Jacuzzi TREVI User manual

WHIRLPOOL

BATH

INSTALLATION

TREVI™FILL SPOUT

2-1/16"

25/32"

1-15/32" 7/32" DIA.

7/8" DIA.

TOWARD INTERIOR OF BATH

MOUNTING SUFACE

OF FILL SPOUT

2-1/2"

MAX.

INTERIOR EDGE OF BATH RIM

HOLE DRILLING GUIDE

(SEE TEMPLATE NEXT PAGE) INSTALLATION ON BATH

INSTALLATION

1. Drill a 7/8" diameter hole in the deck with a 1/4" diameter hole 13/16" (center to center) away from the 7/8" hole.

Drill the second hole so that the fill spout is oriented properly toward the bath. Use drilling template on next page.

2. Install set screw and fill spout washers.

3. Install fill spout through the 7/8" diameter hole while aligning the set screw to the 1/4" hole.

4. From the underside of the bath rim install the rubber washer, metal washer and nut as shown. Tighten the nut.

5. Connect water supply hose (not provided) from the mixer valve.

FILL SPOUT

BATH SHELL

RUBBER WASHER

METAL WASHER

SET SCREW

1/2" FLEXIBLE FAUCET

CONNECTOR (NOT

PROVIDED)

NUT

SET SCREW O-RING

FILL SPOUT WASHER

MOUNTING NUT

GASKET

BATH SHELL

MOUNTING NUT

GASKET

NUT

COMPRESSION

CONE

GROMMET

FLAT SEAT

NUT

TO FILL

SPOUT

MAXIMUM OF

ONE THREAD

BRASS WASHER

HOLE SIZE

FOR VALVE

1-1/4" DIA.

1/4" DIA.

Drilling Holes for Valves

Drill holes from the finished surface side of the unit very carefully, making sure they are the proper size. We

recommend that you drill pilot holes and then use the recommended drill size. Mount the valve as shown

HOT WATER

SUPPLY

COLD WATER

SUPPLY

ANTI-SIPHON VALVE SHOULD

BE AMINIMUM OF 6" ABOVE

RIM OF BATH

ANTI-SIPHON

VALVE

(NOT SUPPLIED)

BATH

RIM

IF SPOUT OPENING IS BELOW

BATH RIM, ANTI-SIPHON VALVE

SHOULD BE INSTALLED.

1" MIN.

1" MINIMUM

CODE REQUIREMENT

HEAD NUT

LOCK NUT

HANDLE

FLANGE

NUT

GASKET

NUT

VALVE BODY

COLD

COMPRESSION CONE

NUT

RUBBER

GROMMET

FLAT

SEAT

NUT

1/2"

COPPER

TEE

1/2" O.D.

COPPER ELL

1/2" O.D.

COPPER PIPE

1/2" COPPER

ELL

1/2" O.D.

COPPER

PIPE

VALVE BODY

HOT

ADAPTER

1/2" COPPER

TO 1/2” NPT

FAUCET HANDLE

ASSEMBLY NOT

INCLUDED WITH

FILLSPOUT

SUGGESTED TREVI PLUMBING SCHEME

(Pipe and fittings are not included)

BRASS WASHER

FILL SPOUT

BATH SHELL

RUBBER

WASHER

METAL

WASHER

SET SCREW

1/2" FLEXIBLE

FAUCET

CONNECTOR

(NOT PROVIDED)

NUT

SET SCREW O-RING

FILL SPOUT WASHER

Plumbing Code Requirements

WhentheWater RainbowFillSpoutismountedon thebathandthefill spoutopeningislessthan 1" abovethebath

rim,plumbing codeswill require theinstallation ofan anti-siphon valve. Locatethe anti-siphonvalve 6" abovethe rim

of the bath in a vertical position over a waterproof surface or fixture to allow for any possible water leakage through

the air vent. The valve must be installed with access for service.

Printed in the U.S.A.

Printed on Recycled Paper

HOLE DRILLING TEMPLATE

25/32"

7/8" DIA.

7/32" DIA.

MOUNTING SUFACE OF FILL SPOUT

TOWARD INTERIOR OF BATH

INTERIOR EDGE

2-1/2"

MAXIMUM

CAUTION

Since plumbing fittings may contribute detectable amounts of lead to water, the following notice is required by

California law (Proposition 65). "This product contains a chemical known to the State of California to cause birth

defects or reproductive harm." In normal use, any lead exposure can be minimized by allowing the water to run free

for several seconds before drinking.

IMPORTANT

Proper installation of the fill spout and compliance with local codes is the responsibility of the installer.

Jacuzzi Whirlpool Bath does not warrant connections of water supply fittings and piping or fill systems.

Nor is it responsible for damage to the bath which occurs during any installation procedure.

Other Jacuzzi Bathroom Fixture manuals

Jacuzzi

Jacuzzi SPRAY GUARD User manual

Jacuzzi

Jacuzzi LINK 160x70 User manual

Jacuzzi

Jacuzzi flexa therma ST2 User manual

Jacuzzi

Jacuzzi J-DREAM II User manual

Jacuzzi

Jacuzzi J-Tower User manual

Jacuzzi

Jacuzzi SAVANNAH-B40C User manual

Jacuzzi

Jacuzzi The Essentials 100x80 User manual

Jacuzzi

Jacuzzi caleidos User manual

Jacuzzi

Jacuzzi Glint 80x80 User manual

Jacuzzi

Jacuzzi J-DREAM II User manual

Jacuzzi

Jacuzzi Sharp User manual

Jacuzzi

Jacuzzi Cloud 100 User manual

Jacuzzi

Jacuzzi BZ00000 User manual

Jacuzzi

Jacuzzi 67661-W5104 User manual

Jacuzzi

Jacuzzi flexa DOUBLE Parts list manual

Jacuzzi

Jacuzzi 65804W-6201 User manual

Jacuzzi

Jacuzzi Morphosis Opalia Wood User manual

Jacuzzi

Jacuzzi THE ESSENTIALS 100x70 User manual

Jacuzzi

Jacuzzi SYDNEY 32 User manual

Jacuzzi

Jacuzzi xyz+ Maintenance and service guide

Jacuzzi

Jacuzzi Moove User manual

Jacuzzi

Jacuzzi 67662-X5127H2 User manual

Jacuzzi

Jacuzzi MP44827 User manual

Jacuzzi

Jacuzzi 873X-1201 User manual

Popular Bathroom Fixture manuals by other brands

DURAVIT

DURAVIT C.1 C15240 0090 Instructions for mounting and use

Heatstore

Heatstore HSTRL500WTN Installation and operating instructions

Sunshower

Sunshower PURE SOLO manual

Delabie

Delabie Delabie Sporting 714700 manual

Kohler

Kohler K-13056 Homeowner's guide

ESS

ESS Container TCL-11 installation manual

Mustee

Mustee 22C installation instructions

VITRA

VITRA V-Flow manual

baliv

baliv DUK-80.30 T manual

Malmet

Malmet B105BT Operation, maintenance and installation manual

bathstore

bathstore Transition H1690MM Installation, Care & Adjustment Instructions

BELLOSTA

BELLOSTA Edward 0800/M Installation instruction

baliv

baliv DU-5160 manual

Franke

Franke PRTR0006 Installation and operating instructions

Gessi

Gessi RILIEVO 59011 manual

noken

noken VITAE 100188525-N299998810 manual

Allen + Roth

Allen + Roth 1142VA-30-201 manual

Britex

Britex HBDA installation guide