Franke PRTR0006 User manual

Installation and operating instructions Montażi instrukcja obsługi

Notice de montage et de mise en service Monterings- og driftsvejledning

Instrucciones de montaje y uso Návod pro montáž a provoz

Istruzioni per il montaggio e l’uso Asennus- ja käyttöohje

Montage- en bedrijfsinstructies Инструкция по монтажу ивводу в

эксплуатацию

ZMI_001_2000105118-PRTR0006_#SALL_#AQU_#V1.fm/25.04.13

Franke Aquarotter GmbH, Germany

EA-Nr.: 7612982184628

FAR-Best.-Nr.: 2000105118

PRTR0006

[email protected] - www.hygiene-shop.eu

Inhaltsverzeichnis35.fm

...................................................................................... 3

Please refer to the graphics in the German Installation and

Operating Instructions.

...................................................................................... 11

Les graphiques sont disponibles dans la notice de montage et de

mise en service allemande.

...................................................................................... 20

Por favor, consulte los gráficos en las instrucciones alemanas de

montaje y uso.

...................................................................................... 29

Per le grafiche fare riferimento alle Istruzioni per il montaggio e

l’uso in tedesco.

...................................................................................... 38

De tekeningen kunt u in de Duitse montage- en bedrijfsinstructies

vinden.

...................................................................................... 47

Prosimy przyjąć grafikęz niemieckiej instrukcji montażu i obsługi.

...................................................................................... 56

Bilderna finns i den tyska monterings- och bruksanvisningen.

...................................................................................... 64

Obrázky najdete v nìmeckém návodu k montáži a obsluze.

...................................................................................... 73

Kuvat löydätte saksankielisestä asennus- ja käyttöohjeesta.

...................................................................................... 82

Рисунки приведены винструкции по монтажу иэксплуатации на

немецком языке.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

0English

PROTRONIC-T, 230 V AC

Washbasin sink mixer with mixing lever

Please refer to the graphics in the German Installation and Operating Instructions.

0Table of Contents

1. Abbreviations and Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2. Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3. Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4. Important Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description of Product

5. Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

6. Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

7. Scope of Delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

8. Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

9. Installation Example . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Installation, Function and Commissioning

10. Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

11. Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

12. Controlling the Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

13. Programmable Function Parameters . . . . . . . . . . . . . . . . . . . . . . 7

Maintenance

14. Maintenance and Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

15. Replacing an Aerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

16. Replacing the Grit Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

17. Replacing the Non-return Valve . . . . . . . . . . . . . . . . . . . . . . . . . . 8

18. Replacing the Solenoid Valve Cartridge . . . . . . . . . . . . . . . . . . . . 9

19. Fault Correction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

20. Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

1. Abbreviations and Units

2. Key

Warning!

Failure to observe can result in injury or even death.

Caution!

Failure to observe can result in material damage.

☞Important!

Failure to observe can cause the product to malfunction.

☞Useful information for optimally handling the product.

3. Warranty

Liability is accepted according to the General Terms and Conditions of Business and

Supply.

Use original replacement parts only!

4. Important Notes

• Installation, commissioning and maintenance are to be performed only by a

qualified technician according to the instructions provided and in accordance with

legal requirements and acknowledged rules of technology.

• All technical connection regulations specified by the local water and electricity

supply utility companies must be complied with.

DN Nominal diameter in mm

EA-Nr. European Article Number

FAR-Best.-Nr. Franke-Aquarotter Order No.

Conversion 1 mm = 0.03937 inches

1 inch = 25.4 mm

All length specifications in the graphics are in mm.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

5. Application

PROTRONIC-T mains-operated, opto-electronically controlled washbasin mixer

DN 15 with aerator with integrated flow rate regulator, with connection to hot and

cold water. With temperature-selector lever and plug-in power supply, 230 V AC.

6. Technical Specifications

7. Scope of Delivery

8. Dimensions

9. Installation Example

Minimum flow pressure: 1.0 bar

Recommended flow

pressure:

1–5 bar

Maximum operating

pressure:

10 bar

Calculation flow rate:

0,07 l/s 0,07 l/s

Operating voltage: 230 V AC

Operating voltage: 12 V DC

Type of protection: Tap IP55

Plug-in power supply IP20

Quantity Description

1 PROTRONIC-T pillar tap

with non-return valves and filters

1 Cleaning clip

1 Plug-in power supply 230 V AC/12 V DC

1 Fixing set

1 Installation and Operating Instructions

X Extension cable FAR Order No.

0.6 m without –

3.6 m 3.0 m 2000101456

10.6 m 10.0 m 2000101457

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

10. Assembly Instructions

Warning!

