual

HoMedics

HoMedics FB-655HJ-GB manual

Everyday Hot Tubs

Everyday Hot Tubs 530 owner's manual

anko

anko SS-601A user manual

Pooli

Pooli OS030979B product manual

ab Solares Smart Spa operating manual

CalderaSpas

CalderaSpas CalderaSpas Utopia Series owner's manual

Outsunny

Outsunny 848-047V70 Assembly guide

Aquatic

Aquatic INFINITY 1 Specifications

Master Spas

Master Spas MP Force owner's manual

Asteria

Asteria 5630 owner's manual

Image

Image IMSB61610, IMSG61610 user manual

ViSAGE

ViSAGE FM-588D user manual