Use the fitting only with non-return valves and the grit filters specified.

Failure to observe can result in an increased bacterial load in drinking water and

cause a health risk or even risk of death.

☞Important!

Before installing, flush the pipes in compliance with DIN 1988.

☞Do not shorten the connector hoses located at the fitting.

☞Connect the fitting only to the original plug-in power supply. Connect the plug-in

power supply only to a socket carrying 230 V/50 Hz.

10.1

Install the fitting (a) on the washbasin (b).

☞Important!

Observe the range settings when installing on a stainless steel washbasin

Chapter 13.

☞The corner valves (c) must be provided by the customer.

10.2

Screw the connecting hose (d) on to the corner valve.

10.3

Insert the plug-in power supply into the socket.

10.4

Connect the line between the fitting and the power supply.

11. Function

11.1

Allow your hand to approach the sensor.

• Water flows.

11.2

Remove your hand from the sensor.

• Water flow stops automatically after a set flow duration.

☞The range of the sensor and the flow duration can be adjusted with the optional

remote control (FAR Order No. 2000101087).

☞Important!

Reflecting surfaces can influence the sensor. There is a risk of having permanent

reflections. ((see Chapter 13. for adjusting the sensor range).

“Auto-flush” function

Caution!

When the “Auto flush” function is used, the flow of water must be ensured.

• The "Auto-flush" function ensures that forced flushing takes place to exchange the

water in the tap lines after 24 or 72 hours of non-use.

• The “Auto-flush” function can only be switched on with the optional remote control

(FAR-Order-No. 2000101087).

• This function is switched off at the factory.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

12. Controlling the Temperature

Sink mixer with mixing lever

12.1

Set the mixing lever (a) in the desired position.

13. Programmable Function Parameters

The optional remote control FAR Order No. 2000101087 offers the following

functions:

– Range can be set (3-20 cm)

– Turn-off delay can be set (0-10 s)

– Continuous flow can be switched to 3.5 min or 11 min.

– Switching off the fitting

– Basic settings can be restored

– Test mode for simulation without water

– Setting automatic safety switch-off (2–210 s)

– Automatic flushing can be activated

☞Important!

Reflecting surfaces can influence the sensor. There is a risk of having permanent

reflections. The range must be reduced for installations on reflecting surfaces such

as stainless steel washbasins. If this is not sufficient, an additional base/spacing ring

is available (see Chapter 20.).

14. Maintenance and Servicing

Depending on the quality of the water, the local conditions and the rules and

regulations applicable on site, the fitting must be maintained and serviced at regular

intervals.

Perform maintenance on the following components:

• Aerators (see Chapter 15.)

• Filters (see Chapter 16.)

• Non-return valves (see Chapter 17.)

14.1

Push up the cleaning clip (a) in front of the sensor.

☞The fitting is in sleep mode.

14.2

Properly use suitable cleaning agents that are not harmful to the fittings and rinse

with water after use. High-pressure cleaners must not be used for cleaning.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

15. Replacing an Aerator

15.1

Use an open-end spanner to unscrew and replace the aerator (a).

16. Replacing the Grit Filters

Filter for corner valve

16.1

Close the corner valves (c).

16.2

Trigger the valve.

16.3

Unscrew the connector hoses (a) from the corner valves.

16.4

Replace the grit filters (b).

16.5

Reassemble in the reverse order.

Filter, solenoid valve cartridge

16.6

Remove the solenoid valve cartridge (see Chapter 18.).

16.7

Use a flat nose pliers to pull the filter (d) out.

16.8

Replace the filter.

☞Important!

Ensure correct installation position. The rib of the filter must not lie on the flow-

through hole.

16.9

Reassemble in the reverse order.

17. Replacing the Non-return Valve

Warning!

All non-return valves must always be replaced as a group.

Failure to observe can result in an increased bacterial load in drinking water and

cause a health risk or even risk of death.

17.1

Close the corner valves (b).

17.2

Trigger the valve.

17.3

Unscrew the connector hoses (a) from the corner valves.

17.4

Take out the grit filters(c).

17.5

Take out the non-return valve (d).

☞Important!

Be careful to insert the non-return valves and grit filters the right way round.

17.6

Reassemble in the reverse order.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

18. Replacing the Solenoid Valve Cartridge

18.1

Close the corner valves.

18.2

Trigger the valve.

18.3

Loosen the screw (a) with an Allan key.

18.4

Pull the housing (b) from the base (c).

18.5

Remove the screws (d).

18.6

Remove the mounting bracket (e).

18.7

Remove and replace the solenoid valve cartridge (f).

18.8

Reassemble in the reverse order.

19. Fault Correction

If you are unable to correct a fault or if the fault is not described in the fault correction

section, please inform our customer service department!

Fault Cause Remedy

Water does not flow – Voltage supply interrupted ➯Restore it

– Water-flow volume regulator closed ➯Open it

– Grit filters are clogged with dirt ➯Clean them

– Cleaning clip in front of the fitting ➯Remove

– Solenoid valve faulty ➯Replace it

Water flows

continuously

– Solenoid valve faulty ➯Replace it

Water flow too weak – Corner valves not fully opened ➯Open it

– Grit filters are clogged with dirt ➯Clean them

– Aerator calcified ➯Replace it

– Solenoid valve faulty ➯Replace it

– Supply pressure too low ➯Check it

Water is too hot – Cold water is turned off ➯Open it

– Filter in cold-water part is dirty ➯Replace it

– Non-return valve faulty ➯Replace it

Water is too cold – Hot water is turned off ➯Open it

– Filter in hot-water part is dirty ➯Replace it

– Non-return valve faulty ➯Replace it

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105118-PRTR0006_#SEN_#AQU_#V1.fm

20. Replacement Parts

Designation Order No.

1 Aerator with

flow rate regulator

(PU 10 pcs.) . . . . . . . . . . . . . . . . . 2000104691

2 Solenoid valve cartridge

with grit filter . . . . . . . . . . . . . . . . 2000104456

3 Cleaning clip . . . . . . . . . . . . . . . . 2000105795

4 Maintenance kit comprising:

O-rings

Screws

Grit filters. . . . . . . . . . . . . . . . . 2000104898

5 Mixing lever with screw. . . . . . . . . 2000105821

Designation Order No.

6 Plug-in power supply . . . . . . . . . . 2000105814

7 Installation kit comprising:

Non-return valve

Grit filters . . . . . . . . . . . . . . . . . 2000105106

8 Hose . . . . . . . . . . . . . . . . . . . . . . . 2000105960

Accessories Order No.

9 Remote control . . . . . . . . . . . . . . . 2000101087

10 Base for installation

on stainless steel washbasin . . . . 2000105834

[email protected] - www.hygiene-shop.eu

This manual suits for next models

Table of contents

Languages:

Other Franke Bathroom Fixture manuals

Franke

Franke F5ET2008 User manual

Franke

Franke AQUAJET-COMFORT SHAC0008 User manual

Franke

Franke F5 ACDR0001 User manual

Franke

Franke CHRX676N User manual

Franke

Franke AQUALINE WC AQRM553C User manual

Franke

Franke F5LT2001 User manual

Franke

Franke STRX611 User manual

Franke

Franke F5LT2023 User manual

Franke

Franke 7612210067174 User manual

Franke

Franke Maris MRG 160 Black Edition User manual

Franke

Franke ABSINTHE PF5290SB User manual

Franke

Franke RODAN RODX602 User manual

Franke

Franke RODX608 User manual

Franke

Franke AQUALINE-Therm AQLT0109 User manual

Franke

Franke MIRANIT F5SM2024 User manual

Franke

Franke EM5 ACEX1004 User manual

Franke

Franke SANW200 User manual

Franke

Franke AQRM276B User manual

Franke

Franke 7612210009501 User manual

Franke

Franke F5LM2028 User manual

Franke

Franke AQUAFIT User manual

Franke

Franke AQUALINE AQLT0053 User manual

Franke

Franke Miranit F5ST2028 User manual

Franke

Franke Janus JSD Series User manual

Popular Bathroom Fixture manuals by other brands

DURAVIT

DURAVIT C.1 C15240 0090 Instructions for mounting and use

Heatstore

Heatstore HSTRL500WTN Installation and operating instructions

Sunshower

Sunshower PURE SOLO manual

Delabie

Delabie Delabie Sporting 714700 manual

Kohler

Kohler K-13056 Homeowner's guide

ESS

ESS Container TCL-11 installation manual

Mustee

Mustee 22C installation instructions

VITRA

VITRA V-Flow manual

baliv

baliv DUK-80.30 T manual

Malmet

Malmet B105BT Operation, maintenance and installation manual

bathstore

bathstore Transition H1690MM Installation, Care & Adjustment Instructions

BELLOSTA

BELLOSTA Edward 0800/M Installation instruction

baliv

baliv DU-5160 manual

Gessi

Gessi RILIEVO 59011 manual

noken

noken VITAE 100188525-N299998810 manual

Allen + Roth

Allen + Roth 1142VA-30-201 manual

Britex

Britex HBDA installation guide

GRE

GRE DSALC32W instruction manual